Академический Документы
Профессиональный Документы
Культура Документы
Operation of Generators
If we have a generator with 4 poles, how many rpm does it need to give 60Hz?
1800 rpm
1200 rpm
900 rpm
How many degrees are there between the phases in a 3-phase generator?
120 degrees
90 degrees
60 degrees
180 degrees
Where will you find the instruments for synchronising the generator?
On the main switch board
On the generator
On the diesel engine
On the circuit breaker
How many % of nominal voltage is required before main circuit breaker can be
connected to main bus bar?
70%
90%
50%
80%
What will happen if Load dependent start/stop of generator sets is in auto mode?
It will start/stop the generator sets in response to varying load
It will start/stop the generator sets in response to fuel consumption
It will start but never stop the generator sets in response to varying load
It will stop but never start the generator sets in response to varying load
Please note this answer is not correct but it will give you 1 point. Proper answer should
be (in red)