Академический Документы
Профессиональный Документы
Культура Документы
Goto any web browser and type 192.168.1.1 (in case of d-link modems)
select 'advanced settings from left side menu'.You can see a similar page then
2.Configure ATM
click on 'Add' button at DSL ATM configuration page shown.This will take you
to a new page
If you dont know the VPI and VCI just google it in your mobile before you proceed as
wrong values wont connect modem to WAN
3.Configure WAN
Click on WAN interface inside advanced settings and it will take you to a page
like below
click on next
select pppoe if you want the modem to be always on (even when desktop off),so that you
can use internet in laptops and wi-fi devices
select bridge mode if you want the connection only when the desktop pc is turned on and
dialled the connection from pc---note:no devices can connect unless you dial from your
desktop(wired pc)
click next.After this phase you can see a window like below picture
TOP HALF
enter username as given by your service provider.For BSNL users, the id format is
idphoneno_scdrid
ie; if your phone no is 2554546, then your id is
id4912554546_scdrid
enter password.This is password itself unless you changed it in BSNL portal login
service name: enter any name here i used BB
authentication method-auto
enable firewall (disable if you want high speed in torrents,by allowing ports incoming
and outgoing in modem,you can enable firewall if you need safety)
if you were given a static IP, enter it in static ip tab,else leave it unticked,so that you will
be assigned a dynamic ip automatically
BOTTOM HALF
click next
All set.Wait a second.You should see the internet light blinking now
If you see a RED internet light,then your password/username is incorrect
If after doing all the steps correctly,and internet light doesnt go on, then contact your
service provider to check the connection from exchange
Click device info to see a page as below to ensure your connection is all set.
4.wireless configuration
select the wireless tab on the left and select basic settings
Enable wireless
change your country
click apply/save
Only select this if you want to assign a password.Else your connection will be open for
all users nearby
Select network authentication as WPA-Personal
click apply/save