Академический Документы
Профессиональный Документы
Культура Документы
STUDIES
PUTRAJAYA CAMPUS
FINAL EXAMINATION
SEMESTER 2 2014/2015
PROGRAMME
SUBJECT CODE
EEED 114
SUBJECT
Electrical Technology 1
DATE
__ February 2015
TIME
1 hours 30 minutes
NAME
STUDENT ID
SECTION
:
:
:
INSTRUCTIONS TO CANDIDATES:
1.
2.
3.
Page 1 of 8
[3 marks]
b) What is Node?
[2 marks]
c) Find the current i and Vab for the following circuit in Figure 1a.
[7 marks]
Figure 1a
d) Find i1 and calculate the power for the controlled current source (indicate whether the
power is absorbed or supplied) in Figure 1b.
[7 marks]
Page 2 of 8
Figure 1b
e) Find the equivalent resistance Rab for the following circuit in Figure 1c.
Figure 1c
Page 3 of 8
[6 marks]
Figure 2(a)
a) Find v1, v2, v3 and v4 using Nodal Analysis.
[13 marks]
[12 marks]
Page 4 of 8
Figure 3.0
a) Find the Norton current, IN at terminal A-B. Use superposition theorem as part of the
method to find IN.
[7 marks]
b) Find the Norton Resistance, RN of the circuit
[5 marks]
c) From the result of 3 a. and 3b. Draw the Norton equivalent circuit of circuit in Figure
3.0. Label the circuit properly.
[3 marks]
d) From the Norton equivalent circuit, use source transformation technique to find the
Thevenin Voltage, VTH. Draw the Thevenin equivalent circuit and label the diagram
properly.
e) What is the value of RL so that RL will consume maximum power?
f) Calculate the maximum power that can be transferred to RL
Page 5 of 8
[5 marks]
[1 marks]
[4 marks]
a) Referring to circuit in Figure 4(a), the switch is connected to position 1 for a very long
time. Then, the switch is moved to position 2. Find the value of current flowing out from
the capacitor, 2s after the switch is moved to position 2.
[13
marks]
Figure 4(a)
b) Referring to circuit in Figure 4(b), determine whether the response of VcT in the circuit is
under damp, over damp or critically damp when the switch is turned on. Show calculation as
proof. Assume all initial value as zero.
[12
marks]
V
Figure 4(b)
Page 6 of 8
FORMULA SHEET
Ohms Law, V =IR
Equivalent/Total value in series circuit:
RT =R1 + R2 +
LT =L1 + L2 +
CT =
1
1 1
+ +
C1 C2
V T =V 1+V 2+
I T =I 1=I 2=
QT =Q1=Q2=
1
1 1
+ +
L 1 L2
CT =C 1+ C2 +
V T =V 1=V 2=
I T =I 1+ I 2 +
QT =Q1+Q 2+
Current Divider,
I1 =
R2
I
R1 + R2 T
R1
Voltage Divider, V 1= R1+ R 2 V s
Page 7 of 8
Page 8 of 8