Академический Документы
Профессиональный Документы
Культура Документы
ip
parser
version
IP information
Show parser commands
System hardware and software status
Note: There can be more EXEC commands available than displayed depending on your device and IOS
image used.
i.
Issue the show ip interface brief command. Were you able to do it as the tech user? Why or why not?
____________________________________________________________________________________
____________________________________________________________________________________
Yes. It is one of the allowed commands.
j.
Issue the show ip route command. Were you able to do it as the tech user?
____________________________________________________________________________________
____________________________________________________________________________________
No. It is not one of the allowed commands.
R1# show ip route
^
% Invalid input detected at '^' marker.
k.
l.
Issue the show run command to see the views you created. For tech view, why are the show and show
ip commands listed as well as show ip interface and show ip interface brief?
____________________________________________________________________________________
____________________________________________________________________________________
All parts of the command must be listed for the more specific parameters to work.
Using NTP, configure a router as a synchronized time source for other devices.
Make changes to the router and monitor syslog results on the PC.
Note: Perform all tasks on both R1 and R3. The procedure and output for R1 is shown here.
2014 Cisco and/or its affiliates. All rights reserved. This document is Cisco Public.
Page 20 of 61