Академический Документы
Профессиональный Документы
Культура Документы
Basic Interfaces:
7. speed of usb1.0,2.0,2.1,3.0?
8. difference between usb2.0 and usb3.0?
9. impedance of D+ and D- line in usb?
10. what is usb Enumuration?
11. differnce between Host, device and otg mode?
12. how will identify my usb is host or device or otg?
13. how will you identify my deivce is USb low speed or full speed or high speed or super speed?
14. what is J and K chirps in USb what it's use?
15. What is the use of JTAG? Pinouts?
16. UART? How will control the flow of data? speed?
17. Have you s=used DDR? what are differnt type of DDR available?
18. Difference between DDR DDR2 and DDR3?( Speed/Power/latency)
19. Difference between DDR and LPddr?
20. what are the signal in ddr interface?
21. What is the use of Strobe?
22. What is the speed you have used?
23. What is the topology you have used ?( point to point or point to multi point)
24. what is DDR DIMM? advantage of ddr Dimm?
Power Supply:
6. Convert one 12v 3 A dc to 5V/ 1A and 3.3V/0.5A and 1.8V/0.5A and 1.35V/0.1A( draw block
level)?
10. In case of battery charging with usb means what is the maximum current sourced by the USb ?
11. what is decoupling Capacitor? what it will do? how will choose the value of the capacitor?
Analog:
Digital:
7. What is skew? what is the reason for skew? how to overcome it?
8. How you use termination ? what are the differnt types of termination? when to use which type
of termination?
Common :
10. Have you worked for Medical/automation or comerical product what the key aspect you
will take care while choosing the product/ for certification?
11. Have you went through any certification process?( FCC,CE, ISO, MEdical)
12. RGMII Interface
What is the clock frequency of RGMII interface?
How 100bT is achieved through 124MHz clock?
13.How impedance is achieved in PCB?
What is the reason for 50 ohm Impedance?
14.HOW host or device or OTG is detected in USB OTG?
15.Draw any 1 switching regulator and denote the current direction during ON and OFF state
16.What is the interface for WiFi, IEEE standards of WiFi
17.What is inside an LDO?
18.Parameters of LDO?
19.Loadr Regulation / Line Regulation
20.Max freq of your processor,Clock you provided?
21.Protection circuits
22.Data rate of WiFi and Bluetooth?
23.What will happen if 2 batteries are connected in series/Parallel?
24.Parameters for choosing a resistor? Derating factor?
24.Impedandce of an inductor?,reactance of an Inductor?
26.Max devices can be connected in I2C bus? Is it practically possible to connect 127devices
on the same bus?
27.Grouping of DDR signals?
28.Routing considerations for high speed signals
29.How to overcome ringing of a signal?
****************************************************************
Please add your questions also in that document in different color .