Академический Документы
Профессиональный Документы
Культура Документы
Page 1(13)
Revision Date: 25.06.2015
Date of printing : 16.11.2015
(24 h)
Page 2(13)
>= 1 - < 3 %
111-46-6
203-872-2
603-140-00-6
Category 4
Category 2
Methanol
Concentration :
CAS number :
EC number:
Index Number
Category 2
Category 2
Category 3
R11
R36
R67
H225
H319
H336
H302
H373
R22
Category 2
R11
R23/24/25
R39/23/24/25
H225
Page 3(13)
3
3
3
1
< 0,1 %
50-00-0
200-001-8
605-001-00-5
H301
H331
H311
H370
Category
Category
Category
Category
Category
Category
3
3
3
1B
1
2
R40
R23/24/25
R34
R43
H301
H331
H311
H314
H317
H351
Page 4(13)
Revision Date: 25.06.2015
Date of printing : 16.11.2015
Symptoms
The possible symptoms known are those derived from the labelling (see section 2).
No symptoms known currently.
Hazards
No additional hazards are known except those derived from the labelling.
4.3. Indication of any immediate medical attention and spe cial treatment needed
Treatment
There is no specific antidote available.
Page 5(13)
200-659-6
67-56-1
Revision
2006-02-09
Type of value
Limit Value eight hours
Values
260 mg/m3
200 ppm
Remarks
DNEL/DMEL values
Formaldehyde
EC number:
CAS number :
200-001-8
50-00-0
Route of exposure
Inhalation
Personnel
Workers
Exposure time/Effect
Acute systemic effects
Inhalation
Workers
Inhalation
Workers
Value
1 mg/m3
0,8 ppm
1 mg/m3
0,8 ppm
0 mg/m3
0,4 ppm
Remarks
DNEL
DNEL
DNEL
Page 6(13)
Inhalation
Workers
Dermal
Dermal
Oral
Dermal
Inhalation
Inhalation
Workers
Consumers
Consumers
Consumers
Consumers
Consumers
0 mg/m3
0,4 ppm
240 mg/kg
102 mg/kg
4,1 mg/kg
0,012 mg/cm2
3,2 mg/l
0,1 mg/m3
DNEL
DNEL
DNEL
DNEL
DNEL
DNEL
DNEL
PNEC values
Formaldehyde
EC number:
CAS number :
Environmental
compartment
Fresh water
salt water
Water (intermittent
release)
Fresh water
sediment
Marine sediment
Soil
Sewage treatment
plant
200-001-8
50-00-0
Personnel/Exposure time/Effect
Value
0,47 mg/l
0,47 mg/l
4,7 mg/l
2,44 mg/l
2,44 mg/l
0,21 mg/l
0,19 mg/l
Hand protection :
Eye protection :
Body protection :
liquid ( 20 C )
Form :
liquid
Particle size :
not applicable
Colour :
white yellowish
Odour :
Product specific
Odour threshold :
not applicable
Page 7(13)
pH value :
approx. 8 - 10 (20 C)
(undiluted)
Melting point :
not applicable
Boiling point :
not determined
Sublimation point :
not applicable
Flash point :
> 100 C
Method : DIN 51758
Evaporation rate :
Flammability :
Not relevant
The lower explosion point may be 5 - 15 C below the flash
point.
Not relevant
Combustion number :
not applicable
not tested.
Vapour pressure :
not applicable
Solubility in water :
soluble
Octanol/water partition
coefficient (log Pow) :
Ignition temperature :
not determined
Self-ignition temperature :
not auto-flammable
Thermal decomposition :
Viscosity (dynamic) :
not determined
Explosive properties :
Oxidizing properties :
Page 8(13)
not tested.
not tested.
Sensitization :
not tested.
not tested.
not tested.
Aspiration hazard :
No aspiration toxicity classification
Remarks
The product has not been tested. The information is derived from the properties of the
individual components.
Page 9(13)
LD50
LC50
Daphnia toxicity :
not tested.
Algae toxicity :
not tested.
Bacteria toxicity :
not tested.
Daphnia toxicity :
Bacteria toxicity :
20 - 70 % (28 d)
Moderately/partially eliminated from water.
Method : Zahn-Wellens Test
Page 10(13)
99 % (28 d)
Method : OECD Test Guideline 301D
not tested.
Page 11(13)
not restricted
not restricted
not restricted
not restricted
not restricted
Page 12(13)
Revision Date: 25.06.2015
Date of printing : 16.11.2015
Other regulations
Apart from the data/regulations specified in this chapter, no further information is available
concerning safety, health and environmental protection.
15.2. Chemical safety assessment
No Chemical Safety Assessment (CSA) is yet available for the substance, or for the
component substances, contained in this product.
Highly flammable.
Harmful if swallowed.
Toxic by inhalation, in contact with skin and if swallowed.
Causes burns.
Irritating to eyes.
Toxic: danger of very serious irreversible effects through inhalation, in
contact with skin and if swallowed.
Limited evidence of a carcinogenic effect.
May cause sensitisation by skin contact.
Vapours may cause drowsiness and dizziness.
Legend
ADN
ADR
AOX
CAS
DMEL
Page 13(13)
Revision Date: 25.06.2015
Date of printing : 16.11.2015
This information corresponds to the present state of our knowledge and is intended as a general
description of our products and their possible applications. Archroma makes no warranties, express or
implied, as to the information's accuracy, adequacy, sufficiency or freedom from defect and assumes
no liability in connection with any use of this information. Any user of this product is responsible for
determining the suitability of Archroma's products for its particular application. Nothing included in this
information waives any of Archroma's General Terms and Conditions of Sale, which control unless it
agrees otherwise in writing. Any existing intellectual/industrial property rights must be observed. Due
to possible changes in our products and applicable national and international regulations and laws, the
status of our products could change. Material Safety Data Sheets providing safety precautions, that
should be observed when handling or storing Archroma products, are available upon request and are
provided in compliance with applicable law. You should obtain and review the applicable Material
Safety Data Sheet information before handling any of these products. For additional information,
please contact Archroma.