Академический Документы
Профессиональный Документы
Культура Документы
Supplements
Using the NMReady-60e Benchtop
Sponsored by Nanalysis Corp.
Table of Content
Introduction
Omega-3 Supplements
Wild Salmon
Oil Cod Liver
Oil Shark
Liver Oil
Conclusion
Introduction
Scientific advancements are often inspired by nature. For instance, penicillin was discovered in mould,
aspirin was made from willow bark and solar cells imitate the photosynthetic process. Now, vertebrates and
invertebrates are being studied in detail to develop innovative medicinal compounds. Unlike mammals,
marine algae and phytoplankton synthesise different types of omega-3 (-3) polyunsaturated fatty acids
(PUFAs).
PUFAs are natural products that regulate important metabolic mechanisms such as heart and brain activity.
They are known to have anti-cancer activity and to reduce inflammation. A diet that includes fish is the
main source of PUFAs for human beings. This is because fish themselves feed on microorganisms rich in
-3.
The term -3 describes how these molecules contain a double bond on the third carbon from the chain
terminus. The -3 class includes a wide range of molecules which show a lot of variation in terms of the
extent of saturation and the chain length. -linolenic acid (ALA), eicosapentaenoic acid (EPA) and
docosahexaenoic (DHA) are the three most important -3 molecules found in nature (Figure 1).
Omega-3 Supplements
A standard -3 supplement will include PUFA, fish oil concentrate (PUFA-EE), EPA, and DHA. Fish oil
concentrate is a synthetic product, and is exclusive to -3 supplements. It is produced via a
transesterification reaction between ethanol (EtOH) and a PUFA triglyceride to give the -3s as ethyl
ester derivatives. The reaction results in the elimination of the triglyceride chain as glycerol (Figure 2).
400 MHz
%Difference
A good agreement is seen between the 400 MHz and 60 MHz data acquired for the percent composition of the
nutritional supplement,
and this data is similar to that obtained for the -3 supplements. While 400 MHz NMR can be used to
establish the -3: -6 acid ratio, inadequate resolution on the 60 MHz spectra makes it difficult to
accurately measure the ratio.
Despite this fact, both saturated and monounsaturated fatty acids can be viewed through 1) a higher
number of alkyl -CH2- components (~47% cf., 24% in -3 supplement) and 2) a higher olefin to bisallylic ratio (1.7 cf., 1.2 in to -3 supplement). The multiplet centered at 4.21 ppm makes it possible
to view the triglyceride linkage.
Figure 6. 400 and 60MHz 1D 1H NMR spectrum for cod liver oil with % difference.
The presence of retinyl palmitate, i.e. vitamin A, in supplements can present a major issue because it is not
well tolerated by humans. Although essential for many basic functions, vitamin A is a fat-soluble vitamin and
is likely to accumulate in fat tissues.
People should take cod liver oil only under the supervision of a doctor, and must limit and regulate other
vitamin A sources in their diets. Toxins are generally removed by the liver, and trace amounts of
contaminants such as MeHg, PCBs, PBDEs, and PCDDs may be present (Figure 7). If these contaminants
exist in the samples their low concentration would make it difficult to detect on a 400 MHz or 60 MHz
spectrum.
Shark Liver
Oil
This oil is obtained from specific species of deep sea sharks. It does not contain much -3 PUFAs,
however it is still erroneously classified as a PUFA supplement. The liver of a shark has a special
composition because it serves as a swim bladder. It contains oils that boost the fishs buoyancy and these
oils contain mostly squalene.
Squalene, a terpenoid, is used as a precursor for in vivo steroid development. Shark liver is the chief source of
squalene, though
other natural sources are also available, namely amaranth and vegetable oil. Squalene is known to reduce
cancer risk, shrink existing tumors, and also have anti-carcinogenic activity. Whilst squalene has a different
bioactivity, it provides similar health benefits to PUFAs.
However, shark liver oils contain pristane and toxins such as PCBs and PBDEs. There is no proof of
aromatic protons from PBDE or PCB contaminants in the 400 MHz or 60 MHz spectrum, and this indicates
that these contaminants are at a level lower than the detection limit or not present altogether. However,
alkyl impurities were detected in the allayed samples.
Figure 8. Spectra exhibit evidence of alkyl impurities at both high and low fields in the 5.0-1.4 ppm
range
In Figure 8, the spectra show the presence of alkyl impurities at low and high fields in the 5.0 - 1.4 ppm
range. This can be attributed to the remaining pristine, a saturated terpenoid substance that is the second
major source of oil in shark liver.
Pristine can cause rheumatoid arthritis in humans and, plasmacytosis and auto-immune disease in mice. A
more sensitive method such as high-performance liquid chromatography (HPLC) or mass spectrometery
shoukd be used to establish whether this impurity is a residual solvent or pristine.
Conclusion
From the results, it is evident that the constituents of fish oil supplements can be effectively analyzed using
the standard 400MHz and benchtop 60MHz 1H NMR spectroscopy.