Академический Документы
Профессиональный Документы
Культура Документы
ID No.
Time Allowed:
30 min.
Marks obtained
Max. Marks: 15
In words ___________________
NOTE:
(A)
1.
2.
The __________________ used in flange coupling are subjected to both shear and tensile stresses.
3.
The ratio of strength of joint to the strength of solid plate is called _____________________________.
4.
When an object is placed in third Quadrant then its view drawn, it is called ________________ method.
5.
6.
Involutes are the best and most commonly employed to design the teeth of gears. These involutes are
also called __________________________________.
7.
Depth of tooth from pitch circle to the base circle is known as ________________________________.
8.
(B)
1.
( ___________ )
2.
( __________ )
3.
( __________ )
4.
The angle less than 180 and more than 90 is called complementary angle.
( __________ )
5.
The radial distance between two rivet holes in the riveted joint is called diagonal pitch. ( __________ )
6.
Square threads are mostly used for power transmission purposes because of possessing maximum
frictional resistance.
( _________ )
7.
( _________ )
8.
( _________ )
Contd on P/-2.
(-2-)
(C)
(M.C.Q.)
1.
Key is a metallic piece inserted between the joint of two pieces to (allow, prevent, or resist) relative
motion.
2.
( Feather key, Saddle key, or Gib key ) is a particular type of parallel key which transmits a turning
moment as well as permits axial movement.
3.
Crown pulleys are driven by means of ( flat belts, circular ropes, or v-belts).
4.
5.
Root diameter + ( 0.5 depth of cut, depth of cut, or twice the depth of cut ) is called major diameter of
thread.
6.
Pitch circle lies between ( addendum and base, addendum and dedendum, or dedendum and base )
circles.
7.
8.
Interior or hidden surfaces in machine Drawing are shown by ______________________( Break lines,
Centre lines, dotted lines)
9.
A view drawn on vertical plane is known as _________ (Plan, Elevation, Orthograph projection)
(D)
1. Threads
2. Isometric projection
3. First angle projection.
------------THE END----------