Академический Документы
Профессиональный Документы
Культура Документы
Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor
y.
24 FastEthernet/IEEE 802.3 interface(s)
2 Gigabit Ethernet/IEEE 802.3 interface(s)
63488K bytes of flash-simulated
Base ethernet MAC Address
Motherboard assembly number
Power supply part number
Motherboard serial number
Power supply serial number
Model revision number
Motherboard revision number
Model number
System serial number
Top Assembly Part Number
Top Assembly Revision Number
Version ID
CLEI Code Number
Hardware Board Revision Number
Switch
-----*
1
Ports Model
----- ----26
WS-C2960-24TT
:
:
:
:
:
:
:
WS-C2960-24TT
FOC1033Z1EY
800-26671-02
B0
V02
COM3K00BRA
0x01
SW Version
---------12.2
SW Image
---------C2960-LANBASE-M
v
v
vl
vlan
VLAN Name
Status
Ports
---- -------------------------------- --------- ------------------------------1
default
active
Fa0/1, Fa0/2, Fa0/3, Fa0/4
Fa0/5, Fa0/7, Fa0/8, Fa0/9
Fa0/10, Fa0/12, Fa0/13, Fa0/14
Fa0/15, Fa0/16, Fa0/17, Fa0/19
Fa0/20, Fa0/21, Fa0/22, Fa0/23
Fa0/24, Gig0/1, Gig0/2
10 Faculty/Staff
active
20 Students
active
Fa0/18
30
99
1002
1003
1004
1005
Guest(Default)
Management&Native
fddi-default
token-ring-default
fddinet-default
trnet-default
VLAN
---1
10
20
30
99
1002
1003
1004
1005
Type
----enet
enet
enet
enet
enet
fddi
tr
fdnet
trnet
SAID
---------100001
100010
100020
100030
100099
101002
101003
101004
101005
MTU
----1500
1500
1500
1500
1500
1500
1500
1500
1500
active
Fa0/6, Fa0/11
active
act/unsup
act/unsup
act/unsup
act/unsup
Parent
------
RingNo
------
BridgeNo
--------
Stp
---ieee
ibm
BrdgMode
--------
Trans1
-----0
0
0
0
0
0
0
0
0
Trans2
-----0
0
0
0
0
0
0
0
0
S2#
S2#
S2#
S2#s
S2#sj
S2#sh
S2#show in
S2#show interfaces t
S2#show interfaces trunk
Port
Mode
Encapsulation Status
Gig0/1
on
802.1q
trunking
Native vlan
99
Port
Gig0/1
Port
Gig0/1
Port
Vlans in spanning tree forwarding state and not pruned
Gig0/1
1,10,20,30,99
S2#
................................................................................
.................
C2960 Boot Loader (C2960-HBOOT-M) Version 12.2(25r)FX, RELEASE SOFTWARE (fc4)
Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor
y.
2960-24TT starting...
Base ethernet MAC Address: 0001.9746.A42B
Xmodem file system is available.
Initializing Flash...
flashfs[0]: 3 files, 0 directories
flashfs[0]: 0 orphaned files, 0 orphaned directories
flashfs[0]: Total bytes: 64016384
flashfs[0]: Bytes used: 4416863
flashfs[0]: Bytes available: 59599521
flashfs[0]: flashfs fsck took 1 seconds.
...done Initializing Flash.
Boot Sector Filesystem (bs:) installed, fsid: 3
Parameter Block Filesystem (pb:) installed, fsid: 4
Loading "flash:/c2960-lanbase-mz.122-25.FX.bin"...
######################### [OK]
Restricted Rights Legend
Use, duplication, or disclosure by the Government is
subject to restrictions as set forth in subparagraph
(c) of the Commercial Computer Software - Restricted
Rights clause at FAR sec. 52.227-19 and subparagraph
(c) (1) (ii) of the Rights in Technical Data and Computer
Software clause at DFARS sec. 252.227-7013.
cisco Systems, Inc.
170 West Tasman Drive
San Jose, California 95134-1706
Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor
y.
24 FastEthernet/IEEE 802.3 interface(s)
2 Gigabit Ethernet/IEEE 802.3 interface(s)
63488K bytes of flash-simulated
Base ethernet MAC Address
Motherboard assembly number
Power supply part number
Motherboard serial number
Power supply serial number
Model revision number
Motherboard revision number
Model number
System serial number
Top Assembly Part Number
Top Assembly Revision Number
Version ID
CLEI Code Number
Hardware Board Revision Number
Switch
-----*
1
Ports Model
----- ----26
WS-C2960-24TT
SW Image
---------C2960-LANBASE-M
S1(config)#int g0/2
S1(config-if)#sw
S1(config-if)#switchport m
S1(config-if)#switchport mode t
S1(config-if)#switchport mode trunk
S1(config-if)#exit
S1(config)#show i
S1(config)#show in
S1(config)#ex
S1(config)#exit
S1#
%SYS-5-CONFIG_I: Configured from console by console
S1#
S1#
S1#sh
S1#show
S1#show
S1#show
S1#show
Port
Gig0/2
i
in
interfaces t
interfaces trunk
Mode
Encapsulation Status
on
802.1q
trunking
Native vlan
99
Port
Gig0/2
Port
Gig0/2
Port
Vlans in spanning
Gig0/2
1,10,20,30,99
S1#co
S1#con
S1#conf
S1#configure t
Enter configuration commands,
S1(config)#int g0/1
S1(config-if)#sw
S1(config-if)#switchport mo
S1(config-if)#switchport mode
S1(config-if)#switchport mode
t
trunk
S1(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface GigabitEthernet0/1, changed stat
e to down
%LINEPROTO-5-UPDOWN: Line protocol on Interface GigabitEthernet0/1, changed stat
e to up
S1(config-if)#
S1(config-if)#
...............................................................
C2960 Boot Loader (C2960-HBOOT-M) Version 12.2(25r)FX, RELEASE SOFTWARE (fc4)
Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor
y.
2960-24TT starting...
Base ethernet MAC Address: 0090.2BE2.C691
Xmodem file system is available.
Initializing Flash...
flashfs[0]: 3 files, 0 directories
Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor
y.
24 FastEthernet/IEEE 802.3 interface(s)
2 Gigabit Ethernet/IEEE 802.3 interface(s)
63488K bytes of flash-simulated
Base ethernet MAC Address
Motherboard assembly number
Power supply part number
Motherboard serial number
Power supply serial number
Model revision number
Motherboard revision number
Model number
System serial number
Top Assembly Part Number
Top Assembly Revision Number
Version ID
CLEI Code Number
Hardware Board Revision Number
Switch
-----*
1
Ports Model
----- ----26
WS-C2960-24TT
SW Version
---------12.2
SW Image
---------C2960-LANBASE-M
1
10
20
30
99
1002
1003
1004
1005
enet
enet
enet
enet
enet
fddi
tr
fdnet
trnet
100001
100010
100020
100030
100099
101002
101003
101004
101005
1500
1500
1500
1500
1500
1500
1500
1500
1500
ieee
ibm
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Native vlan
99
Port
Gig0/2
Port
Gig0/2
Port
Gig0/2
1,10,20,30,99
S3#conf t
Enter configuration commands, one per line. End with CNTL/Z.
S3(config)#int f0/18
S3(config-if)#no sh
S3(config-if)#no shutdown
S3(config-if)#