Age:14+
‘SPECIFICATIONS COLOURS AND CONTENTS MAY VARY FROM ILLUSTRATIONS
Laas ial anc Oh Cl ae amy
2.4GHZ R/C SERIES 4 CHANNEL XIS GYRO
> GPTOYS F1C-wifi
Attention :
1.This 4-axis aerocraft is suitable for indoor/outdoor flying,but make
sure the outdoor wind force is not more than grade4 and you can
enjoy perfect performance.
2.It adopts 2.4G frequency band;with long controll distance, allowing
more players to fly in the same area without any interference.
Besides, players can control it to move forward/backward, turn
left/right, left/right sideways fly
3.in order to control it more easily ,more skillfull , more safely please
read this maunal carafully before using,and keep it properly for
future reference.
The product has been tested before delivery,parameters have been seted
and matched properly.Please do not adjust the trimming button if
unnecessary in order to avoid the aerocraft appearing incapable of flight.
Correction methods:turn the trimming button to be in middle.
whilethe key in the middle the transmitter will ‘beep’THE REMOTE CONTROL FUNCTIOI
4 Antenna oF ue
2 Tumble buten, 200m
tumbing te | SFr NO LCD pane power sch
‘ =I 5 seconds Buzzer ‘Headless ying
‘Saocelerator Leh or
fight tating rocker
‘Thro fine-tuning
rang 3 forthe
tnd of recovery
£ ?. 3 Power ight
accelerator, Lettor
== fight retating rocker
5 Thotte fine-tuning
4) (Ce) rae) 15s teeing acustmen 13 Poet SSeawas
5 QC fe Sa) it rondo on nun
{Ss ae | 13 SAWomatcaly set and rt side
x ‘ty back 1) fnosunng|
7 5 ya Beadess tying 12a on aero
i ) Sone buton torgpt yg oe!
3) ) HLC0 saeon 12 Seeger
= ¢ 12 Poner swe ask
13.Lot and ght sie fy fnetning ae
ne 1i-Fonvard bsclovare fe tring iste
{15 Front and rar fight ysticn Powe indicat
18.Thespood baton wo sas 10 ar
(Buzzer boop fer sow gear, peacoat
rg wie a 851) ae
aa Sa SS ION
Loading method of the batteries
Open the battery cover on the back of the transmitter,
correctly.than load 4 AA batteries correctly as per the
polarity shown.
CAUTION:
‘Make sure the battery and its polarity in the battery
tl : a a ewe
HEADLESS FLYING AUTOMATICALLY FLY BACK
CAUTION:
An aircrafts flat, remote as right
behind the aircraft, (lef). Connect
etd ca et Come,
eS rs
De a en ne
sey Seay ste some
tng
“fisy mcocroce ene
CD rarest ere atone
@. ‘=~ automatic return, return direction
Jonge 1) forte reroe eatin
Dd CAUTION:
‘naira sft rete as ght
behind te ara et, Connect
the vice power Supp open he
; remote cone! poe’ bri god
N Fequency after seconds rg
s pres te hay ofa emote
fej) Ecoles ascnsiong
g mettre emer he heals
2
frying,
1.SD card need to be inserted before power being connected.(SD card
volume suggesting to be upper 4 Gin order to record more content)
2.Ming the plag while connecting power (Reed line connects to red ling,
whe black fine connects to black line)
3.Recording switch & indicator light description.(1)Power on (with no SD card inside) the blue light is on.the red ight wil lash;
Power on(with SD card inside-ready mode),the blue light is still on, the red light goes out
(2)in the ready mode,press the'DV‘button shorlythen it will turn into recording mode, the
red light will flash:press the'DV‘butlon shortly again recording made stopped, the red light
{goes out and the blue light will be stil on. Video recording completed and saved.
(@)While the SD card memory is ful ile will be saved automatically and back to ready mode.
WARNING:POWER SHOULD BE OFF & SD CARD BE EXTRACTED AFTER RECORDING BEING TURNED OFF
Aerocraft battery charge
The lithium battery of the aerocratt is shown removed from the battery holder and disconnect the power
power plug,USB charger plug into the power Brain USB jack,after charging plug of the charyer lithium
battery plug is connected,the LED lights off when charging,and charging is completed when the LED is on,
recupmincudintomensnay Py =
: ;
CE
iN
ae
pz pow
THE RELATED NOTES ABOUT LITHIUM BATTERY’S USAGE
‘In the case of misuse, the batteries’charging may cause fire ,body hurt and property loss.
Players must be aware of the risks of using this product. Manufacturers,retailers and
dealers do not bear any responsibility once accidents occur,so please carefully read the
safety guidelines and charging instuctions before playing
Once the batteries’electrolyte come into your eyes,do not rub,but wash them with clean
water and seek medical care immediately.
Please remove the plug immediately if you find out the peculiar smell,noise and smog
Please comply with the following requirements strictly,or it may cause fire,electric
shock or explosion.
harge
Please use the charger from original factory to ensure your safety usage.
Do not charge the dilatanVoutworn batteries.
‘Do not overcharge the battery. Please pull out the charger once the battery is fully charged.
‘Do not charge next ti the inflammables or on the surface of electro-conductive objects.
You should observe the battery at all times.
#Do not charge the batteries which are still not cool the surface. Otherwise: it would
cause expansion and even fire accident.
‘The charging temperature should be between 0C and 40 C
Use and storage
Do not pack the broken batteries with the plastic bag.
Do not inserttake out the batteries with the plastic bag.
#Do not over-expose or over-impact the batteries.
The dilatant/outwor batteries are forbidden to use.
Children are prohibited from touching the batteries
Do not throw the batteries into the fire or make it touched with the liquid
Batteries are not allowed to be thrown into the microwave oven or pressure tank.
Do not gismantle,dril or cut the batteries.
Do not clean the charger with menstruum,industrial alcohol and other flammable solvent.
The power supply terminal is not to be short circuited.Avoid touching the electrolyte in the
battery,which is bad for your health.
Please store the product at room temperature. The extreme temperature is not suggested.
Do not place the product near the hot source.
*Please remove the batteries when you don't operate the product.
Pull out the charger when you do not charge the battery.Recycle
Do not deal with the related equipment as daily rubbish. The damaged/unusable batteries
should be put into the designated container.
‘This equipment is composed of electronic elements and batteries.For the electronics
garbage, please dispose them according to the special requirements.
‘Please familiarize yourself with the local garbage disposal method.
OW TO CONTRO ‘Please connect the aerocraft power cord with
battery power cord correctly by the method
‘shown in this picture.And then set the areocraft
on the ground flound flatly. Please do not move
when board LEDs flashing,
2.Please pill the throttle stick to the bottom within 6
second and then put the power switch to the"NO”
Position,then pull the throttle control from
maximum position to minimum one to make
WARNING aerocraft and remote control at the same frequency.
fitieteeneerel ier eer teee oa 3.Put the aerocate on the open place.And confirm the
a long time please disconnect the front and back direction, make the back position
battery wire from the circuit board, aligned behind you. Then you can fly.
Important:aircraft white blades end to the forward direction,the aircraft red
or green biades end for the backward direction
Push up the throttle stick,and the
Ascending spinning speed of the main blades.
will increase. The aerocraft begins
to ascend,
Pull down the throttle stick,and the
spinning speed of the main blades.
Descending will decrease. The aerocraft begins
to descend
ram okt Push the rudder stick to the
left,and the aerocratft will tun
\ } to left,Push the rudder stick
to the right,and the aerocraft
urn left will turn to right.
‘When the rudder stick is pushed
5 upward.the aerocraft swashplate
Forward Backward will downtit and it advances.
e =>, When the rudder stick is pushed
downward,the aerocraft will uptit
and it recedes.
; When push the right lever (steering
rudder)to the right.the aerocraft
will fly to the right.
- => When push the right lever(steering
; rudder)to the leftthe aerocraft will
Left /
‘Right fly to the left.
sideward fiy sideward flyNOTICE Push the throttle level slowly;plwase press the trimming buttons
when the aerocraft hovers or leans to different directions in the air.
‘Attention:
When the aerocraft ascend to 30cm high it will suffer the“ground effect’and its
perfomance will become unstable.
a ‘y
> >
‘When the aerocraft spins towards to left,please
continuously press the trimming buttorvright-turn
trimmingytil it stops spinning
When the aerocraft spins towards to right,please
continuously press the trimming button(left-turn
trimming till t stops spinning
‘When the aerocraft flies sideways
(towards the leftjin the process of
hovering, please continuously press|
= the trimming button(right sideways
fiy)till it recovered.
When the aerocraft flies sideways
= (towards the right)in the process
of hovering, please continuously
press the trimming button(left
sideways flytill it recovered.
When the aerocrafft flies backward
in the process of houering,please
continuously press the trimming
button(forward)til it recovered,When the aerocraft flies forward
f in the process of houering,please
continuously press the trimming
l button(baskward)till it recovered
FLYING ENVIRONMENT:
NOTICE:
DDo not fly in extreme temperature Flying in extreme temperature may affect
the performance and damage the product.
Do not fiy in windy days.The performance and the control of the aerocratft will
bbe affected by wind. Windy condition may cause the missing and damage of
the aerocraft
To master the aerocraft,please attempt the
eae following flying practices
Fixed-point revolcing 2
X\. See se
ae Se hae
WS. BE
> S23
Bes SED ee Bae
Nat ¥
Completion ofa = |
To flight a square pattem. cross action. :
You can sentinel take-off and landing of the aircraff,rotation,and
other basic Practice,and then attempt to fly the square,cross-shaped
pattem of flight training fiy.
3D FLIP FLYING
Players can control it to perform some breathtaking
operations when mastering the basics.Firstfly it to the
height of 3m,Second, press the flip key and push the right turn to the end(in one
direction),and then loosen itithe aerocraft turn over.
In the larher enough space, please hold down the Tumbling button(Rudder stick), don’t release it.
The quad copter will show the 3D continuous rolling demonstration under one button controlled.
Flip backward
eS
Flip towards the left Flip forwards the rightTHROWING
‘When the aerocraft being launched by
hand for about 3 meters height,push
the throttle, the aerocrafe will be calibrated
to flight automatically.
PROBLEMS AND SOLUTIO!
PROBLEMS, CAUSES | SOLUTIONS
4.The transmitter switch is on OFF | 4.Turn on the transmitter
2.Check with the pole indications
2.Install the batteries improperly ‘and reinstall the batteries again
Transmitter
not working
3.Batteries are completely consumed | 3.Replace with new batteries
1.The transmitter switch is on*OFF" 1.Turn on the transmitter
2.The aerocraft battery in the
2.The aerocraft battey no connection ‘correct oriented connection
3. Do rot fy under the environment of
Oe Nee re
convttanue [270 88"8 Wind force ie ae eS ay
as hamper your controlling or flying.
1.The rotation of main biades is too siow| + Push up the throttle stick
Asending failure
2.The fuselage battery is well consumed | 2.Recharge the fuselage battery
PUII down the throtle slick slow
Landing to0 son | The throttle stick is pulled down too fast | to perform a smooth landing
Make sure there is no transnitter with
Out of control | Beyond the effective controlling distance | the same frequency is used with in the
radius of 30 meters,
PRECAUTION
1.The remote controlled distance will be shorten when the power(aerocraft or transmitter)is
insufficient.
2.Itis difficult to take off or fly not high when aerocraft's power is insufficient.
3.When the aerocraft is damaged, please repair it in time and stop operating, or it may lead
to injury,
4.If you do not use the transmitter for a long time,please remove the batteries to avoid the
batteries'leakage.
5.Do not drop the transmitter from the high altitude or crash it badly,otherwise,it will shorten
the transmitter’s using life,EXPLOSION FIGURE
mE
4
ae eS
U
WS
SINE
sre
eevee 2
F1C-wifi Accessories list
Parts number | Parts name | Quantity |Part Number | A°C®S8°'V | Quantity
FiC-wifi-01 [Cabinet | 1 | F1C-wif-10 | Bearing 4
FAC-wif-02 | ghiten noter 1 | FiCewifi-1t | Screws | 24
FAC-wifi-03 |teowecrerwers) 2) FAC-wifi-12 | Ottomans | 4
FIC-Wif-04 \eisaneseyeen | 2 FIC-wif-13 | Limitsets | 6
F1C-wifi-05 |Reducercone | 4 | F1C-wifi-14 Receiver board) 1
F1C-wif-06 | Bae ger 4 | F1C-wifi-15 Battery 1
F1C-wifi-07 | Reducer shaft 4 | F1C-wifi16 | Camera 1
FAC-wif-08 | RON wine | 2 | F1C-wifi-17 |use charger] 1
FAC-Wif-09 |actSntataciney | 2