Академический Документы
Профессиональный Документы
Культура Документы
Doubling the leg size of an equal leg fillet weld increases the
Weight/Volume of weld metal by a factor of 2
strength by a factor of 1.707
volume and weight by a factor of 4
time to weld by two
Requires a larger welding rod
2. Copper can be effectively used as backing because
It melts at a higher temperature than steel
oxides form on the surface that prevent bonding to t he steel
The thermal conductivity of copper allows it to efficiently absorb energy
the chemical differences do not allow copper and steel to melt together
None of the above, copper is never used as backing
3. GTAW welding of aluminum can be performed with
DCRP
DCSP
ACHF
2 and 3
All the above
4. Which of the following codes does not indicate specific acceptance criteria
for production welding.
AWS D1.1
ASME B31.3
ASME Sec I
ASME Sec IX
NONE OF THE ABOVE
5. If a welder qualifies to GTAW carbon steel (P-1) pipe without purge is he/she
qualified to weld 304 SS with purge provided all other variables remain the
same
Yes
No
It depends on the piping code B31.1 or B31.3
ASME Sec IX Does not address these requirements
not ENOUGH INFORMATION IS GIVEN
6. Which of the following defects cannot be easily located with radiography
Laminations
cracks perpendicular to the film plane
Porosity
Incomplete Penetration
Slag
7. Which end of a gouging rod must point towards the work piece
The pointed end
The copper covered end
either provided the air is flowing over the rod
either provided the air is flowing between the rod and work piece
Any of the above
8. Effective preheating will
Increase cooling times
Increase distortion
Increase residual stress
Both 1 and 3
Both 2 and 3
9. PWHT is an acronym for
GTAW
SAW
OFW
18. Excess preheat and interpass temperatures on high strength low alloy steel
such as A-514 will be most likely to
Cracking
Porosity
Hydrogen Embrittlement
Reduction in Mechanical Properties
have no affect provided the lower critical temperature is not reached before
welding
19. Glass is
Ductile
Brittle
Opaque
Elastic
Fatigue Resistant
20. A material with a fractured surface that leaves a grey appearance on a
piece of paper when it is rubbed with the paper is probably
White Cast Iron
Gray Cast Iron
Carbon Steel
Nickel Chromium Iron
Any of the above
Get score Clear