Академический Документы
Профессиональный Документы
Культура Документы
Launch Device Manager (in Control Panel) on your PC. Next, launch the RKAndroidTool.exe from the RileyROM folder (Run as
Administrator, if your Windows user account does not have administrator privileges). At the bottom of the RK Android Tool window, it
should now say "Found RKAndroid Mass Storage Usb".
Now click the button that says "Reboot2Flash". This reboots your device into "Flash mode".
In a few seconds. depending on your Windows Version - Windows should now attempt to install a driver, but fail. You may get a dialog
asking you to point it to the correct driver. If not, open the previously launched Device Manager, and look for the "Unknown Device".
Right-click on the device, and select "Update Driver". Point it to the folder corresponding with your windows version.
If the update goes well, you can close Device Manager. Go back to the RK Android Tool, and you should now see the following at the
bottom: "Found RK Android Loader Rock Usb". If instead it says "No found RKAndroid rock usb", don't worry, the device's "flash
mode" has timed out due to inactivity. Either boot while holding "ESC" button, or; power the device on normally, let it finish booting,
and click "Reboot2Flash" again and wait for the ""Found RK Android Loader Rock Usb" line to appear.
Q: CWM (ClockWorkMod) and stock Recovery - whats what, and what is it for?
A: Stock (original) recovery has very few options and functions. CWM (CockWorkMod) Recovery is a 3rd party custom recovery mode,
with highly extended possibilities and functions. If it is available for your device, it will be included and flashed at default. There will be
an additional file named StockRecovery.img in the ROM folder - this is the Stock (original) recovery. If you don't want to use CWM, or
are having problems with CWM Recovery, you can rename the recovery.img to CWMrecovery.img and rename stockrecovery.img to
recovery.img - then restart the RKAndroidTool. On the first boot after flashing, recovery mounts and formats all of the drives necessary
for the device to run properly. Some CWM Recovery installations don't do this properly, so stock recovery is recommended if you
experience any problems with boot.
Q: The flash procedure went wrong somehow, now the tablet will not respond.
A: Connect via USB to your PC
Start the Flash app on your PC
Press and hold the ESC button for 5 seconds.
While holding the ESC button put a paperclip in the reset hole and press and hold it for 5 seconds.
While still holding the Esc button and the Reset button, press the power button and hold.
You will see the flash tool recognize your device in loader mode.
Release the ESC key
Release the Reset button
Keep holding the power button with your thumb (if you let go, it will go out of loader mode and you will have to start over).
Click Erase IDB, let it finish
Click Flash ROM, keep holding the power button until it is done flashing the ROM.
Disconnect from the PC and press the power button again until the device powers up.
Q: The device is stuck in bootloop - what do I do?
A: Depending on the reason why you are stuck in bootloop, this may or may not work;
Connect the tablet to your computer, and start RKAndroidTool.
Hold "ESC" button while booting. If successful, the tablet should boot into loader (flash) mode. Proceed to erase IDB and
flash ROM again.