Академический Документы
Профессиональный Документы
Культура Документы
MOCK TEST
1.
2.
3.
4 1
For the matrix
the eigen values are
1 4
(a) 3 and 3
(b) 3 and 5
(c) 3 and 5
(d) 5 and 0
Stokes theorem connects
(a) a line integral and a surface integral
(b) a surface integral and a volume integral
(c) a line integral a volume integral
(d) gradient of a function and its surface integral
A p- u diagram has been obtained from a test on a
reciprocating compressor. Which of the following represents
that diagram?
(a)
(a)
1
k ( x + d )2
(d)
2
The force P on 5 m wide gate is
5.
(b)
(d)
m1
m2
(b)
1/ 2
7.
8.
9.
1 2
kx mgx
2
1 2
kx + mgx
2
(a) 721 kN
(b) 653 kN
(c) 602 kN
(d) 545 kN
Two bodies of mass m1 and m2 are dropped from different
heights h1 and h 2 respectively. Neglecting the effect of
friction, the ratio of times taken to drop through the given
heights would be
(a)
4.
(b)
(c)
6.
(c)
1 2
kx
2
m2 h2
m1h1
2
h1
h1
(c)
(d)
h2
h2
A average Nusselt number in laminar natural convection
from a vertical wall at 1000 with still air at 200C is found to be
48. If the wall temperature becomes 300C, all other parameter
remaining same, the average Nusselt number will be
(a) 8
(b) 16
(c) 24
(d) 32
A diesel engine is usually more efficient than a spark ignition
engine because
(a) diesel being a heavier hydrocarbon, releases more heat
per kg than gasoline
(b) the air standard efficiency of diesel cycle is higher than
the Otto cycle, at a fixed compression ratio
(c) the compression ratio of a diesel engine is higher than
that of an SI engine
(d) self ignition temperature of diesel is higher than that of
gasoline
In green sand moulding process, uniform ramming leads to
(a) Less chance of gas porosity
10.
15.
16.
2
A a = 600 mm
As = 300 mm
Aluminium
Steel
1m
3m
Aluminium
Steel
17.
18.
11.
12.
13.
14.
Group-I
P-Pressure Constant
Q-Volume Constant
R-Temperature
Constant
(a)
(c)
P-S-5
R-U-3
P-S-1
Q-T-2
R-T-3
P-S-1
P-T-4
Q-S-5
Group-II
S-Pressure Constant
T-Volume Constant
W-Temperature
Constant
1.
2.
3.
4.
5.
19.
20.
21.
Group-III
Rankine cycle
Otto cycle
Carnot cycle
Diesel cycle
Brayton cycle
(b) P-S-1
R-U-3
P-S-4
P-T-2
(d) P-T-4
R-S-3
P-S-1
P-S-5
(a) 3
(b) 4
(c) 2
(d) 1
For air with a relative humidity of 80%
(a) the dry bulb temperature is less than the wet bulb
temperature
(b) The dew point temperature is less than wet bulb
temperature
(c) The dew point and wet bulb temperatures are equal
(d) The dry bulb and dew point temperatures are equal
The differential equation
3
dy 2
d2 y
1 + = C 2
dx
dx 2
(a)
(b)
(c)
(d)
22.
is of
1 3 2
The determinant of the matrix 0 5 6 is 26. Then the
2 7 8
3
2 7 8
determinant of matrix 0 5 6 is ________ .
1 3 2
23.
f 2 f
=
is
t x 2
(b) elliptic
(d) non linear
0 0 3
25. What is the rank of the matrix 9 3 5 is _______.
3 1 1
26.
27.
28.
29.
30.
31.
T is
(a)
( )
l e
2
-l2 t
(b)
e -l t
l2
e -lt
l
32. What is the speed of sound in Neon gas at a temperature of
500K (Gas constant of Neon is 0.4210 kJ/kg-K)?
(a) 492 m/s
(b) 460 m/s
(c) 592 m/s
(d) 543 m/s
33. When an ideal gas with constant specific heats is throttled
adiabatically, with negligible changes in kinetic and potential
energies
(a) Dh = 0, DT = 0
(b) Dh > 0, DT = 0
(c) Dh > 0, DS > 0
(d) Dh = 0, DS > 0
34. The best size wires for measuring effective diameter of
threads is of diameter
(c)
l e -lt
(d)
(a)
p sec q
2
(b)
p cos q
(d) none of these
4
Water flows through a 0.6 m diameter, 1000 m long pipe from
a 30 overhead tank to a village. Find the discharge (in liters)
at the village (at ground level), assuming a Fanning friction
factor f = 0.04 and ignoring minor losses due to bends etc.
A Brayton cycle (air standard) has a pressure ratio of 4 and
inlet conditions of one standard atmospheric pressure and
27C. Find the air flow rate required for 100 kW power output
if the maximum temperature in the cycle is 1000C. Assume
g = 1.4 and cp = 1.0 kJ/kg-K.
(a) 0.24 kJ/kg
(b) 0.32 kJ/kg
(c) 0.36 kJ/kg
(d) 0.42 kJ/kg
A copper tube of 20 mm outer diameter, 1 mm thickness and
20 m long (Thermal conductivity = 400 W/m2K). is carrying
saturated steam at 150C (Convective heat transfer
coefficient = 150 W/m2 K). The tube is exposed to an
ambient temperature of 27C. The convective heat transfer
coefficient of air is 5 W/m2 K. Glass wool is used for
insulation (Thermal conductivity = 0.075 W/mK). If the
thickness of the insulation used is 5 mm higher than the
critical thickness of insulation, calculate the rate of heat lost
by the steam and the rate of steam condensation in kg/hr.
(The enthalpy of condensation of steam = 2230 kJ/kg.)
Inventary can be in the form of
(a) raw materials
(b) supplies
(c) brought out part, semi-finished goods and subassemblies
(d) all of these
Annual carrying cost, for a given annual demand
(a) will increase with the increase in the number of orders
placed per annum.
(b) will decrease with the increase in the number of orders
placed per annum
(c)
35.
36.
37.
38.
39.
p cos q
2
4
(c) is independent of number of orders placed per annum
(d) will increase with the decrease in lead time
G.L
2
a
1
40. If matrix X = 2
and X2 X + I = 0, then
+
a
a
1
1
6m
inverse of X is
Clay
1 a 1
(a) 2
a
a
1
1 a
(b) 2
a a + 1 a
a
1
(c)
2
a + a + 1 a 1
2
a
(d) a a + 1
1
1 a
(a) acas
(b)
e as
5
eas
eas
(d)
5
a
42. The equation x3 x2 + 4x 4 = 0 is to be solved using
Newton-Raphson method. If x = 2 taken as the initial
approximation of the solution, then the next approximate
using this method, will be
(c)
(a)
2
3
(b)
4
3
3
2
43. The box 1 contains chips numbered 3, 6, 9, 12 and 15.
The box 2 contain chips numbered 6, 11, 16, 21 and 26. Two
chips, one frame each box are drawn at random.
The numbers written on these chips are multiplied.
The probability for the product to be an even number is
(c) 1
(a)
6
25
2
5
3
19
(d)
5
25
44. The general solution of the differential equation (D2 4D
+ 4)y = 0 is of form
(a) c1 e2x
(b) c1 e2x + c2 e2x
2x
2x
(c) c1 e + (2e d)
(d) c1 e2x + c2 x e2x
45. A square footing is to be established in a clay soil at a
depth of 2m, where water fable has risen up to the ground
level as shown in fig. Assume that the net load for the
given footing is a constant and that the some is dispersed
in to a clay as shown with load dispersion as 2V to 1H.
(rw = 10 kN/m3, rsat = 19.3 kN/m3) Net load = 50 kN,
Cc = 0.36, e0 = 0.92)
(c)
2
1
Rock
(d)
(b)
2m
(a)
h0 = 0.25, hB = 0.18
(b)
h0 = hB = 0.33
50.
5
(a)
mx&& + kx = 0
(b)
m
x&& + kx = 0
2
3m
&&
x + kx = 0
(d) 2mx&& + kx = 0
2
The natural frequency of the spring mass system is
(c)
51.
(a)
wn =
k
rad / sec
3m
(b)
wn =
2k
rad / sec
3m
2k
rad / sec
(d) None of these
m
Common Data and Linked Answer Q. 52 and 53
Oil of absolute viscosity 1.5 poise and relative density 0.85 flows
through a 30 cm diameter pipe. The head loss in 3000 m length of
pipe is 10 m.
Given : m = 1.5 poise = 0.15 Pas
r = 0.85 998 = 848.3 kg/m3
52. Shear stress at the pipe wall will be
(a) 2.773 Pa
(b) 3.18 Pa
(c) 4.16 Pa
(d) 6.28 Pa
53. Shear stress at a radial distance of 10 cm from the pipe axis
will be
(a) 2.773 Pa
(b) 3.18 Pa
(c) 4.16 Pa
(d) 6.28 Pa
Statement for Linked Answer Questions 54 and 55:
The following table of properties was printed out for saturated
liquid and saturated vapour of ammonia. The titles for only the
first two columns are available. All that we know is that the other
columns (columns 3 to 8) contain data on specific properties,
namely, internal energy (kJ/kg), enthalpy (kJ/kg) and entropy (kJ/
kg. K).
(c)
t(C)
20
0
20
40
54.
55.
56.
57.
wn =
p(kPa)
190.2
429.6
857.5
1554.9
88.76
179.69
272.89
368.74
0.3657
0.7114
1.0408
1.3574
89.05
180.36
274.30
371.43
5.6155
5.3309
5.0860
4.8662
1299.5 1418
1318.0 1442.2
1332.2 1460.2
1341.0 1470.2
| y|
and q is any non-zero real number,,
y
the value of |f (q) f ( q)| is
(a) 0
(b) 1
(c) 1
(d) 2
64. The horse has played a little -known but very important
role in the field of medicine. Horses were injected with
toxins of disease, until their blood built up immunities.
Then a serum was made from their blood. Serum to fight
with diphtheria and tetanus were developed this way. It
can be inferred from the passage, that horses were.
(a) Given immunity to diseases
(b) Generally quite immune to disease
(c) given mediacines to fight toxirs
(d) given diphtheria and tetanus serums
65. The sum of in term of the series 4 + 44 + 444 + ... is
(a) (4/81) [10n+19n1]
(b) (1/81) [10n19n1]
(c) (4/81) [10n+1 9n 10]
(d) (4/81) [10n 9n 10]
63. Given that f (4) =