Академический Документы
Профессиональный Документы
Культура Документы
in
BY-SHAHAJI JADHAV
(INDIGO) DGCA AME PAPER 3 RN-JUNE 2015
RADIO NAV.(DGCA AME PAPER 3)
JUNE 2015
A. Yellow Light
Light
Rf feedback oxcillator
AF osc
Multivibrator
B&C
c.5MBps
b.2MBps
c.L=468/f
d.10MBps
a.L=234/f
C. Blue
2.MultivibratorA.
B.
C.
D.
B. Green Light
b.L=f/234
d. L=f/468.
www.dgcaquesttionpapers.in
www.dgcaquesttionpapers.in
BY-SHAHAJI JADHAV (INDIGO) DGCA
AME PAPER 3 RN-JUNE 2015
d) All of these
a) Icing
b) Ground or Sea Water
c)faulty display unit
19 Terminal Strips which provide connection of
www.dgcaquesttionpapers.in
www.dgcaquesttionpapers.in
BY-SHAHAJI JADHAV (INDIGO) DGCA
AME PAPER 3 RN-JUNE 2015
28. The satellite data units (SDU)
# a) it provides the interface unit to all other
related a/c system for an aviation satellite
system
b) it provides the interface between the a/c
station and the satellite system
c) it provides the interface to the ground station
and the a/c station.
29. MTCS
36. In Single Side Band Radio ReceiverA. career freq Re-Inserted B. Have Narrow band pass
C. Audio response is from 300hz to 3000hz A
D. All of the above
105.75
45.75
124.25
none
A. Outer marker
B. Middle marker
C. Modulated signal of 40hz
Transmission line
Loop line
Feeder line
Generator line
Mode A
Mode C
Mode S
All
A.
B.
C.
D.
0 or 1 (BLT 4-2629)
Low or high
True or false
On or off
10mm
40mm
4m
400mm
A.
B.
C.
D.
Conventional FMCW
Constant Difference freq FMCW
Pulsed altimeter
All
CMOS+XOR
NAND+OR
AND+CMOS
CMOS+OR
www.dgcaquesttionpapers.in
www.dgcaquesttionpapers.in
BY-SHAHAJI JADHAV (INDIGO) DGCA
AME PAPER 3 RN-JUNE 2015
53.Radome should not be cleaned with Solvent
bcoz
A.
B.
C.
D.
12inch
24inch
2feet
2mtr
A.
B.
C.
D.
Spacewave propagation
To avoid interference
.
All
A. Ground plate
B. Horizontal plate
C. Hurtz plate
56.INS
A. Independent of ground based
equipments
B. Dependant
C. .
D. ..
57.SSR advantages over Primary.
Less energy required
May be used in conjuction with TCAS
Uses 4096 codes
All
A. Sence antenna
B. Loop antenna
C. Both
A.
B.
C.
D.
D. Terrain
A.
B.
C.
D.
Quadrantal error
Field alignment error
Loop alignment error
all
Amplitude
Frequency
Phase
.
Refueling
Near high explosive
Inside hanger
All
www.dgcaquesttionpapers.in
Oppose
Aids
Distorts
Doesnt effects
A. Space waves
B. Ground waves
C. Sky waves
74. The system made up of coinstallation of 24
satellites, ground stations and airborne receivers is
called
A. GPS
B. GNSS
C. GLONASS
75. Noise suppression of aircraft radios is done by..
A. ..
76
Standing
Transmission
Feeder
Signal
A.
B.
C.
D.
www.dgcaquesttionpapers.in
71.Aircraft compass system(RMI) WORKS on the
principle of
A. ..
B. ..
72. ELT antenna can cause serious interference with
vhf communication hence it should be separated by at
least..from any vhf carrying antenna.
A. 12 inch
B. 2mtr
C. 24cm
Light
Sound
Water
All
A.
B.
C.
D.
On vertical stabilizer
On cabin apex V pointing forward
Below fuselage
Anywhere
Flutter
Interference
Vibration
A&c
www.dgcaquesttionpapers.in
0.01 ohm
1.0 ohm
0.001 ohm
1-2 ohm
Grid
Filament
Plate
None
www.dgcaquesttionpapers.in
www.dgcaquesttionpapers.in
www.dgcaquesttionpapers.in
87.