Вы находитесь на странице: 1из 8

3.

Technical data

OM Sandvik CH890:01

31

OM Sandvik CH890:01

3. Technical data

3.1 General data


The data presented below are typical values. Specific data may vary
depending on installation and machine configuration
Characteristics

CH890:01

Type

Cone crusher

Application

Mineral processing

Usage

Outdoors/Indoors

Total mass

78100 kg (172200 lbs)

Length (with motor cradle)

6670 mm (262 in)

Width

3600 mm (142 in)

Height

5520 mm (217 in)

Max. motor power

750 kW (option 600 kW)

Installed power

750 kW

Available crushing chambers

6 (EC, C, MC, M, MF and F)

Close Side Setting (CSS)

Approx. 13-95 mm (0.51-3.74 in) depending on crushing chamber


and eccentric throw

Open Side Setting (OSS)

Max. depends on chamber,


CSS and ECC

OSS = CSS + ECC

Pinionshaft speed

990 rpm / 50 Hz

880 rpm / 60 Hz

Feed hopper

Mass

3850 kg (8500 lbs) incl. cone


2490 kg (5500 lbs) excl cone

Material

Rubber lined steel hopper

Topshell

Spider shields

Spider cap

Bottomshell

Bottomshell liners

32

1000 hp (option 800 hp)

S 223.822.en-01

Thickness

120 mm incl. rubber lining

Height

1585 mm (62.4 in)

Inner diameter

2660 mm (104.7 in)

Capacity

10.8 ton with B.D = 1.6 ton/m3

Mass

22700 kg (50000 lbs)

Diameter at lower flange

3100 mm (122 in)

Material

Cast steel

Spider bushing lubrication

Grease

Number of shields

2 (1 per spider arm)

Mass of a shield

308 kg (680 lbs) or


651 kg (1435 lbs)

Material

Manganese steel

Backing material

No

Securing method

Welding

Mass

1034 kg (2280 lbs)

Securing method

Bolts, seal with O-ring

Mass

23800 kg (52500 lbs)

Inner diameter at
discharge opening

2 780 mm (109.4 in)

Min. shell thickness

70 mm (2.76 in)

Number of liners

22

Different shapes

Mass of heaviest liner

52 kg (115 lbs)

Material

Wear-resistant hardened steel

Hardness

HB 360-440

Securing method

Welding

2011 Sandvik SRP AB

OM Sandvik CH890:01

3. Technical data

Characteristics

CH890:01

Bottomshell arm liners

Material

Manganese steel

Min. thickness

35 mm (1.38 in)

Max. thickness

61 mm (2.40 in)

Number of liners

Different shapes

Mass of heaviest liner

260 kg (573 lbs)

Securing method

Welding

Total mass of all bottomshell liners


Mantle

Concave ring

Mainshaft

Eccentric

Pinionshaft housing assembly

2011 Sandvik SRP AB

1574kg (3470 lbs)


Types

A, B, EF, OB and HC

Min. thickness

55 mm (2.165 in)

Max. thickness

135 mm (5.315 in)

Outer diameter at bottom

2016 mm (79.37 in)

Material

Manganese alloyed steel

Backing material

Plastic composition

Securing method

Self-tightening head nut, burning ring

Mass of heaviest mantle

6716 kg (14806 lbs)

Types

EC, C, MC, M, MF and F

Min. thickness

40 mm (1.575 in)

Max. thickness

115 mm (4.528 in)

Diameter

2020 mm (79.53 in)

Material

Manganese alloyed steel

Mass of heaviest concave ring

4100 kg (9039 lbs)

Backing material

Plastic composition

Securing method

Clamping ring, filler ring and


metallic contact

Max. mainshaft travel

360 mm (14.2 in)

Mainshaft position sensing

Yes

Mass (incl. headcentre)

13425 kg (29600 lbs)

Length

3220 mm (126.8 in)

Alternative throws

Yes

Standard eccentric throws

24, 28, 32, 36, 40, 44, 48, 52, 56,


60, 64, 68 and 70

Eccentric speed

230 rpm

Balancing

Yes

Eccentric assembly mass

2900 kg (6340 lbs)

Eccentric bushing mass

600 kg (1325 lbs)

Total weight

900 kg (1985 lbs)

Pinion mass

45 kg (99 lbs) (50 Hz)


30 kg (66 lbs) (60 Hz)

Pinionshaft mass

230 kg (507 lbs)

Pinionshaft bearing mass

18 kg (40 lbs)

Bevel gear mass

300 kg (50 Hz)


380 kg (60 Hz)

S 223.822.en-01

33

OM Sandvik CH890:01

3. Technical data

3.2 Crusher motor


Other types of motor may be used together with the CH890 crusher.
This is a typical example:

34

Characteristics

CH890:01

Manufacturer

WEG

Model

HGF 450 C

Mass

approx. 6 000 kg (13 230 lbs)

Type

Squirrel cage

Voltage

To suit supply

Phases

Frequency

50 Hz (6-pole motor)
60 Hz (8-pole motor)

Power

750 kW (1000 hp)

Typical power draw with crusher idling

50 kW

Speed

990 rpm (50 Hz, 6-pole motor)


880 rpm (60 Hz, 8-pole motor)

Design vibration resistance velocity

20 mm/s

Locked rotor current

Depends on voltage

Full load current

Depends on voltage

Enclosure

TEFC

Insulation class

Typical full load efficiency %

Depends on voltage approx. 97%

Bearing type

Anti-friction, regreasable

Lubrication method

Grease

Frame size

450C

S 223.822.en-01

2011 Sandvik SRP AB

OM Sandvik CH890:01

3. Technical data

3.3 Drive system


Direct drive

CH890:01

Torque- limiting coupling

Manufacturer

Flexible coupling

Voith

Model

Safeset

Size

SR-N 180

Manufacturer

Rexnord

Model

Holset

Rubber blocks
Total coupling mass

Renold SM60
252 kg (556 lbs)

Sub frame

Mass

5400 kg (11900 lbs)

Protection

Drive guard mass

40 kg (88 lbs)

Slip detection device

Speed monitor

Characteristics

50 Hz

60 Hz

Motor power

0.55 kW

0.55 kW

Voltage

400 V, 525 V, 550 V, 690 V

460 V, 575 V

Phases

3.4 Blower motor

2011 Sandvik SRP AB

Speed

2 800 rpm

Enclosure

TEFC

Insulation

Protection

IP55

Frame

IEC 71

S 223.822.en-01

3 350 rpm

35

OM Sandvik CH890:01

3. Technical data

3.5 Corrosion protection


Paint system:
Single layer waterborne paint, 1-comp
Corrosion protective pigment

Calcium phosphate

Type of paint

Alkyd (enamel)

Total dry film thickness

100-120 m (0.004-0.005 in)

Procedure

Spray painting

3.6 Processing data


Characteristics

CH890:01

Max. feed size

110-315 mm (4.3-12.4 in)

CSS min.max.

13-95 mm (0.5-3.7 in)

Nominal capacity

250-2200 tonnes/h

The data above are typical. The capacity of the cone crusher is dependent on
the crushing chamber, the eccentric throw, the crushers setting and the feed
materials bulk density, crushability, size analysis, moisture content, etc.

3.7 Noise levels and measuring conditions


Machine

Test running in the factory


(without material)
dB(A)

Typical values when crushing


dB(A)

CH890 Hydrocone

95

95 - 106

The values given above are equivalent continuous sound levels (Leq)
measured during a period of 60 seconds with an integrating sound level
meter. The values are measured at a distance of approx. 1 m from the
machine and approx. 1.6 m above ground level or above a platform alongside
the machine.
The sound levels given are approximate values. The sound level depends on
many factors, e.g. whether or not the crusher has dust encapsulation, how the
equipment is installed, how the feed arrangement is designed, the size and
impact strength of the feed material, the size of the drive motor, etc.

36

S 223.822.en-01

2011 Sandvik SRP AB

OM Sandvik CH890:01

3. Technical data

3.8 Tightening threaded fasteners


Unless otherwise specified, the threaded fasteners used in the crusher must
be tightened to the torque specified in the table below.
STRENGTH GRADE (SS-ISO 898/1)
Thread
M (mm)

8.8 Bright zinc-coated


Nm (ft lbs)

12.9 Untreated
Nm (ft lbs)

21 (5)

40 (30)

10

40 (30)

79 (58)

12

70 (52)

136 (100)

16

169 (125)

333 (246)

20

331 (244)

649 (479)

24

572 (422)

1120 (826)

30

1130 (833)

2210 (1630)

36

1960 (1446)

3850 (2840)

42

3130 (2309)

6140 (4529)

48

4690 (3459)

9190 (6778)

3.8.1 Requirements for joints with threaded fasteners


Use the following materials for joints with threaded fasteners:

Steel screws of grade 8.8 with bright zinc-coated finish.


Nuts of grade 8 with bright zinc-coated finish.
Hardened washers, at least HB200 (bright zinc-coated finish).
Lightly oiled components.
Cleaned threads in the castings.

Tightening carried out with a torque wrench which can be calibrated,


or with a bolt/nut runner with a torque limiter.
Max. permissible torque spread: 10%.

2011 Sandvik SRP AB

S 223.822.en-01

37

OM Sandvik CH890:01

3. Technical data

3.8.2 Locking fluid for threaded fasteners


Unless otherwise specified, use Loctite 243 or an equivalent when locking
fluid is recommended in this manual, with the following exceptions:
To seal pipe threads in the lubrication system, use Loctite 577 or an
equivalent.
For pipes in sizes up to 3/4 in, and in the Hydroset system, use
Loctite 543 or an equivalent.
If a previously used screw is to be installed, make sure that the threads are
cleaned of oil and locking fluid, before the screw is installed.
Follow the manufacturers instructions for the application of locking fluid.

38

S 223.822.en-01

2011 Sandvik SRP AB

Вам также может понравиться