Академический Документы
Профессиональный Документы
Культура Документы
A 2014/2015
TANGGAL
MATA KULIAH
PROGRAM STUDI
WAKTU
DOSEN
SIFAT
:
Juni 2015
: Aircraft Systems
: RANGKA / MOTOR PESAWAT D3
: 90 MENIT
: SUWARDI
: Closed
1. The air for .......... pressure pneumatic systems is usually stored in metal bottles.
a) High
b) Medium
c) Low.
d) All above are true
2. Medium pressure pneumatic systems on turbine powered aircraft usually use ......... air
for their operation.
a) Normal
b) Bleed
c) Low
d) High.
3. One of the most common types of aircraft pneumatic systems supplies low-pressure
air to operate
a) Pitot static
b) Wiper
c) Gyro instrument
d) De-icing
4. -type pumps are usually associated with low pressure pneumatic
systems, such as those used to operate aircraft instruments.
a) Vane
b) Piston
c) Rotor
d) All above are true
5. After the air in a pneumatic system leaves the moisture separator it must pass though
a(n) or , ., to remove
the last traces of moisture.
a) Desiccant
b) Chemical
c) Dryer
d) All above are true
6. A(n) .. valve may be installed to allow a pneumatic system to
operate from a ground source.
a) Relief
b) Shuttle
c) Check
1
d) By pass
7. Emergency extension air enters a hydraulic landing gear actuator through a(n)
valve.
a) Stop
b) Shuttle
c) Check
d) By pass
8.
a)
b)
c)
d)
The point in an aircraft electrical systems from which the various circuits get their power is called a/an.......
Stop contact
Bus
Diode
Circuit arrangement
9.
a)
b)
c)
d)
Thing that happen in an electrical circuit when current flows through it are ;
Heat is produced in conductor
Magnetic fielde sorrounds the conductor
All above are true
All above arefalse
10. The longer line in the symbol for battery indicates the ............
a) positive
b) negative
c) combination
d) all above are true
11. Electron flowing in an electrical circuit is assumed to flow in the ...........
a) Same
b) Opposite
c) Parallel
d) Horizontal
12. If the bar in the symbol for a semiconductor diode is connect to the negative terminal of battery, the diode
is ...................
a) upward
b) down ward
c) forward
d) reverse
13. An electrical relay has a .................. core
a) movable
b) fixed
c) movable and fixed
d) All answer are true
14. The voltage drop across a closed switch in series circuitis ..........
a) Zero volts
b) Battery volts
c) Two answer are true
d) Two answer are false
15. The amount of current that flow through each path of parallel circuit determined by the ............. of the path
a) circuit
b) Conductor
c) Resistance
d) Transistor
16. The battery terminal that is normally grounded is the ................... terminal
2
a)
b)
c)
d)
negative
positive
combined
All answer are true
a) AC
b) DC
c) All above are true
d) All above arefals
24. De icing systems are turned on..icing is encountered.
a)
b)
c)
d)
at
after
before
all above are true
25. During normal operation of pneumatic deicer system, the air pressure gage will..................
a) fluctuate
b) remain steady
c) All above true
3
Essay
1.
2.
3.
4.
Answer of essay:
1.
4
4.
a. mechanical
b. Chemical
c. Pneumatic.