Академический Документы
Профессиональный Документы
Культура Документы
Refill Instructions
(For #5000SK Kit)
Specific Cartridges:
932, 932XL, 933, 933XL, 950, 950XL, 951,
951XL
Revised: 02/02/2015
Contents of Kit:
- (4) each #1950, 10cc Syringe
- (4) each #1953, 20cc Syringe
- (1) each #1952, 60cc Syringe
- (4) each #1905, Cannula Needle (Dual Side Port Blunt Plastic Needle)
- (4) each #1959, Syringe Tip
- (25) each #LAB104, Label, Quality Remanufactured Ink Jet Cartridge
- (1) each Pushpin
- Inks: 8 ounces of Black, 4oz Cyan, 4oz Magenta, and 4oz Yellow
Cartridge #
932
933
933
933
950
951
951
951
Color
Ink #
Black
Cyan
Magenta
Yellow
Black
Cyan
Magenta
Yellow
BKP280
CP280
MP280
YP280
BKP280
CP280
MP280
YP280
Color
Empty Wt
Ink Amount
Full Wt
Black
Black
C/M/Y
C/M/Y
Black
Black
C/M/Y
C/M/Y
20
38
20
20
48
48
26
27
13ml
32ml
6ml
13ml
38ml
80ml
13ml
25ml
33
70
26
33
86
128
39
52
Cartridges
You will need to have 2 sets of cartridges for this refill method to work correctly in your printer (unless replacement chips are
used). See Ink Cartridges Depleted message on page 5.
Warning: Do not use the Starter/Setup cartridges that came with the printer
The Starter Cartridges may fail in the customers printer due to the chip being marked as Depleted, and this condition may
not be recoverable for the starter cartridge.
Caution:
To prevent damage to the chips follow common ESD safety procedures - for example see:
http://en.wikipedia.org/wiki/Electrostatic_discharge
HP Refill_932.933.950.951_IS-5000SK-V2.4
Page 2 of 6
Revised: 02/02/2015
Refill Process
HP 932/933/950/951
Syringe Tip Preparation: Using a Pushpin you
will need to punch a hole in the plastic Syringe
Tip on each side about 1/16 from the tip (See
Figure 1). This will prevent the Syringe Tip from
sealing against the exit port sealing ball.
1. Place the plastic Syringe Tip with the
punched holes onto the 10ml syringe.
Figure 4
Figure 2
Figure 5
Figure 3
Figure 6
HP Refill_932.933.950.951_IS-5000SK-V2.4
notice
Page 3 of 6
Revised: 02/02/2015
Error Messages
When using refilled 932/933/950/951 Cartridges you may receive one of the following error messages:
Used or Counterfeit Cartridges Detected In this case click on No and continue. The same
message appears for both the Black and Color cartridges.
HP Refill_932.933.950.951_IS-5000SK-V2.4
notice
Page 4 of 6
Revised: 02/02/2015
Ink Cartridges Depleted You may run into this message when a cartridge that was removed
from the printer, refilled, and then is placed back into the printer. The printer has marked this
cartridge on the chip when it becomes empty. You can overcome this issue by obtaining a
second set of cartridges, and replace the cartridge in question. Once this secondary cartridge is
used up replace it with the first cartridge that generated the Ink Cartridge Depleted message,
and it should work fine. Continue to do this Leap-Frog method with each cartridge.
HP Refill_932.933.950.951_IS-5000SK-V2.4
notice
Page 5 of 6
Revised: 02/02/2015
3. Once the adhesive is exposed, proceed to carefully place the chip over the existing OEM as
shown. The flat X-ACTO blade works well for this.
4. Once the chip has been placed, press down on the chip gently to secure the adhesive in place.
5. Inspect the chip for proper location as shown.
HP Refill_932.933.950.951_IS-5000SK-V2.4
notice
Page 6 of 6