Академический Документы
Профессиональный Документы
Культура Документы
STANDARD
C18
520 ekW/ 650 kVA/ 50 Hz/ 1500 rpm/ 400 V/ 0.8 Power Factor
Fuel Strategy: LOW FUEL CONSUMPTION
C18
520 ekW/ 650 kVA
50 Hz/ 1500 rpm/ 400 V
Metric
English
Package Performance
Genset Power Rating with Fan @ 0.8 Power Factor
520 ekW
650 kVA
N/A
N/A
133.2 L/hr
35.2 gal/hr
98.4 L/hr
26.0 gal/hr
67.2 L/hr
17.7 gal/hr
38.0 L/hr
10.0 gal/hr
20.8 L
5.5 gal
35.8 m/min
1263.6 cfm
49 C
120 F
553.7 C
1028.6 F
103.0 m/min
3637.4 cfm
10.0 kPa
Fuel Consumption
Cooling System
Engine Coolant Capacity
Inlet Air
Combustion Air Inlet Flow Rate
Max. Allowable Combustion Air Inlet Temp
Exhaust System
Exhaust Stack Gas Temperature
Exhaust Gas Flow Rate
Exhaust System Backpressure (Maximum Allowable)
TSS-EM1391-00-GS-EPG-10190033.pdf
Page 1 of 3
Heat Rejection
Heat Rejection to Jacket Water
167 kW
9518 Btu/min
498 kW
28317 Btu/min
95 kW
5381 Btu/min
84 kW
4764 Btu/min
27 kW
1524 Btu/min
Alternator
Motor Starting Capability @ 30% Voltage Dip
2055 skVA
Current
938 amps
Frame Size
A3355L4
Excitation
SE
Temperature Rise
125 C
Emissions (Nominal)
NOx
3072.6 mg/Nm
6.1 g/hp-hr
CO
401.3 mg/Nm
0.8 g/hp-hr
HC
7.3 mg/Nm
0.0 g/hp-hr
PM
14.4 mg/Nm
0.0 g/hp-hr
For ambient and altitude capabilities consult your Cat dealer. Air flow restriction (system) is added to existing
restriction from factory.
2.
UL 2200 Listed packages may have oversized generators with a different temperature rise and motor starting
characteristics. Generator temperature rise is based on a 40 C ambient per NEMA MG1-32.
3.
Emissions data measurement procedures are consistent with those described in EPA CFR 40 Part 89, Subpart D &
E and ISO8178-1 for measuring HC, CO, PM, NOx. Data shown is based on steady state operating conditions of
77 F, 28.42 in HG and number 2 diesel fuel with 35 API and LHV of 18,390 btu/lb. The nominal emissions data
shown is subject to instrumentation, measurement, facility and engine to engine variations. Emissions data is based
on 100% load and thus cannot be used to compare to EPA regulations which use values based on a weighted cycle.
TSS-EM1391-00-GS-EPG-10190033.pdf
Page 2 of 3
The International System of Units (SI) is used in this publication. CAT, CATERPILLAR, their respective
logos, ADEM, EUI, SOS, "Caterpillar Yellow" and the "Power Edge" trade dress, as well as corporate
and product identity used herein, are trademarks of Caterpillar and may not be used without permission.
TSS-EM1391-00-GS-EPG-10190033.pdf
Page 3 of 3