Академический Документы
Профессиональный Документы
Культура Документы
To check the connection of the HDMI cable inside Solo we need to remove motor pods #02 and #03, and
we will need to remove the battery tray and check under the board.
Please use a zip tie to wrap the cables that go from the motor pod to the board, leaving the long part of the
tie out. Disconnect the wide beige connector, the red wire and the black wire to remove the old motor pod.
To remove the wide beige connector (DF13), carefully lift the edges of the connector away from the pod
until they pop out, then remove the connector. Dont pull on the wires! The connector can break easily if
force is used to remove it.
1 of 6
Once you have removed all three screws proceed to remove the mount by lifting it, but be careful to not
break the clips showed on the picture.
2 of 6
After lifting the mount remove the HDMI cable through the little hole in the mount.