Академический Документы
Профессиональный Документы
Культура Документы
Taxila
Audio Amplifier
EDC FINAL PROJECT
SUBMITTED BY:
MUHAMMAD TALHA AAMIR
HAMZA SULAIMAN
15-EE-158
15-EE-14
UET
UET
Table of Contents
COMPONENTS
CALCULATIONS
SCHEMATIC DIAGRAM
PAGE 1
UET
Components Used
PAGE 2
UET
2SK1058 MOSFET: Operating in its saturation region this MOS acts as an amplifier. To
ensure saturation region we make sure the Vgs > Vth and Vds >= Vgs-Vth.
Variable Resistors:
1) 50K: This resistor acts as a volume control to the input signal.
2)100K: This Resistor is used to bias the MOS to ensure operation in saturation region.
Capacitors: All capacitors are used as a filter to the input voltage with the exception of
the 0.47F which is input capacitance and 4700F which is the output capacitance.
Audio Jack: Used to provide input from the user.
Speaker: provides the output.
PAGE 3
UET
Calculations
Simulating the designed circuit in proteus helped us in calculating the gain.
We know that
Gain=Vout/Vin
Our selected Vin was 20mV.
Received Vout was 80mV
So Gain = 80mV/20mV = 4
Attached is the received waveform.
PAGE 4
UET
I=0.7A
P=VI
P= (24) * (0.7)
P= 16.4 Watts
However this circuit causes major heat loss from the MOS and the Rd resistors. Efficiency is very
much dropped due to heat loss.
PAGE 5
UET
Schematic Diagram
PAGE 6