Академический Документы
Профессиональный Документы
Культура Документы
Valve Cover LH
Special Tool(s)
Disconnect Tool, Spring Lock Coupling (5/8")
412-038 (T83P-19623-C)
Disconnect the battery negative cable. For additional information, refer to Section 414-01.
2.
3.
4.
1.
Detach the accelerator and speed control cables from the throttle body.
2.
Detach the accelerator and speed control cables from the bracket, and position the cables aside.
CAUTION: It is important to twist the spark plug wire boots while pulling upward to avoid possible damage to the spark plug wire.
NOTE: Spark plug wires must be connected to the correct ignition coil terminal. Mark spark plug wire locations before removing them.
Disconnect the spark plug wires.
5.
6.
7.
8.
Disconnect the radio interference capacitor electrical connector and position the coil aside.
9.
10.
2.
3.
4.
5.
11.
12.
13.
14.
Remove the bolt and position the electrical connector and bracket aside.
15.
Remove the screws and the EGR valve vacuum regulator solenoid.
16.
Remove the differential pressure feedback with the hoses from the exhaust manifold-to-EGR valve tube.
17.
Relieve the fuel system pressure. For additional information, refer to Section 310-00.
18.
19.
20.
Remove the bolt and position the lower fuel line bracket aside.
21.
Remove the bolt and position the fuel supply line aside.
22.
Loosen the fitting and disconnect the exhaust manifold-to-EGR valve tube.
23.
24.
25.
26.
CAUTION: Do not use metal scrapers, wire brushes, power abrasive discs or other abrasive means to clean sealing surfaces. These tools cause
scratches and gouges which make leak paths.
Clean and inspect the sealing surfaces. Install a new gasket if necessary.
27.