Вы находитесь на странице: 1из 1

wireless clip-on mini microphone

operating instruction.
it is very happy that you have this
professional wireless clip-on mini. microphone
of good quality which will bring you
convenience when you are using it in the
situacion of teaching, conference, monitoring
etc.
HOW DO YOU OPERATE IT?
1.- open the bottom cover (4) of the
transmitter, insert the battery with the
correct polarity the mic connector(9) into the
socket(1) of transmitter.
2.- insert the mic connector(9) into the
socket(1) of transmitter
3.- Open the battery cover (5)
of the
receiver, insert one batteries (size A A) into
the receiver with correct polarity and close
the batery cover.
4.- plug the receiver into the input socket for
microphone of amplifier, set both switch(2) of
transmitter and switch (8) of receiver to ON
position, then the pilot lamps (3) and (7) are
on that indicates a good condition and it is
ready for operation.
TTENTIONS
1.- if acoustic quality and volume are
abnormal or receiving distance is shortened,
the batteries in transmitter and receiver
should be replaced, if thereafter still not in
normal operation, you can carefully trim the
frequency by adjusting the screw(6) in
receiver with a screwdriver to become normal
operation.
2.- if your microphone isn't used for a long
period, the battery should be taken out to
avoid its deterioration and the damage of
componets.
3.- if two wireless microphones are used at
the same time, you should use them with one
red and another green lamp and can't use
them with the map of the same color.
4.- if the microphone is too close to the
speaker or the volume of the amplifier is too
loud, shrill sound will occur and that may
damage the amplifier or speaker. in that case,
please keep microphone long distance from
the speaker and turn down the volume of
amplifier.
5.- shall not be subject to splash water
facilities or drop
6.- shall not be placed on the device, such as
vases filled with water and the like items.
SPECIFICATIONS
1. modulation-------------------FM
2. frequency response--------80 to 12500 Hz
3. output impedance----------600 ohm

Clip mini inalmbrico. Micrfono - wireless clipon mini microphone


Instrucciones de operacin.
Es muy feliz que tiene este mini clip
inalmbrico profesional. Micrfono de buena
calidad que le traer mayor comodidad cuando
se est utilizando en la situacin de la
enseanza, conferencias, monitoreo, etc.
CMO SE HACE FUNCIONAR?
1.- Abrir la tapa inferior (4) del transmisor,
inserte la batera con la polaridad correcta del
conector de micrfono (9) en el enchufe (1) del
transmisor.
2.- insertar el conector de micrfono (9) en el
enchufe (1) del transmisor
3.- Abrir la tapa de la batera (5) del receptor,
insertar uno pilas (tamao A A) en el receptor
con la polaridad correcta y cierre la tapa batery.
4.- conectar el receptor a la toma de entrada de
micrfono del amplificador, ponga los dos
interruptores
(2)
del
transmisor
y
el
conmutador (8) del receptor a la posicin ON, a
continuacin, las luces de los pilotos (3) y (7) se
encuentran en una que indica buenas
condiciones y que est listo para el
funcionamiento.
ATENCIONES
1.- Si la calidad acstica y el volumen son
anormales o la recepcin de la distancia se
acorta, las bateras de transmisor y el receptor
deben ser sustituidos, a partir de entonces, si
todava no est en funcionamiento normal,
puede recortar cuidadosamente la frecuencia
ajustando el tornillo (6) en el receptor con un
destornillador
para
convertirse
en
el
funcionamiento normal.
2.- Si el micrfono no se utiliza durante un largo
periodo, la batera debe ser retirado para evitar
su deterioro y el dao de los componets.
3.- Si se utilizan dos micrfonos inalmbricos al
mismo tiempo, se las debe usar con uno rojo y
otro verde y la lmpara no se pueden utilizar
con el mapa del mismo color.
4.- Si el micrfono est demasiado cerca del
altavoz o el volumen del amplificador es
demasiado alto, se producir sonido estridente
y que puede daar el amplificador o speaker.
En ese caso, por favor, tenga micrfono larga
distancia desde el altavoz y bajar el volumen
del amplificador.
5.- no estarn sujetos a salpicaduras de agua o
instalaciones de cada
6.- No se colocar en el dispositivo, tales como
floreros llenos de agua y los artculos similares.
PRESUPUESTO
1. modulacin-------------------------FM
2. Respuesta de frecuencia--------80 a 12500 Hz

Вам также может понравиться