Академический Документы
Профессиональный Документы
Культура Документы
Tools Required
The only tools required for this procedure are a Phillips screwdriver and a small flat-blade
screwdriver.
073-0751 Rev. A
7. Remove the two screws that secure the system to the front rail of the rack. (Figure 1)
Figure 1
8. Remove the two screws that secure the back of the systems side panels to the rack.
9. With one person supporting each side of the unit, slide the system out of the rack and
place it on a sturdy, flat surface covered by an ESD mat.
10. Put on an ESD wrist strap.
11. Remove the 16 mounting screws on the left and right sides of the top cover. (Figure 2)
Figure 2
12. Slide the top cover a short distance toward the back of the unit.
13. Lift the top cover straight up off the enclosure.
Xserve RAID Center Front Light Pipe - 2
4. Carefully pull the bezel a short distance straight back off the enclosure, making sure
the bezel clears the barrel of the locking mechanism. (Figure 4)
Figure 4
5. Disconnect the front panel cable from the center front panel board. (Figure 5)
6. Remove the bezel from the enclosure.
Figure 5
7. Place the bezel on an ESD mat with the center front panel board facing up.
8. Remove the two mounting screws on the center front panel board. (Figure 6)
9. Remove the board from the bezel.
Figure 6
10. Using a flat-blade screwdriver, carefully pry up the upper center light pipe and shield
and remove them from the bezel. (Figure 7)
11. Remove the lower light pipe and shield from the bezel.
Figure 7
6. Route the two branches of the front panel cable straight up through the opening in the
center front of the chassis. (Figure 8)
Figure 8
7. Replace the bezel on the front of the enclosure, making sure the opening in the bezel
fits over the barrel of the locking mechanism.
8. Replace the four screws that secure the bezel to the enclosure.
9. Connect the front panel cable to the left front panel board.
10. Connect the locking cable and front panel cable to the right front panel board.
3. Replace the 16 mounting screws on the left and right sides of the cover.
4. With one person supporting each side of the unit, slide it all the way into the rack until
the unit engages the small posts at the rear of the L-brackets. (Figure 10)
Figure 10
5. Replace the two screws that secure the unit to the front rail of the rack.
6. Reconnect all cables and power cords.
Warning: Never turn on Xserve RAID unless all of its internal and external parts
are in place and it is closed. Operating the system when it is open or missing
parts can damage it or cause injury.