Академический Документы
Профессиональный Документы
Культура Документы
Remotely change the electrical downtilt of an antenna with this AISG compliant
RET actuator.
This AISG compliant Teletilt RET actuator enables operators to remotely change the electrical
downtilt of an antenna.
The ATM200
ATM200--A20 is shipped in AISG 2.0 mode. In the field, the actuator can be set to AISG 1.1 or
2.0 as needed.
The actuator's absolute position sensor eliminates the need for calibration, enhances precision and
prevents dropped calls caused by calibration sweeps. Male and female AISG connectors facilitate daisy
chaining actuators. As many as 32 actuators can be attached to a single control line.
This actuator is equipped with a flashing LED, which indicates data transfer and tilt movements. It comes
in a weather resistant gasket
gasket--sealed container that has a drain hole to permit drainage of condensed
moisture.
The ATM200
ATM200--A20 actuator can be field fitted onto Andrew Teletilt remote electrical downtilt (RET)
compatible antennas that are already in service or factory fitted before delivery to the field.
The part number for antennas with a factory
factory--fit ATM200
ATM200--A20 actuator ends in -AxM, with x referring to
the number of the attached actuators (either A1M or A2M).
l
l
l
2015CommScope, Inc. All rights reserved. All trademarks identified by or are registered trademarks, respectively, of CommScope.
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: November 23,
2015
page 1 of 3
November 27, 2015
Product Specifications
ATM200
ATM200--A20
TeletiltActuator,AISG2.0defaultprotocol
l
Connectstothebasestationantennaforremoteelectricaltilt
FactorysettoAISG2.0mode
CanbefieldresettoAISG1.1
Absolutepositionsensoreliminatestheneedforcalibration
LEDindicatestiltmovement
General Specifications
Brand
Teletilt
Electrical Specifications
Protocol
AISG1.1 | AISG2.0
DefaultProtocol
AISG2.0
InterfaceProtocolSignal
Data
InputVoltage
1030Vdc
AdjustmentCycles,minimum
10000cycles
dc
AdjustmentTime,fullrange,maximum 22s
ElectricalSafetyStandard
EN60950
ElectromagneticCompatibility(EMC)
CFR47Part15,SubpartB,ClassB
V1.3.22003
UL60950
EUCertification
CE
EN55011
EN613261
ETS300386
Mechanical Specifications
AISGInputConnector
8pinDINMale
AISGInputConnectorQuantity
AISGOutputConnector
8pinDINFemale
AISGOutputConnectorQuantity
Color
Black
MaterialType
ABS
LightningSurgeCapability
5times@3kA
5times@3kA
LightningSurgeCapabilityTestMethod IEC6100045
LightningSurgeCapabilityWaveform
1.2/50voltageand8/20currentcombinationwaveform
Environmental Specifications
ClimaticSequenceTestMethod
IEC60068214
ColdExposureTestMethod
IEC6006821
CorrosionTestMethod
IEC60068211,TestConditionKa
DampHeatExposureTestMethod
IEC60068230,TestConditionDb
HeatExposureTestMethod
IEC6006822
IngressProtectionTestMethod
IEC60529:2001,IP56
OperatingTemperature
40Cto+70C(40Fto+158F)
PackagedProductShockTestMethod
ASTMD4169 | GR63CORE,Section4.1.1
IEC60068252,TestConditionKb
2015CommScope, Inc. All rights reserved. All trademarks identified by or are registered trademarks, respectively, of CommScope.
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: November 23,
2015
page 2 of 3
November 27, 2015
Product Specifications
ATM200
ATM200--A20
RainSimulationTestMethod
IEC60068218,TestConditionRa,Method1
RelativeHumidity
Upto100%
UVResistanceTestMethod
IEC6006825,TestConditionB
VibrationTestMethod
ASTMD4169
IEC6006826
Dimensions
Width
71.1mm | 2.8in
Depth
53.3mm | 2.1in
Height
203.20mm
NetWeight
0.2kg
8.00in
0.5lb
Regulatory Compliance/Certifications
Agency
RoHS2011/65/EU
AISG
ISO9001:2008
Classification
CompliantbyExemption
Compliant
Designed,manufacturedand/ordistributedunderthisqualitymanagementsystem
2015CommScope, Inc. All rights reserved. All trademarks identified by or are registered trademarks, respectively, of CommScope.
All specifications are subject to change without notice. See www.commscope.com for the most current information. Revised: November 23,
2015
page 3 of 3
November 27, 2015