Академический Документы
Профессиональный Документы
Культура Документы
Description
With the help of this shield and an SIM card, your Arduino could join your local mobile service
providers cell phone network. This shield allows you to communicate with other devices via:
SMS, Audio (DTMF), and GPRS service.
This shield connects to Arduino with long-wire headers, which keeps the pin layout intact and
allows another shield to be stacked on top.
Features
l
l
l
l
l
l
l
l
l
Pin Usage
The pin usage is basically the same with the official version.
D0: HW Serial Port SIM900->Arduino
D1: HW Serial Port SIM900<-Arduino
D2: SW Serial Port SIM900->Arduino
D3: SW Serial Port SIM900<-Arduino
D7: Ringing Indicator, active LOW
VIN: Drawing power from Arduino.
NOTE: By factory default, the serial communication is done via D2, D3, SW serial port and the RI is connected to D7 via a
jumper. To use the HW serial port, user should rearrange the two jumpers so they connect the SIM900 TX pin to D0 and
SIM900 RX pin to D1, respectively. If you do not want to use the Ringing Indicator feature, just remove the jumper from the
header denoted RI.
Sandbox Electronics
Operation
1.
2.
3.
4.
5.
6.
Buttons:
S-POWER: Power switch button of SIM900.
S-RESET: Reset button of SIM900.
A-RESET: Reset button of Arduino.
LEDs:
RING:
Goes ON when there is a incoming call
NETWORK: 64ms ON/800ms OFF SIM900 not registered to cell phone network.
64ms ON/3000ms OFF SIM900 registered to cell phone network.
64ms ON/300ms OFF GPRS communication is established.
STATUS:
ON when SIM900 is powered ON.
Sandbox Electronics
Dimensions
Contacts
Sandbox Electronics
SLD-000012
SIM900 GPRS/GSM shield for Arduino
Description
With the help of this shield and an SIM card, your Arduino could join your local mobile service
providers cell phone network. This shield allows you to communicate with other devices via:
SMS, Audio (DTMF), and GPRS service.
This shield connects to Arduino with long-wire headers, which keeps the pin layout intact and
allows another shield to be stacked on top.
Features
l
l
l
l
l
l
l
l
l
Pin Usage
The pin usage is basically the same with the official version.
D0: HW Serial Port SIM900->Arduino
D1: HW Serial Port SIM900<-Arduino
D2: SW Serial Port SIM900->Arduino
D3: SW Serial Port SIM900<-Arduino
D7: Ringing Indicator, active LOW
VIN: Drawing power from Arduino.
NOTE: By factory default, the serial communication is done via D2, D3, SW serial port and the RI is connected to D7 via a
jumper. To use the HW serial port, user should rearrange the two jumpers so they connect the SIM900 TX pin to D0 and
SIM900 RX pin to D1, respectively. If you do not want to use the Ringing Indicator feature, just remove the jumper from the
header denoted RI.
Sandbox Electronics
Operation
1.
2.
3.
4.
5.
6.
Buttons:
S-POWER: Power switch button of SIM900.
S-RESET: Reset button of SIM900.
A-RESET: Reset button of Arduino.
LEDs:
RING:
Goes ON when there is a incoming call
NETWORK: 64ms ON/800ms OFF SIM900 not registered to cell phone network.
64ms ON/3000ms OFF SIM900 registered to cell phone network.
64ms ON/300ms OFF GPRS communication is established.
STATUS:
ON when SIM900 is powered ON.
Sandbox Electronics
Dimensions
Contacts
Sandbox Electronics