Вы находитесь на странице: 1из 3

CIVIL AVIATION REQUIREMENT

SECTION 7, SERIES B PART VIII


Issue I dated 1.9.99

Subject :

Effective 1.1.2000

Syllabus for Examination for Issue of Student/ Flight Navigators


Licence.

1. INTRODUCTION
Sections U and V of Schedule II of the Aircraft Rules, 1937, stipulate, amongst other
requirements, that for issuance of Student Navigators Licence and Flight
Navigators licence, the applicant shall pass a written examination with oral and
practical tests as per the syllabus prescribed by the DGCA. Accordingly, this part of
the CAR lays down the main topics of the syllabus in accordance with Schedule II.
These topics of syllabus are in conformity with the knowledge requirements
prescribed in ICAO Annex 1.
This CAR is issued under the provisions of Schedule II and rule 133A of the Aircraft
Rules, 1937.
2. SYLLABUS
2.1

Air Regulations
a)
b)
c)
d)

Aircraft Act, 1934 Chapter I, Section Short title and extent, definitions,
power to detain aircraft, penalty for act in contravention of rules made
under the act, penalty for flying so as to cause danger;
Aircraft Rules, 1937;
rules of the air;
appropriate air traffic services practices and procedures.

CIVIL AVIATION REQUIREMENTSSECTION 7


SERIES B PART IX

2.2

Flight Performance and Planning


a)
b)
c)

2.3

DATED: 1ST SEPTEMBER, 1999

effects of loading and mass distribution on aircraft performance;


use of take-off, landing and other performance data including procedures
for cruise control;
pre-flight and en-route operational flight planning; preparation and filing of
air traffic services flight plans; appropriate air traffic service procedures,
position reporting procedures; altimeter setting procedures; operations in
areas of high density traffic;

Human Performance and Limitations


human performance and limitations relevant to the flight navigator;

2.4

Meteorology
a) interpretation and practical application of aeronautical meteorological reports,
charts and forecasts; codes and abbreviations; use of, and procedures for
obtaining, meteorological information, pre-flight and in-flight; altimetry;
b) aeronautical meteorology; climatology of relevant areas in respect of the
elements having an effect upon aviation; the movement of pressure
systems; the structure of fronts and the origin and characteristics of
significant weather phenomenon which affect take-off, en-route and
landing conditions;
c) causes, recognition and effects of engine and airframe icing; frontal zone
penetration procedures; hazardous weather avoidance;
d) practical high altitude meteorology, including interpretation and use of
weather reports, charts and forecasts; jet streams;

2.5

Navigation
a)
b)
c)
d)
e)

dead reckoning, pressure pattern and celestial navigation procedures; the


use of aeronautical charts, radio navigation aids and area navigation
systems; specific navigation requirements for long-range flights;
use, limitations and serviceability of avionics and instruments necessary
for the navigation of aircraft;
use, accuracy and reliability of navigation systems used in departure, enroute and approach phases of flight; identification of radio navigation aids;
principles, characteristics and use of self contained and externalreferenced navigation systems; operation of airborne equipment;
the celestial sphere including the movement of heavenly bodies and their
selection and identification for the purpose of observation and reduction of
sights; calibration of sextants; the completion of navigation
documentation;
2

CIVIL AVIATION REQUIREMENTSSECTION 7


SERIES B PART IX

f)
2.6

DATED: 1ST SEPTEMBER, 1999

definitions, units and formulae used in air navigation;

Operational Procedures
interpretation and use of aeronautical documentation such as AIP, NOTAM,
aeronautical codes and abbreviations, and instrument procedure charts for
departure, en-route, descent and approach;

2.7

Principles of Flight
principles of flight;

2.8

Radiotelephony
radiotelephony procedures and phraseology.

Sd/(H.S. KHOLA)
Director General of Civil Aviation

Вам также может понравиться