Вы находитесь на странице: 1из 103

WALK BEHIND SCRUBBER

Operating Instructions
Bedienungsanleitung

MODELS:

SC20
10052190

SCC20
10052230

SC20T
10052200

SCC20T
10052240

SCX20T
10052370

SCXC20T
10052420

IPX4

Read these instructions before using the machine


Bitte lesen Sie diese Anleitungen, bevor Sie die Maschine in Gebrauch nehmen

BK
86038350 04/26/12
PRV NO. 98712

MACHINE DATA LOG/OVERVIEW


MODEL _______________________________________
DATE OF PURCHASE __________________________
SERIAL NUMBER ______________________________
SALES REPRESENTATIVE # _____________________
DEALER NAME ________________________________
OPERATIONS GUIDE NUMBER ___________________
PUBLISHED __________________________________________

YOUR DEALER
Name: __________________________________________________________________________________________________
Address: _______________________________________________________________________________________________
Phone Number: _________________________________________________________________________________________

For the name and address of your dealer contact: Windsor Industries

OVERVIEW
The Saber Compact is a battery powered, hard floor scrubber intended for commercial use.
The appliance applies a cleaning solution onto a hard floor, scrubs the floor with a brush or
pad, and then vacuums the soiled water back into the recovery tank.

Warranty Registration
Thank you for purchasing a Windsor product. Warranty registration is quick and easy.
Your registration will allow us to serve you better over the lifetime of the product.
To register your product go to:
www.windsorind.com/WarrantyRegistration.aspx
For customer assistance:
1-800-444-7654

SABER (SC) 86038350 05/13/11

TABLE OF CONTENTS
Machine Data Log/Overview.........................2
Table of Contents..........................................3

HOW TO USE THIS MANUAL


How to use this Manual.................................1-1

SAFETY
Important Safety Instructions ........................2-1
Hazard Intensity Level. .................................2-2
Safety Label Location. ..................................2-3

OPERATIONS
Technical Specifications. ..............................3-1
How the Machine Works. ..............................3-3
Components..................................................3-4
Controls.........................................................3-5
Machine Operation...................................... 3-10
Pre-Run Machine Inspection.................... 3-10
Starting Machine. ..................................... 3-10
Emergency Stop Procedures ................... 3-10
Filling the Solution Tank........................... 3-10
Scrubbing................................................. 3-10
Emptying & Cleaning Tanks..................... 3-12

MAINTENANCE
Batteries........................................................4-1
Battery Maintenance. .................................4-1
Checking Battery Specific Gravity..............4-2
Charging the Batteries. ..............................4-2
On-Board Charger Battery Selection .........4-4
Changing Batteries. ...................................4-5
Battery Connections...................................4-5
Scrub Brushes. .............................................4-6
Types. ........................................................4-6
Replacing or Installing Scrub Brushes .......4-6
Squeegee Blades..........................................4-7
Replace Squeegee Blade. .........................4-7
Remove Squeegee Assembly....................4-7
Adjusting Deluxe Squeegee.......................4-7
Adjusting Squeegee Deflection..................4-8
Replacing Squeegee Blades......................4-8
Greasing Axles...........................................4-8
Service Schedule. .........................................4-9
Machine Troubleshooting............................ 4-10

GROUP PARTS LIST


Control Handle Group Non-Traction. .........5-1
Control Tower Group - Traction. ...................5-3
Decal Group..................................................5-5
Electrical Panel Group Non-Traction. ........5-7
Electrical Panel Group Traction...5-9
Hour Meter5-11
Recovery Tank Group................................. 5-13
Scrub Brush/Pad Driver Group . ................. 5-15
Scrub Head Group Non-Traction5-17
Scrub Head Group - Traction...................... 5-19
Scrub Head Lift Group Non-Traction. ...... 5-21
Scrub Head Lift Group - Traction................ 5-23
Solution Tank Group Non-Traction. ......... 5-25
Solution Tank Group Traction.................. 5-27
Squeegee Group ........................................ 5-29
Squeegee Lift Group................................... 5-31
Deluxe Squeegee Group. ........................... 5-33
Deluxe Squeegee Lift Group. ..................... 5-37
Vacuum Group............................................ 5-39
Wheels and Frame Group Non-Traction.. 5-41
Wheels and Frame Group - Traction .......... 5-43
Onboard Charger........................................ 5-45
Wiring Group Battery Cables ................... 5-47
Wiring GroupControl Panel-Non-Traction 5-49
Wiring Group-Control Panel-Non-Traction
With Battery Charger .......................... 5-51
Wiring Group Schematic Non-Traction . 5-53
Wiring Group Schematic Non-Traction
Onboard Charging .............................. 5-55
Wiring Group Schematic - Traction.......... 5-57
Wiring Group Schematic Traction and
Onboard Charging .............................. 5-59
Wiring Group Control Panel - Traction..... 5-61
Wiring Group Main Harness - Traction .... 5-63
Emergency Stop Option.............................. 5-65
Accessory Pump Option. ............................ 5-67
Suggested Spare Parts............................... 5-69
EC Declaration of Conformity. .................... 5-70
Serial Number............................................. 5-72
Warranty

SABER (SC) 86038350 09/30/09

HOW TO USE THIS MANUAL


This manual contains the following sections:
-

HOW TO USE THIS MANUAL


SAFETY
OPERATIONS
MAINTENANCE
PARTS LIST

The HOW TO USE THIS MANUAL section will tell


you how to find important information for ordering
correct repair parts.
Parts may be ordered from authorized Windsor
dealers. When placing an order for parts, the
machine model and machine serial number are
important. Refer to the MACHINE DATA box which
is filled out during the installation of your machine.
The MACHINE DATA box is located on the inside of
the front cover of this manual.
MODEL _____________________________________
DATE OF PURCHASE ________________________
SERIAL NUMBER ____________________________
SALES REPRESENTATIVE # ___________________

The SAFETY section contains important information


regarding hazard or unsafe practices of the
machine. Levels of hazards are identified that could
result in product or personal injury, or severe injury
resulting in death.
The OPERATIONS section is to familiarize the
operator with the operation and function of the
machine.
The MAINTENANCE section contains preventive
maintenance to keep the machine and its
components in good working condition. They are
listed in this general order:
-

The PARTS LIST section contains assembled parts


illustrations and corresponding parts list. The parts
lists include a number of columns of information:
-

DEALER NAME ______________________________


OPERATIONS GUIDE NUMBER __________________

PUBLISHED ________________________________

Copyright 1995 Windsor Industries, Printed in USA

The model and serial number of your machine is on


the front of the control tower.

Batteries
Scrub Brushes
Squeegee
Service Schedule
Machine Troubleshooting

REF column refers to the reference


number on the parts illustration.
PART NO. column lists the part
number for the part.
PRV NO. reference number
QTY column lists the quantity of the
part used in that area of the machine.
DESCRIPTION column is a brief
description of the part.
SERIAL NO. FROM If this column has
an (*) and a Reference number, see the
SERIAL NUMBERS page in the back of
your manual. If column has two asterisk
(**), call manufacturer for serial number.
The serial number indicates the first
machine the part number is applicable
to. The main illustration shows the most
current design of the machine. When a
boxed illustration is shown, it displays
the older design..
NOTES column for information not
noted by the other columns.

NOTE: If a service or option kit is installed on your


machine, be sure to keep the KIT INSTRUCTIONS
which came with the kit. It contains replacement
parts numbers needed for ordering future parts.

1-1

SABER (SC) 86038350 01/29/07

IMPORTANT SAFETY INSTRUCTIONS


When using an battery powered appliance, basic precaution
must always be followed, including the following:
READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE.

! WARNING:

To reduce the risk of fire, electric shock, or injury:

Use only indoors. Do not use outdoors or expose to rain.


Use only as described in this manual. Use only manufacturers recommended components and
attachments.
If the machine is not working properly, has been dropped, damaged, left outdoors, or dropped into
water, return it to an authorized service center.
Do not operate the machine with any openings blocked. Keep openings free of debris that may reduce
airflow.
This machine is not suitable for picking up hazardous dust.
Machine can cause a fire when operating near flammable vapors or materials. Do not operate this
machine near flammable fluids, dust or vapors.
This machine is suitable for commercial use, for example in hotels, schools, hospitals,
factories, shops and offices for more than normal housekeeping purposes.
Maintenance and repairs must be done by qualified personnel.
If foam or liquid comes out of machine, switch off immediately.
Disconnect battery before cleaning or servicing.
Before the machine is discarded, the batteries must be removed and properly disposed of.
Make sure all warning and caution labels are legible and properly attached to the machine.
During operation, attention shall be paid to other persons, especially children.
Before use all covers and doors shall be put in the positions specified in the instructions.
When leaving unattended, secure against unintentional movement.
The machine shall only be operated by instructed and authorized persons.
When leaving unattended, switch off or lock the main power switch to prevent unauthorized use.
Only chemicals recommended by the manufacturer shall be used.
This appliance has been designed for use with the brushes specified by the manufacturer. The fitting
of other brushes may affect its safety.
Do not use on surfaces having a gradient exceeding 2%.

SAVE THESE INSTRUCTIONS

SABER (SC) 86038350 01/29/07

2-1

HAZARD INTENSITY LEVEL


The following symbols are used throughout this guide as indicated in their descriptions:

HAZARD INTENSITY LEVEL


There are three levels of hazard intensity identified by signal words -WARNING and CAUTION and FOR
SAFETY . The level of hazard intensity is determined by the following definitions:

! WARNING
WARNING - Hazards or unsafe practices which COULD result in severe personal injury or death.

! CAUTION
CAUTION - Hazards or unsafe practices which could result in minor personal injury or product or property
damage.
FOR SAFETY: To identify actions which must be followed for safe operation or equipment.
Report machine damage or faulty operation immediately. Do not use the machine if it is not in proper
operating condition. Following is information that signals some potentially dangerous conditions to the
operator or the equipment. Read this information carefully. Know when these conditions can exist. Locate
all safety devices on the machine. Please take the necessary steps to train the machine operating
personnel.

FOR SAFETY
DO NOT OPERATE MACHINE:
Unless Trained and Authorized.
Unless Operation Guide is Read and understood.
In Flammable or Explosive areas.
In areas with possible falling objects.
WHEN SERVICING MACHINE:
Avoid moving parts. Do not wear loose clothing; jackets, shirts, or sleeves when working on the
machine. Use Windsor approved replacement parts.

! WARNING
Batteries emit hydrogen gas. Explosion or fire can result. Keep sparks and open flame away. Keep
solution tank in raised position when charging. Keep sparks and flames away from the batteries.
Do not smoke around batteries.

! WARNING
Disconnect batteries before working on machine. Only qualified personnel should work inside
machine. Always wear eye protection and protective clothing when working on or near batteries.
Avoid skin contact with the acid contained in the batteries.

! WARNING
Never allow metal to lie across battery tops.

2-2

SABER (SC) 86038350 01/29/07

SAFETY LABEL LOCATION


NOTE: These drawings indicate the location of safety labels on the machine. If at any time the labels become
illegible, promptly replace them.

SAFETY DECAL
86252530
PRV NO. 81494

CAUTION
Explosive Gas is Given Off
By Batteries During Charge.
1. Keep Battery Compartment
Cover Open.
2. No Smoking, Flame Or
Sparks In Area.
3. Charge Only In Well
Ventilated Area.

BATTERY CAUTION
86252520
PRV NO. 80885

SABER (SC) 86038350 01/29/07

2-3

TECHNICAL SPECIFICATIONS
ITEM
Nominal power non-traction model
Nominal power traction model
Rated Voltage
Rated Amperage non-traction model
Rated Amperage traction model
Batteries
Scrub Brush Motor
Vacuum Motor
Propelling Motor traction model
Mass (GVW) non-traction model
Mass (GVW) traction model
Weight empty without batteries non-traction model
Weight empty without batteries traction model
Solution Control non-traction model
Solution Control traction model
Solution tank capacity
Recovery tank capacity
Scrub brush diameter
Scrub brush pressure non-traction model
Scrub brush pressure traction model
Scrub brush speed
Tires non-traction model
Tires traction model
Casters
Foundation Pressure non-traction model
Foundation Pressure traction model
Maximum Speed traction model
Frame Construction
Minimum aisle u-turn width
Maximum rated climb and descent angle with empty tanks
Maximum rated climb and descent angle with full tanks

3-1

DIMENSION/CAPACITY
1100 W
1200 W
24VDC
45 Amps
50 Amps
2 x 12 Volt 105-130-195 AH @
20hr rate
.75 hp (0.56 kW)
.75 hp (0.56 Kw)
.38 hp (0.28 Kw)
543 lbs. (246.5 kg)
556 lbs. (252.4 kg)
213 lbs. (96.1 kg)
232 lbs. (105.3 kg)
Gravity feed, fully variable
Gravity feed, fully variable with
automatic shut-off in neutral
13 gal. (50 l)
16 gal. (60 l)
20 in (51 cm)
50 lbs. (23 kg)
100 lbs. (45 kg)
200 rpm
2 x 8 in (20 cm) thermoplastic
elastomer non-marking
2 x 8 in (20 cm) foam filled nonmarking
3.5 x 1.25 in (9 cm) polyurethane
solid non-marking
105 lbs./in 2 ( 725 kPa)
46 lbs./in 2 ( 315 kPa)
2.75 miles/hour (4.5 km/hour)
Steel with epoxy powdercoat
finish.
45 in. ( 114.3 cm)
2%
2%

SABER (SC) 86038350 01/27/12

TECHNICAL SPECIFICATIONS
ITEM
Height
Length
Width without squeegee
Width of squeegee
Width of scrub path

MEASURE
43 in. ( 109.2 cm)
54 in. (137.1 cm)
22 in. (55.9 cm)
31 in. ( 78.7 cm)
20 in. (51 cm)

Length

Width

Height

SPECIAL NOTES:
The A-weighted sound pressure level emitted
by the appliance was measured to be 72.5 dBA.
This is a space-averaged, broad-band
measurement determined according to IEC
704-I. This appliance contains no possible
source of impact noise.

The overall root-mean-square acceleration at


the operators arms was measured to be less
than 1.0m/s2. This is a tri-axial, broad-band
measurement made during normal operation on
a composite tile floor.

SABER (SC) 86038350 01/29/07

3-2

HOW THE MACHINE WORKS


The Saber Compact is a battery powered, hard
floor scrubber intended for commercial use. The
appliance applies a cleaning solution onto a hard
floor, scrubs the floor with a brush, and then
vacuums the soiled water back into the recovery
tank.
The machine's primary systems are the solution
system, scrub system, recovery system. The
traction model has a directional control system as
well.
The function of the solution system is to store
cleaning solution and deliver it to the scrub
system. The solution system consists of the
solution tank, strainer, valve and controls. The
solution tank stores cleaning solution (water and
detergent) until it is delivered to the scrub system.
The strainer protects the valve from debris. The
non-traction model has a ball-type valve which
controls the delivery of cleaning solution to the
scrub system. The traction model has a solenoid
type valve, which controls the delivery of cleaning
solution to the scrub system. The valve
automatically prevents solution flow unless the
scrub brushes are turned on and the machine is
being propelled. The solution control knob
controls the amount of cleaning solution delivered
to the scrub system.

The function of the recovery system is to vacuum


the soiled water back into the recovery tank. The
recovery system consists of the squeegee,
vacuum motor, screen, recovery tank and
controls. The squeegee wipes the dirty solution
off the floor as the machine moves forward. The
vacuum motor provides suction to draw the dirty
solution off the floor and into the recovery tank.
The screen protects the vacuum fan from debris.
The recovery tank stores the dirty solution. The
float ball in the tank activates when the recovery
tank is full.
On the traction model, the function of the
directional control system is to control the
direction and speed of the machine. The
directional control system consists of buttons,
speed control knob/potentiometer, controller and
transaxle. The speed control knob actuates a
potentiometer, which signals speed. The
controller interprets the forward/reverse signals
from the buttons and the speed signal from the
potentiometer to command the transaxle to propel
the machine in the direction, and at the speed,
desired.
The buttons on the control handles signal forward.
When the reverse button on the control panel is
pushed, in addition to either button on the control
handles, reverse is signaled.

The function of the scrub system is to scrub the


floor. The scrub system consists of a rotary type
disk scrub brush, motor, self-adjusting scrub deck
skirt, lift linkage and controls. The brush scrubs
the floor and the motor drives the brush. The
brush drive hub allows the scrub brush to follow
irregularities and changes in the floor without
loosing contact with floor. The self-adjusting
scrub deck skirt controls the cleaning solution on
the floor so that the squeegee can pick it up. The
brush lift lever raises and lowers the scrub deck.
On the traction model the brush lift lever can be
locked into an increased brush pressured
position.

3-3

SABER (SC) 86038350 01/29/07

COMPONENTS

2
1

11

4
6

9
10

13

12
5

1. Control Panel
2. Control Handle
3. Recovery Tank
4. Recovery Tank Drain Hose
5. Scrub Head
6. Scrub Brush Access Cover
7. Solution Tank
8. Solution Tank Cover
9. Solution Tank Drain Hose
10. Solution Strainer
11. Solution Tank Support Arm
12. Squeegee
13. Vacuum Motor

SABER (SC) 86038350 01/29/07

3-4

CONTROLS NON-TRACTION
3

8
7
5

2%

2
4

1.
2.
3.
4.
5.
6.
7.
8.

Brush Switch
Brush Lift Lever
Vacuum Switch
Squeegee Lift Lever
Solution Control Lever
Battery Charge Level Indicator
Hour Meter (Optional)
Circuit Breakers

3-5

SABER (SC) 86038350 01/29/07

CONTROLS NON TRACTION


1. BRUSH SWITCH
Controls the scrub brush motor.

6. BATTERY CHARGE LEVEL INDICATOR


Indicates the charge level of the batteries.

To turn scrub brush on, press the top of the


switch.
To turn scrub brush off, press the bottom of
the switch.

2. BRUSH LIFT LEVER


Raises and lowers the brush.
To lower the brush, lift the lever from the
notch, move to the left, then lower.
To raise the brush, lift the lever from its
lowered position.

3. VACUUM SWITCH
Controls the vacuum motor.
To start vacuum motor, press the top of the
switch.
To stop vacuum motor, press the bottom of
the switch.

4. SQUEEGEE LIFT LEVER


Raises and lowers the squeegee.

The meter display is divided into 10 vertical


bars. Bars illuminated on the far right indicate
full charge. Bars flashing near the left side
indicate the batteries should be recharged.
Further operation of the machine could
damage the machine or the batteries.
When the machine is left overnight with less
than a full charge, the display may initially
indicate a full charge. It will also indicate a full
charge if the batteries are disconnected, then
reconnected. After a few minutes of operation
the meter will give the correct charge level.

7. HOUR METER (OPTIONAL)


Records the number of hours the machines
brush has been in operation. This information
is useful in determining when to service the
machine.
8. CIRCUIT BREAKERS
Circuit breakers interrupt the flow of power in
he event of an electrical overload. When a
circuit breaker is tripped, reset it by pressing
the exposed button. If a circuit breaker
continues to trip, the cause of the electrical
overload should be found and corrected.

To lower the squeegee, lift and pull the lever


to the left and then lower.

30 Amp. Protects the scrub brush


motor.

To raise the squeegee, lift the lever and push


it to the right.

30 Amp. Protects the vacuum


motor.

5. SOLUTION CONTROL LEVER


Controls solution flow to scrub deck.
To increase flow pull and raise the knob to the
desired flow.
To decrease flow push the knob down.

SABER (SC) 86038350 01/29/07

3-6

CONTROLS - TRACTION
7

13

11
12
3
10

1. Solution Control Knob


2. Brush Switch
3. Brush Lift Lever
4. Vacuum Switch
5. Squeegee Lift Lever
6. Key Switch
7. Propel Buttons (Normally Forward)
8. Reverse Propel Button
9. Speed Control Knob
10. Battery Charge Level Indicator
11. Emergency Shut Off Switch (Optional)
12. Hour Meter (Optional)
13. Circuit Breakers

3-7

SABER (SC) 86038350 01/29/07

CONTROLS - TRACTION

1. SOLUTION CONTROL KNOB


Controls solution flow to scrub deck.
To increase flow, rotate knob clockwise.
To decrease flow, rotate knob
counterclockwise.

5. SQUEEGEE LIFT LEVER


Raises and lowers the squeegee.
To lower the squeegee, lift and pull the lever
to the left and then lower.
To raise the squeegee, lift the lever and push
it to the right.

If the brush motor is turned off or the direction


control lever is in neutral, the flow is
automatically interrupted until the motor is
turned on again. This feature prevents
unintentional draining of the solution tank and
allows the operator to adjust the solution flow
to the scrub deck without resetting each time
the scrubbing operation is interrupted.

2. BRUSH SWITCH
Controls the scrub brush motor.
To turn scrub brush on, press the top of the
switch. The brush will not rotate with the
direction control lever in neutral.
To turn the scrub brush off, press the bottom
of the switch.

6. KEY SWITCH
Controls the power for machine functions.
To turn machine on, rotate key clockwise.
To turn machine off, rotate key
counterclockwise.
FOR SAFETY: Always remove the key
when machine is unattended or during
service to prevent unauthorized
movement.

7. PROPEL BUTTONS (NORMALLY


FORWARD)
Controls the machine direction, scrub brush
and solution flow.
To propel machine forward, push the button
on either of the control handles.

3. BRUSH LIFT LEVER


Raises and lowers the brush.
To lower the brush, lift the lever from the
notch, move to the left, then lower.
To increase brush pressure, lock the lever into
the lowered position.
To raise the brush, lift the lever from its
lowered position and lock into highest notch.

4. VACUUM SWITCH
Controls the vacuum motor.

The scrub brush will not rotate and the


solution will not flow to the scrub deck unless
a propel button is pushed.

8. REVERSE PROPEL BUTTON


Controls the machine direction in reverse.
To propel machine backward, push the button
on the control panel and one of the buttons on
either of the control handles.

To start vacuum motor, press the top of the


switch.
To stop vacuum motor, press the bottom of
the switch.

SABER (SC) 86038350 01/29/07

3-8

CONTROLS - TRACTION

9. SPEED CONTROL KNOB


Controls the speed of the machine.
To increase speed, rotate knob clockwise.
To decrease speed, rotate knob
counterclockwise.

10. BATTERY CHARGE LEVEL INDICATOR


Indicates the charge level of the batteries.
The meter display is divided into 10 vertical
bars. Bars illuminated on the far right indicate
full charge. Bars flashing near the left side
indicate the batteries should be recharged.
Further operation of the machine could
damage the machine or the batteries.

12. HOUR METER (OPTIONAL)


Records the number of hours the machines
brush has been in operation. This information
is useful in determining when to service the
machine.
13. CIRCUIT BREAKERS
Circuit breakers interrupt the flow of power in
he event of an electrical overload. When a
circuit breaker is tripped, reset it by pressing
the exposed button. If a circuit breaker
continues to trip, the cause of the electrical
overload should be found and corrected.

When the machine is left overnight with less


than a full charge, the display may initially
indicate a full charge. It will also indicate a full
charge if the batteries are disconnected, then
reconnected. After a few minutes of operation
the meter will give the correct charge level.

11. EMERGENCY SHUT-OFF SWITCH


(OPTIONAL)
Shuts off machine.
To shut off machine, push the switch.
To restart machine, rotate the switch
clockwise.

3-9

SABER (SC) 86038350 01/29/07

3 Amp. Protects the machine


controls.
30 Amp. Protects the scrub brush
motor.
30 Amp. Protects the vacuum
motor.
25 Amp. Protects the propel
motor.

MACHINE OPERATION
PRE-RUN MACHINE INSPECTION
Do a pre-run inspection to find possible problems
that could cause poor performance or lost time
from breakdown. Follow the same procedure each
time to avoid missing steps.
NOTE: See maintenance section for pre-run
machine inspection checklist items.

STARTING MACHINE
NOTE: Perform pre-run machine check before
operating machine.
FOR SAFETY: Before starting machine, make
sure that all safety devices are in place and
operating properly.

4. Measure the chemical into the solution tank.


Liquid chemicals should be added to the
solution tank after filling with water. Dry
chemicals should be thoroughly mixed before
being added into the solution tank.
Commercially available, high alkaline floor
cleaners, are suitable for use in the solution
system.
NOTE: Read the chemical manufacturers
recommended proportion instructions.

5. Replace solution tank cover.

! WARNING

1. Turn the machine power on.

Flammable materials can cause an explosion


or fire. Do not use flammable materials in the
tanks.

2. Press the directional control button(s) to move


in the desired direction, if your machine is
traction model.

NORMAL SCRUBBING

EMERGENCY STOP PROCEDURES


1. Release the directional control button(s), if
your machine is traction model.
2. Turn machine power off.
3. If an electrical problem is suspected push in
emergency stop button, if machine is
equipped with this option.

Plan the scrubbing pattern in advance. The


longest track is around the perimeter of the area
to be cleaned. For efficient operation, the runs
should be the longest possible without turning,
stopping, or raising and lowering scrub
deck/squeegee.
NOTE: In order to achieve the best possible
results, the area which is to be cleaned should be
swept before scrubbing. Large debris, strings &
wire must be removed to prevent being caught in
the brush or squeegee.

FILLING SOLUTION TANK


FOR SAFETY: Before leaving or servicing
machine; stop on level surface, turn off
machine and remove key.
1. Turn the machine power off.
2. Remove solution tank cover.
3. Fill the solution tank with clean water, leaving
enough room for the required amount of
cleaning solution. The solution tank capacity
is 13 gallons (50 liters). The water must not
be hotter than 140 F (60C) to prevent
damage to the tank.

SABER (SC) 86038350 01/29/07

3-10

MACHINE OPERATION
TO STOP SCRUBBING

TO BEGIN SCRUBBING

1. Release the directional control button(s), if


your machine is traction model.

! CAUTION
When operating the machine around people,
pay close attention for unexpected movement.
Use extra caution around children.

2. Turn the scrub brush off.


3. Raise the scrub brush.

! WARNING
Flammable liquids and/or reactive metals can
cause explosions or fire! Do not pick up.

4. Raise the squeegee.


5. Turn the vacuum off.

1. Turn the machine power on.


6. Turn the machine power off.
2. Lower the squeegee.

DOUBLE SCRUB
3. Turn the vacuum on.
4. Lower the scrub brush to the floor.
5. Turn the scrub brush on (for traction model,
brush will start when machine is propelled).
6. Drive machine forward to begin scrubbing.
NOTE: Shut machine off immediately if water or
foam is expelled from the machine.
7. Adjust the speed of the machine, solution flow
and scrub brush pressure as necessary.
NOTE: For non-traction model, the solution flow
must be shut off to prevent unintentional draining
of solution tank. For traction model, once solution
flow rate is set it is not necessary to shut off
solution when stopping scrubbing. Solution flow
is automatically shut off when the brush motor
stops. When the brush motor is activated, flow
will automatically resume.

3-11

For floors which are heavily soiled or have thick


accumulations of floor finish the machine may not
clean sufficiently with one pass. In these cases it
will be necessary to double scrub.
To double scrub, make the first pass over the
surface being cleaned with the squeegee up,
vacuum off, the solution on, and brush down and
on. This allows the solution to stay in contact with
the soil while loosening the surface accumulation
with the brush. Allow time for the first application
to stay in contact with the floor. The length of time
between the first and second pass depends on
the amount of accumulation and the type of
chemical being used. A second scrubbing with the
squeegee down, vacuum on and again with
solution and brush on will further loosen the soil.
The additional application of solution will further
assist the difficult cleaning job.
FOR SAFETY: When using machine, go slow
on inclines and slippery services.

SABER (SC) 86038350 01/29/07

MACHINE OPERATION
EMPTYING AND CLEANING TANKS
1. Park the machine next to a floor drain. Drain
hoses are on the rear of the machine.
2. Turn the machine power off.
SOLUTION TANK
1. Unhook the small drain hose from the retainer.
Unscrew the T-handle plug enough to loosen
it, then lower the hose in the direction of the
drain. Slowly remove the plug from drain
hose.
2. Remove the solution tank cover.
3. Flush the solution tank out with clean water
and run several gallons of clean water through
systems. Do not use water hotter than 140F
(60C) to clean the tank, damage may occur.
NOTE: Never allow solution to remain in tank.
Damage to tank, seals and valves could occur.
4. Replace the drain plug and secure the drain
hose in the bracket.

RECOVERY TANK
1. Unhook the large drain hose from the retainer.
Unscrew the T-handle on the plug enough to
loosen it, then lower the hose in the direction
of the drain. Do not stand in front of the end
the of hose. Recovered solution will come out
with force. Slowly remove the plug from the
drain hose.
2. Raise the solution tank to access the recovery
tank. Make sure the support arm is fully
engaged. Remove the vacuum motor and rear
access cover. Flush the recovery tank out with
clean water. Do not use water hotter than
140F (60C) to clean the tank, damage may
occur.
3. Clean off the float and check for free
movement of the float ball. The float is
attached to the bottom of the vacuum motor.
4. Replace the drain plug and secure the drain
hose in the bracket.

5. If the machine is to be stored, leave solution


tank in the raised position.

SABER (SC) 86038350 01/29/07

3-12

MAINTENANCE
BATTERIES
The batteries provide the power to operate the
machine. The batteries require regular
maintenance to keep them operating at peak
efficiency.
The machine batteries will hold their charge for
long periods of time, but they can only be charged
a certain number of times. To get the greatest life
from the batteries, charge them when their charge
level reaches 25% of a full charge. Use a
hydrometer to check the charge level.
Do not allow the batteries to remain in a
discharged condition for any length of time.
Never expose a discharged battery to
temperatures below freezing. Discharged
batteries will freeze causing cracked cases. Do
not operate the machine if the batteries are in
poor condition or if they have a charge level below
25% (specific gravity below 1.155).
Keep all metallic objects off the top of the
batteries, as they may cause a short circuit.
Replace worn or damaged cables and terminals.
Check the electrolyte level in each battery cell
before and after charging the batteries. Never
add acid to the batteries, use distilled water. Do
not allow water level to fall below the battery
plates. Portions of plates exposed to air will be
destroyed. Do not overfill. Keep plugs firmly in
place at all times.

4-1

! CAUTION
When servicing machine, avoid contact with
battery acid.

! WARNING
Batteries emit hydrogen gas. Explosion or fire
can result. Keep sparks and open flame away.
Keep covers open when charging.

! WARNING
Wear eye protection and protective clothing
when working with batteries.

! WARNING
Charge batteries in a well ventilated area.
BATTERY MAINTENANCE
1. When cleaning the batteries, use a solution of
baking soda and water. Do not allow the
cleaning fluid to enter the battery cells,
electrolyte will be neutralized.
2. Maintain the proper electrolyte level in each
battery cell. If a cell should accidentally
overflow, clean immediately.
3. Wipe off the top of the batteries at least once
a week.
4. Test battery condition with a hydrometer at
least once a week.
5. Ensure that all connections are tight and all
corrosion removed.
6. Every 4 to 6 months, remove that batteries
from the machine and clean the battery cases
and battery compartment.

SABER (SC) 86038350 09/30/09

MAINTENANCE
CHECKING BATTERY SPECIFIC GRAVITY
Use a hydrometer to check the battery specific
gravity.

TO CHARGE THE BATTERIES

! CAUTION
When servicing machine, avoid contact with
battery acid.

! WARNING
WARNING

Battery Check

Batteries emit hydrogen gas. Explosion or fire


can result. Keep sparks and open flame away.
Keep covers open when charging.

! WARNING
Wear eye protection and protective clothing
when working with batteries.
CHECKING GRAVITY
A. Hydrometer
B. Battery
NOTE: Do not take readings immediately after
adding distilled water, if the water and acid are not
thoroughly mixed, the reading may not be
accurate.

Check the hydrometer readings against this chart.


BATTERY CONDITION
SPECIFIC GRAVITY
@ 80 F (27C)
1.265
100% CHARGED
1.225
75% CHARGED
1.190
50% CHARGED
1.155
25% CHARGED
1.120
DISCHARGED
NOTE: If the readings are taken when the battery
electrolyte is any temperature other than 80F
(27C), the reading must be temperature
corrected.

! WARNING
Charge batteries in a well ventilated area. Leave
the solution tank open.
Use a 24 volt, 20 amp maximum output, DC charger
which will automatically shut off when the batteries
are fully charged to charge the two battery pack.
1. Stop the machine in a clean, well ventilated area
next to the charger.
2. Turn the machine power off.
FOR SAFETY: Before leaving or servicing
machine; stop on level surface, turn off machine
and remove key.
3. Drain solution tank and raise the solution tank
and lock the support arm. Make sure the
support arm is fully engaged.

! WARNING
Batteries emit hydrogen gas. Explosion or fire
can result. Keep sparks and open flame away.
Keep covers open when charging.

To find the corrected specific gravity reading


when the temperature of the battery electrolyte is
other than 80F (27): Add (+) to the specific
gravity reading 0.004 (4 points), for each 10F
(6C) above 80 (27C).
Subtract (-) from the specific reading 0.004 (4
points), for each 10F (6C) below 80F (27C).

SABER (SC) 86038350 09/30/09

4-2

MAINTENANCE
4. Check the electrolyte level in each battery
cell. Before charging, add just enough
distilled water to cover the plates. After
charging is complete, add just enough
distilled water to bring up the level to the
indicator ring. If the water level is too high
before charging, normal expansion rate of
the electrolyte may cause an overflow.
Resulting in a loss of battery acid balance
and damage the machine.
5. Replace the battery caps, and leave them in
place while charging.
6. Unplug the battery connector from the
machine.
FOR SAFETY: When charging, connect the
charger to the batteries before connecting the
charger to the AC wall outlet. Never connect the
charger to the AC wall outlet first. Hazardous
sparks may result.

7. Plug the charger connector into the battery


connector. Connect the charger AC plug to
a wall outlet. The charger gauge should
indicate that the batteries are charging.
8. When the batteries are fully charged,
disconnect the charger from the AC wall
outlet, then disconnect the charger from the
batteries.
9. Connect the batteries to the machine
connector.
10. Check the electrolyte level. It should be up
to the indicator ring. If necessary, add
distilled water.
11. Lower the solution tank.

4-3

Machines equipped with onboard Charger:


1. Fully open Recovery Tank / Battery Cover or
prop in partially open position using bracket
(included). This will provide additional venting of
batteries during charging cycle.
2. Connect chargers AC power cord to AC mains.
The chargers YELLOW AC LED will light.
Note: When charger is energized, all machine
function will shut down.
3. After several seconds, the chargers green LED
will flash to indicate that charging is in process.
Note: If no lights are illuminated, or yellow LED
flashes, refer to the charger Product Manual
Troubleshooting section.
4. When charging is complete, both the yellow and
the green LEDs will remain on. The charger is
now in standby mode.
5. Disconnect chargers AC power cord.
6. Raise battery cover and check the battery
electrolyte level. It should be up to the indicator
ring. If necessary, add distilled water.
7. Lower the battery cover.
Note: For additional information about battery
charger function, please see the charger Product
Manual.

SABER (SC) 86038350 09/30/09

MAINTENANCE-From Serial Number **


ON-BOARD CHARGER BATTERY SELECTION

! WARNING
Disconnect charger from wall outlet before
changing charge profiles. Failing to do so could
result in electrical shock.

Only dipswitch SW1 effects the charging curve.


Select the appropriate dip switch setting from the
Charging Curve Table. Do not change settings of
SW2. Changing settings of SW2 dipswitch could
result in charger failure.

DIPSWITCH: SW1
Charging Curve Table
DP1
ON

DP2
OFF

ON

ON

CHARGING CURVE
IUIa-ACD-for Wet batteries (default
setting)
IUIa-O AGM-for AGM or Gel batteries
(maintenance free)

Dipswitches are located behind the label on the front


of the charger. Peel the top right corner back to
reveal two sets of dipswitches.

Once the appropriate charger setting has been


selected, replace label. To verify charger settings,
observe charger immediately after startup. When
configured for lead-acid batteries, the red LED will
flash twice. If configured for gel/AGM batteries the
green LED will flash twice.

**CALL MANUFACTURER FOR SERIAL NUMBER

SABER (SC) 86038350 11/25/09

4-4
4-4

MAINTENANCE
CHANGING BATTERIES
Stop the machine in a clean area next to the
charger. Turn off machine.
FOR SAFETY: Before leaving or servicing the
machine; stop on level surface, turn off machine
and remove key.
1.
2.
3.
4.

5.
6.
7.
8.

! WARNING
Batteries are a potential environmental hazard.
Consult your battery supplier for safe disposal
methods.

Raise the solution tank.


Engage solution tank support arm.
Disconnect battery pack from machine.
Use the proper size open end wrench to
disconnect main ground wire first and secure
cable terminal away from batteries.
Disconnect main positive lead and secure cable
terminals away from batteries.
Loosen both terminals on jumper cable and
remove.
Prepare a suitable site to place the batteries.
Attach suitable battery lifting device and lift
batteries from the machine.

4-5

SABER (SC) 86038350 09/30/09

+ red

- blk

- blk

+ red

MAINTENANCE
SCRUB BRUSHES
NOTE: All original equipment brushes are equipped
with Perform Alert. This feature will tell the
operator when it is time to replace the scrub brush.
Perform Alert brushes have pre-trimmed bright
yellow tufts to indicate the length of a worn out
brush. When the tufts in the scrub brush wear to a
length equal to the yellow tufts, the scrub brush
should be replaced.
There are five different types of brushes available to
cover applications from cleaning heavily soiled floors
to polishing. A pad driver is also available to take
advantage of the many cleaning pads on the market
and further add to the flexibility of the Saber
Compact. Please refer to the following to assist in
selecting the proper brush or pad for the work at
hand.

Blue Pads (Scrubbing) are used for heavy-duty


scrubbing and light stripping. The blue pads remove
less finish than brown stripping pads, yet will remove
black marks, stains and dirt.
Brown Pads (Stripping) are used for easy and
complete removal of old floor waxes/finishes. They
will quickly remove ground in dirt, black heel marks,
and spills. When used with the proper stripper, this
pad leaves the floor clean and ready for finishing.
The scrub brush should be checked before each
days work for wire, string, wear and damage. The
scrub brush should be replaced if brush bristles are
missing or if yellow Perform Alert indicates
minimum brush length.

REPLACING OR INSTALLING SCRUB


BRUSHES

UNCOATED FLOORS
Aggressive Grit is a nylon fiber impregnated with
silicone carbide grit. It grinds away stain, soil, and
removes surface material.
Mild Grit is a less aggressive silicone carbide grit
suitable for cleaning medium soil conditions.
Advantages are faster ground speed than nylon
bristles on light solid applications.
Nylon is a general-purpose scrub brush with stiff
bristles. Polypropylene works well for maintaining
concrete, wood and tile floors.

FINISHED FLOORS
Nylon Polish is the softest brush. It will gently clean
finished tile or terrazzo floors without removing floor
finish or floor material. Used for washing highly
polished or burnished floors.

1. With the scrub deck up, turn the machine power


off.
FOR SAFETY: Before leaving or servicing the
machine; stop on level surface, turn OFF
machine and remove key.
2. Locate release lever on top of brush or pad
driver. Rotate release lever counter-clockwise
and the brush/pad driver will release and drop
down.
3. To reinstall, center the brush driver under the
brush drive hub. Raise until it contacts brush
driver assembly. Turn clockwise until release
lever plate locks into position.
NOTE: Check that release plate is completely
closed and pad/brush is securely attached. Damage
to driver or brush could occur.

Nylon bristles are used in a variety of applications


on coated or uncoated surfaces.
White Pads (Polishing) are used for dry polishing to
achieve a high-gloss appearance, or surface
washing on highly polished or burnished floors.
Red Pads (Buffing) are used for light-duty
scrubbing. When used with a mild detergent they
will provide surface cleaning without removing the
finish.

SABER (SC) 86038350 09/30/09

4-6

MAINTENANCE
SQUEEGEE BLADES

DELUXE SQUEEGEE BLADES

The front squeegee blade allows solution to pass


through channels in the blade into the squeegee
assembly while maintaining vacuum to provide lift.

The front squeegee blade allows solution to pass


through channels in the blade into the squeegee
assembly while maintaining vacuum to provide lift.
The front blade has four wear surfaces and can be
rotated for extended life. The front blade should not
require regular replacement under normal use.

The rear blade wipes the floor to a near dry


condition. It is important the rear blade be in good
condition to properly do its job.
Check both the front and rear squeegee blades for
damage and wear each day in the pre-run check.
Change the front blade if it is torn or has an uneven
edge. Change the rear blade if it is less than 1/2 the
original thickness.

TO REMOVE SQUEEGEE ASSEMBLY


1. With the squeegee in the up position, turn the
machine power off.
2. Loosen both squeegee knobs and pull squeegee
assembly rearward from the lifting carrier.
3. Inspect or repair as necessary and reinstall.

TO REPLACE SQUEEGEE BLADES


1. With the squeegee in the up position, turn the
machine power off.

The rear blade wipes the floor to a near dry


condition. It is important the rear blade be in good
condition to properly do its job. Each rear squeegee
blade has four wear surfaces for extended service.
Check both the front and rear squeegee blades for
damage, wear, and adjustment each day in the prerun check. Change the front blade if it is torn or has
an uneven edge. Change the rear blade if it is less
than 1/2 the original thickness.

ADJUSTING DELUXE SQUEEGEE


Adjusting the squeegee is a two-part process. First,
the squeegee assembly must have correct pitch in
order for the squeegee blade to have the same
deflection at each tip as well as the center. The
knob on the squeegee linkage controls the pitch
adjustment. The second adjustment is the
deflection.

FOR SAFETY: Before leaving or servicing


machine; stop on level surface, turn off machine
and remove key.
2. Remove the squeegee assembly from the
machine. Remove all screws and remove blade
retainer strap and remove squeegee blade.
3. Replace squeegee blades as required.
4. Install blade with ribbed surface facing out.
5. Install squeegee retainer strap.
6. Install all screws starting from center and
working to ends.

3/8

PR OPER DEF LECT ION OF SQUEEGEE BLADE

SQUEEGEE DEFLECTION
CORRECT

NOT ENOUGH

TOO MUCH
SQUEEGEE SIDE VIEW OF BLADES

4-7

SABER (SC) 86038350 09/30/09

MAINTENANCE
TO ADJUST SQUEEGEE PITCH
1. Choose a smooth, level surface. Turn ON the
key switch and vacuum switch. Lower the
squeegee and drive forward at least 2 feet
(60cm.).
2. With the squeegee down, stop the machine. Do
not allow machine to roll back.
FOR SAFETY: Before leaving or servicing the
machine, stop on level surface, turn off machine
and remove key.
3. Determine the differences, if any, in deflection of
the squeegee blade between each end and the
middle. Proper adjustment is obtained when
deflection is equal all the way across the
squeegee blade.
4. To decrease the deflection of the squeegee
blade at the ends, adjust plastic knobs at the far
right or left of squeegee assembly.
5. Check the deflection of the squeegee blades
again. Repeat steps 1 through 4 until the
deflection is equal across the entire rear
squeegee blade.

TO ADJUST AMOUNT OF REAR


SQUEEGEE DEFLECTION
1. Choose a smooth, level surface. Turn ON the
key switch and vacuum switch. Lower the
squeegee and drive forward at least 2 feet
(60cm.).
2. With the squeegee down, stop the machine. Do
not allow machine to roll back.
FOR SAFETY: Before leaving or servicing
machine, stop on level surface, turn off machine
and remove key.

TO REPLACE OR ROTATE REAR


SQUEEGEE BLADE
1. With the squeegee in the up position, turn key
switch OFF.
FOR SAFETY: Before leaving or servicing
machine; stop on level surface, turn off machine
and remove key.
2. Remove the squeegee assembly from the
machine. Unlatch and remove blade retainer
strap and remove squeegee blade.
3. Rotate the squeegee to new edge position or
replace as required. Each blade has four edge
positions.
4. Install blade on locating tabs of squeegee
assembly.
5. Install squeegee retainer strap.
6. Fasten and lock latch, adjust latch only tight
enough to take up slack in retaining strap.

TO REPLACE OR ROTATE FRONT


SQUEEGEE BLADE
1. With the squeegee in the up position, turn key
switch OFF.
2. Remove the squeegee from the machine.
Loosen (3) thumb screws securing retainer
strap.
3. Remove front retainer strap.
4. Remove squeegees blade from locating tabs on
squeegee assembly and rotate to new position
or replace as required.
5. Install blade on locating tabs of squeegee tool.
6. Replace front retainer strap.
7. Secure strap by tighten (3) thumb screws.

GREASING AXLES

3. Observe the amount of squeegee deflection. It


should deflect approximately 3/8 in. (9.5mm)
across the entire width of the squeegee.
4. To increase the squeegee deflection, turn the
center knob above the lift carrier bracket
clockwise. To decrease the deflection, turn the
knob counterclockwise.
NOTE: The deflection should be consistent along
the length of the squeegee. If the deflection varies
from end to end the knobs can be adjusted
independently to correct the variation.
5. Turn on the key switch. Raise, then lower
squeegee assembly. Drive forward at least 2
feet (60cm).
6. Repeat steps 2 through 4 until deflection of
approximately 3/8 in. (9.5mm) is reached.

1. Apply 1-2 strokes of MOBILTEMP78 or


compatible clay-based or calcium-based grease
per service schedule.

SABER (SC) 86038350 09/30/09

4-8

MAINTENANCE
SERVICE SCHEDULE
MAINTENANCE

DAILY

Check batteries after charging; add water if


necessary
Check pad wear to prevent buildup of
chemicals
Check linkages and connectors for wear and
damage
Check hoses for wear, blockages, or damage
Clean squeegee; check for adjustment;
inspect for wear
Check handles, switches, knobs, domes, and
gaskets for damage
Clean out recovery tank
Clean out solution tank; remove and clean
screen
Clean outside of all tanks; check for damage
Run vac motor for at least one minute to
allow motor to dry
Store with dome off tank to allow the tank to
dry
Check scrub deck splash skirt
Check batteries for corrosion, cracks and
evidence of overheating
Check all bearings for noise
Check all gaskets for wear and leakage
Check vac motor carbon brushes
Check brushes for wear; ensure bristles are
not damaged
Check linkages for wear and damage
Grease wheels and casters
Check squeegee blades for wear and frame
for damage
Check overall performance of machine
Clean batteries and terminals
Thoroughly clean the machine
Check parking brake (inspect cables,
linkages and pulleys)
Check carbon brushes in all vacuum, brush
drive, and propel motors
Blow out dust in motors
Inspect motor commutators
Clean chains, cables and pulleys
Clean pivot points on squeegee and scrub
deck linkages

4-9

WEEKLY

MONTHLY

100
HRS

200
HRS

*
*
*
*
*
*
*
*
*
*
*
*

SABER (SC) 86038350 09/30/09

*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*

MACHINE TROUBLESHOOTING
PROBLEM
Poor or no water pick-up

CAUSE
Debris caught on squeegee

SOLUTION
Remove debris

Worn squeegee blades


Vacuum hose clogged

Replace squeegee blades


Clear obstruction from
hose
Vacuum hose disconnected Reconnect vacuum hose
from squeegee or recovery
tank
Vacuum hose damaged
Replace vacuum hose
Vacuum motor inlet screen
dirty
Recovery tank not sealed

Recovery tank full

Check vacuum motor


position. Replace
damaged seal.
Empty recovery tank
Use less or different
detergent
Use defoamer
Drain recovery tank

Circuit breaker tripped

Reset circuit breaker

Loose connection

Check motor wires and


connections
Replace contactor
Replace brushes, check
commutator
Remove debris

Foam filling recovery tank

Vacuum motor does not run, or


runs slowly

Faulty vacuum contractor


Worn vacuum motor
brushes
Debris caught in scrub
brush
Worn brush or pad

Poor scrubbing performance

Brush motor does not run, or runs


slowly

Clean inlet screen

Replace brush or pad

Improper detergent, brush


or pad used
Low scrub brush down
pressure
Low battery charge

Contact equipment or
application specialist
Increase brush pressure
(traction model only)
Charge batteries

Circuit breaker tripped

Reset circuit breaker

Loose connection

Check motor wires and


connection
Replace contactor

Faulty brush motor


contactor
Worn brush motor brushes

SABER (SC) 86038350 09/30/09

Replace brushes, check


commutator

4-10

MACHINE TROUBLESHOOTING
PROBLEM
Little or no solution flow to the
floor

CAUSE
Solution tank empty

SOLUTION
Fill solution tank

Solution flow turned off or


set too low
Solution strainer plugged

Turn on or increase flow


setting
Clean solution strainer

Solution hoses obstructed

Clear obstruction from


hose
Clean or replace

Solution solenoid valve


obstructed or stuck
(traction model only)
Battery disconnected

No power to machine

Emergency shut-off
activated (traction model
only)
Battery connections
corroded
Faulty main contactor
Little or no propel (traction model
only)

4-11

Faulty power switch


Low battery charge
Machine turned on with
directional control button(s)
not in neutral
Controller overheated
Loose connection

SABER (SC) 86038350 09/30/09

Check all battery cable


connections
Reset

Clean connections
Replace contactor
Replace switch
Charge batteries
Allow control button to
return to neutral. Restart
Allow cool down period
Check motor wires and
connection

PARTS

SABER (SC) 86038350 9/30/09

CONTROL HANDLE GROUP - NON-TRACTION


2

1
5

3
7
4

5-1

SABER (SC) 86038350 01/29/07

CONTROL HANDLE GROUP NON TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11

PART NO.
86031740
86005750
86081960
86006750
86006950
86278110
86010670
86079370
86218800
86277700
86005700

PRV NO.
27861
57113
62865
70302
70532
81491
87029
620108
41540
70944
57104

QTY
1
6
1
2
4
4
8
1
1
2
2

DESCRIPTION
CONSOLE, HANDLE
NUT, 5/16-18 HEX NYLOCK
PLATE, DRAIN HOSE
SCR, 5/16-18 X 1"HHCSGR5PLT DL
SCR, 10-32 X 1/2 PPHMS BLK NP
SET SCR, 5/16-18 X1.5 CP SS DL
WASHER, 5/16 FLAT SS
PLATE, DRAIN HOSE OBC
HANGER, CHARGER CORD 172
SCR, 10-32 X 3/8 PTHMS BLK
NUT, 10-32 W/STAR WASHER PLTD

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-2

CONTROL HANDLE GROUP - TRACTION

1
5

3
8
4

5-3

SABER (SC) 86038350 01/29/07

CONTROL HANDLE GROUP - TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12

PART NO.
86351330
86005750
86081900
86006750
86006950
86007220
86278110
86010670
86079360
86218800
86277700
86005700

PRV NO.
27891
57113
62854
70302
70532
72166
81491
87029
620107
41540
70944
57104

QTY
1
6
1
2
4
2
4
8
1
1
2
2

DESCRIPTION
CONSOLE, HANDLE PROPEL
NUT, 5/16-18 HEX NYLOCK
PLATE, DRAIN HOSE
SCR, 5/16-18 X 1"HHCSGR5PLT DL
SCR, 10-32 X 1/2 PPHMS BLK NP
SWITCH, SPST MOMENTARY
SET SCR, 5/16-18 X1.5 CP SS DL
WASHER, 5/16 FLAT SS
PLATE, DRAIN HOSE OBC TRAC
HANGER, CHARGER CORD 172
SCR, 10-32 X 3/8 PTHMS BLK
NUT, 10-32 W/STAR WASHER PLTD

SABER (SC) 86038350 01/14/11

SERIAL NO.
FROM

NOTES:

5-4

DECAL GROUP

4B
9

2
8

4A

1A
1B
3

5-5

SABER (SC) 86038350 01/29/07

DECAL GROUP
REF
1A
1B
2
3
4A
4B
5
6
7
8
9

PART NO.
86004970
86245910
86259210
86242650
86242670
86242660
86242940
OPEN
OPEN
86242850
86242930

PRV NO.
50990
50991
500142
500143
500145
500144
500245
500213
500244

QTY
1
1
1
1
1
1
1
1
1

DESCRIPTION
LABEL, WINDSOR LOGO DOMED
LABEL, QUADRA LOGO DOMED
LABEL, MAIN (RIGHT)
LABEL, MAIN (LEFT)
LABEL, CONTROL PANEL
LABEL, CONTROL PANEL
LABEL, CIRCUIT BREAKER 2.4L
OPEN
OPEN
LABEL, SOLUTION
LABEL, CIRCUIT BREAKER W/ HM

SERIAL NO.
FROM

NOTES:

*(1)

NON-TRACTION
TRACTION
NON-TRACTION

*(1)

NON-TRACTION
TRACTION

* SEE SERIAL NUMBER PAGE

NOTE: SEE SAFETY LABEL LOCATION PAGE FOR SAFETY LABEL INFORMATION.

SABER (SC) 86038350 04/26/12

5-6

ELECTRICAL PANEL GROUP NON-TRACTION

11
9
7
4
6
12
1

3
2

5-7

10

SABER (SC) 86038350 01/29/07

ELECTRICAL PANEL GROUP - NON-TRACTION

REF
1
2
3

PART NO.
86001910
86237720
86005520

PRV NO.
14606
35246
54145

4
5
6
7
8
9
10
11
12

86077640
86081890
86273990
86006850
86007140
86255910
86255920
86008900
86279300

57105
62849
70067
70393
72130
73659
73811
80845
87134

QTY
DESCRIPTION
2 BREAKER, 30A 50VDC CIRCUIT
1 GASKET, ELECTRICAL PANEL
1 METER,24V BATTERY CHARGE LEVEL
4 NUT, 1/4-20 HEX W/STAR WASHER
1 PLATE, ELECTRICAL PANEL
4 SCR, 6-32 X 3/8 PPHMS
SS
2 SET SCR, 1/4-20X 1.25L
2 SWITCH, SPST 2-POSITION ROCKER
2 STANDOFF, 1/4-20 X 1.0 HEX INS
2 STANDOFF, 6-32 X 1/2 HEX NYL
2 BOOT, SEAL-PUSH BUTTON 7/16-28
4 WASHER, #6 LOCK

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-8

ELECTRICAL PANEL GROUP - TRACTION


14
10

28

32

11
30

13
12

18

27
20
24

17
4
19
29

1
2

8
21
16

15

22

31
23
26
7

5-9

SABER (SC) 86038350 01/29/07

ELECTRICAL PANEL GROUP - TRACTION

REF
1
2
3
4
5
6
7
8

PART NO.
86001910
86001920
86002000
86002010
86002740
86002720
86237720
86004850

PRV NO.
14606
14607
14717
14942
270087
270077
35246
48072

QTY
2
1
1
1
1
1
1
2

86005520

54145

10
11
12
13
14
15
16
17

86005680
86005700
86005710
86005720
86271170
86081740
86005880
86250160

57047
57104
57105
57106
57138
62826
620051
66321

4
4
2
2
4
1
1
1

DESCRIPTION
BREAKER, 30A 50VDC CIRCUIT
BREAKER, 25A 50VDC CIRCUIT
BREAKER, 3 AMP
BOOT, 3/8 CIRCUIT BREAKER
CONTROLLER, CURTIS 1210 24V 45A
CIRCUIT BOARD, SOLUTION
GASKET, ELECTRICAL PANEL
KNOB, 1.06OD X .25ID W/SET SCR
METER,24V BATTERY CHARGE
LEVEL
NUT, 1/4-20 HEX NYLOCK
NUT, 10-32 W/STAR WASHER PLTD
NUT, 1/4-20 HEX W/STAR WASHER
NUT, 8-32 W/STAR WASHER PLTD
NUT, 5/16-18 JAM
PLATE, ELECTRICAL PANEL
PLATE, ELECTRICAL MOUNT
PLUG, .875 HOLE

18
19
20
21
22

86006360
86273990
86006850
86007140
86007170
86004860
86257030
86255910
86255920
86008900
86279130
86279300
86279470
86006310
86003410

67118
70067
70393
72130
72159
48073
72168
73659
OPEN
73811
80845
87083
87134
87165
66335
29215

2
6
1
2
1
1
1

RELAY, 24VDC SOLENOID


SCR, 6-32 X 3/8 PPHMS SS
SET SCR, 1/4-20X 1.25L
SWITCH, SPST 2-POSITION ROCKER
SWITCH KEY TWO POSITION
KEY, SWITCH
SWITCH, MOMENTARY, DPST
STANDOFF, 1/4-20 X 1.0 HEX INS

23
24
25
26
27
28
29
30
31
32

2
3
4
6
4
1
1

SERIAL NO.
FROM

NOTES:

*(2)
**

WAS 27858

*(2)

(NOT SHOWN)

STANDOFF, 6-32 X 1/2 HEX NYL


BOOT, SEAL-PUSH BUTTON 7/16-28
WASHER, 5/16 SPLIT LOCK PLTD
WASHER, #6 LOCK
WASHER, #10 SPLIT LOCK PLTD
POTENTIOMETER, 50K OHMS
DIODE ASM, 76075 X 76075

SERVICE ITEM

* SEE SERIAL NUMBER PAGE


* * CALL MANUFACTURER FOR SERIAL NUMBER

SABER (SC) 86038350 01/29/07

5-10

HOUR METER

NON-TRACTION

4A

3A
1
2

TRACTION

4B

5B

1
2
3B

5-11

SABER (SC) 86038350 01/29/07

5A

HOUR METER

REF
1
2
3A

PART NO.
86005530
86255920
86268650

PRV NO.
54154
73811
88490

QTY
DESCRIPTION
1 METER, 12-48 VDC LED HOUR
2 STANDOFF, 6-32 X 1/2 HEX NYL
1 WIRE, 4" RED/18 76040 X 76040

3B
4A

86267340
86266840

880269
880075

1
1

WIRE, 22" RED/18 76075 X 76040


WIRE, 8" RED/18 76031 X 76031

4B
5A

86267350
86266690

880270
880034

1
1

WIRE, 14" RED/18 76008 X 76040


WIRE, 6" BLK/18 76011 X 76040

5B

86267360

880271

WIRE, 14" BLK/18 76011 X 76040

SERIAL NO.
FROM
*(1)

NOTES:

NON-TRACTION
TRACTION
NON-TRACTION
TRACTION
NON-TRACTION
TRACTION

* SEE SERIAL NUMBER PAGE

SABER (SC) 86038350 01/29/07

5-12

RECOVERY TANK GROUP

8
6
1
3
18

5
14

4
11

10

16
9
15
17
1
19

NON-TRACTION

13
15
7
15
7
12

5-13

SABER (SC) 86038350 01/29/07

RECOVERY TANK GROUP

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17

PART NO.
86002400
86008400
86232180
86004260
86004450
86005750
86006240
86006760
86278180
86008260
86233410
86278110
86085510
86010670
86096020
86095960

PRV NO.
20064
OPEN
78499
27877
39472
40019
57113
66227
70305
70218
75294
81270
81491
82575
87029
89127
89198

QTY
2
1
1
1
1
4
1
2
2
1
2
4
1
6
1
1

18
19

86004370
86003010

39547
27759

1
1

DESCRIPTION
CLAMP, 2 WORM GEAR X .312W
TETHER, DRAIN PLUG
CAP, 3 INCH MPT
HOSE, 1.5 X 24.0 DRAIN
HOSEBARB, 1.5 DOUBLE MCHD
NUT, 5/16-18 HEX NYLOCK
PLUG, DRAIN HOSE
SCR, 5/16-18 X 3/4HHCSGR5PLTDL
SHOULDER BOLT, 3/8OD X 1/2L
TANK, RECOVERY
CLAMP, 3/4 DIA CUSHION .406DIA
SET SCR, 5/16-18 X1.5 CP SS DL
PLATE, TANK SUPPORT
WASHER, 5/16 FLAT SS
WLDMNT, HINGE PIN
WELDMENT, HINGE

SERIAL NO.
FROM

NOTES:

HOSE ASM, 1.5 BLK VAC X 21


CUFF, HOSE 1.5" BLK A 2161

SABER (SC) 86038350 01/29/07

5-14

SCRUB BRUSH/PAD DRIVER GROUP 20 IN

6
9
4
8

5-15

SABER (SC) 86038350 01/29/07

2A
2B
2C
2D

SCRUB BRUSH/PAD DRIVER GROUP - 20 IN

REF
1
2A
2B
2C
2D

PART NO.
86000410
86000420
86000430
86283870
86000440

PRV NO.
02436
02437
02438
02439
02440

86005070

51284

4
5
6
7
8
9

86276590
86276580
86276600
86007910
86007280
86005940

70695
70694
70696
73817
730011
62852

QTY
-

DESCRIPTION
PAD DRIVER, 20" SD
BRUSH, 20" POLYPROPYLENE SD
BRUSH, 20" NYLON SD
BRUSH, 20" NYLON POLISH SD
BRUSH, 20" MILD GRIT SD
LOCK, PAD CENTER SNAP,TWO
STEP
SCR, 12-24 X 1.0 PPHMS SS
SCR, 8-32 X 3/4 PTHMS
SCR, 10-32 X 3/4 PTHMS
SPRING, EXT .31D X 2.0L X .03W
SOCKET, DRIVE BRUSH
PLATE, BRUSH RELEASE

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-16

SCRUBHEAD GROUP NON-TRACTION

10
13
14

19
7
12

11

2
20
6

21
15
9
22
23
24
18
4
3
17
16
8

5-17

SABER (SC) 86038350 01/29/07

SCRUBHEAD GROUP - NON-TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16

PART NO.
86072330
86002410
86003420
86004810
86005320
86001970
86005630
86005730
86007020
86006740
86006820
86253940
86253530
86233560
86234800
86278910
86279130

PRV NO.
14357
20077
29220
48040
53630
14695
57022
57111
70673
70266
70385
730140
730001
80805
27899
87003
87083

QTY
1
1
1
1
1
1
1
1
4
1
1
1
2
1
4
1

17
18
19
20
21
22
23
24

86279630
86279640
86010890
86008660
86068380
86011070
86010760
86006270

87212
87213
89059
80605
14402
89219
87142
66276

1
1
1
1
1
1
2
1

DESCRIPTION
BRKT, DECK MOUNT
CLAMP, WORM #HS356
DRIVER, BRUSH SD
KEY, 1/4 SQ X 1.00
MOTOR ASM, 24VDC 200 RPM GEAR
BRUSH SET, BRUSH MOTOR
NUT, 3/8-16 HEX NYLOCK THIN SS
NUT, 3/8-16 HEX
SCR, 5/16-18 X 1.25 HHCS SS
SCR, 3/8-16 X 1" HHCSGR5PLT DL
SCR, 3/8-16 X 2.0 HHCS GR5 PLT
SKIRT, 3.5 X 57.5 EXT
SHROUD, 20 IN SCRUB DECK
CLIP, TREE .19 HOLE FLAT HEAD
COVER, BRUSH RELEASE 5X6
WASHER, 3/8 ID X 7/8 OD SS
WASHER, 5/16 SPLIT

SERIAL NO.
FROM

NOTES:

(NOT SHOWN)

WASHER, .344IDX1.13ODX.09T PLT


WASHER, .78IDX1.63ODX.25T PLT
WHEEL, SQUEEGEE
COTTER, 5/16" RING
BRKT, BRUSH ASSIST
WHEEL, 1.812ODX.314IDX.952W
WASHER, .344X.69X.066 FLAT PLT
PIN, CLEVIS 5/16 X 1.625 LG

SABER (SC) 86038350 01/29/07

5-18

SCRUBHEAD GROUP TRACTION

10
1
19
13
14

7
6
12

11A-

18

15

3
17
16
8

5-19

SABER (SC) 86038350 01/29/07

SCRUBHEAD GROUP - TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16

PART NO.
86072330
86002410
86003420
86004810
86005320
86001970
86005630
86005730
86007020
86006740
86006820
86253940
86253530
86233560
86234800
86278910
86279130

PRV NO.
14357
20077
29220
48040
53630
14695
57022
57111
70673
70266
70385
730140
730001
80805
27899
87003
87083

QTY
1
1
1
1
1
1
1
1
4
1
1
1
2
1
4
1

17
18
19

86279630
86279640
86010890

87212
87213
89059

1
1
1

DESCRIPTION
BRKT, DECK MOUNT
CLAMP, WORM #HS356
DRIVER, BRUSH SD
KEY, 1/4 SQ X 1.00
MOTOR ASM, 24VDC 200 RPM GEAR
BRUSH SET, BRUSH MOTOR
NUT, 3/8-16 HEX NYLOCK THIN SS
NUT, 3/8-16 HEX
SCR, 5/16-18 X 1.25 HHCS SS
SCR, 3/8-16 X 1" HHCSGR5PLT DL
SCR, 3/8-16 X 2.0 HHCS GR5 PLT
SKIRT, 3.5 X 57.5 EXT
SHROUD, 20 IN SCRUB DECK
CLIP, TREE .19 HOLE FLAT HEAD
COVER, BRUSH RELEASE 5X6
WASHER, 3/8 ID X 7/8 OD SS
WASHER, 5/16 SPLIT

SERIAL NO.
FROM

NOTES:

(NOT SHOWN)

WASHER, .344IDX1.13ODX.09T PLT


WASHER, .78IDX1.63ODX.25T PLT
WHEEL, SQUEEGEE

SABER (SC) 86038350 01/29/07

5-20

SCRUBHEAD LIFT GROUP NON TRACTION

25

10

26
20
20
18

20
16
2

20

12

12

23

13

3
4A
4B
24

19

19
1

21

22

8
17

2
24

6
12

15
20

1
12

11

23

14
17

5-21

SABER (SC) 86038350 01/29/07

18

SCRUBHEAD LIFT GROUP NON-TRACTION

REF
1
2
3
4A

PART NO.
86228840
86228880
86072350
86072360

PRV NO.
09124
09132
14360
14361

QTY
4
2
1
1

DESCRIPTION
BEARING, FLANGED.314IDX.502OD
BEARING, .314 ID X .503 OD X 1
BRKT, LIFT LEVER HANDLE
BRKT, LIFT LEVER

4B

86073420

149985

BRKT, LIFT LEVER OBC

5
6
7
8
9
10
11
12
13
14
15
16
17

86072370
86072380
86072520
86066960
86238310
86238430
86005680
86005750
86081880
86273810
86274690
86006730
86006750

14363
14364
14401
14362
36133
36191
57047
57113
62848
70018
70258
70259
70302

1
1
1
1
1
1
4
10
1
4
1
1
6

BRKT, LIFT LEFT


BRKT, LIFT, RIGHT
BRKT, SCRUB DECK MOUNT
BAR, LINKAGE
GRIP, 3/16" X 1.0" FLAT BAR
GROMMET 1.00 ID 3/16 GRIP
NUT, 1/4-20 HEX NYLOCK
NUT, 5/16-18 HEX NYLOCK
PLATE, SCRUB DECK POSITION
SCR, 1/4-20 X 1 HHCS SS
SCR, 5/16-18 X 1.5 HHCS GR5PLT
SCR, 5/16-18 X 1.75 HHCS PLTD
SCR, 5/16-18 X 1"HHCSGR5PLT DL

18
19
20
21
22
23
24
25
26

86006760
86274910
86010670
86279320
86279350
86259400
86259410
86072340
86275180

70305
70325
87029
87136
87140
87205
87206
14358
70375

2
2
9
2
4
3
3
1
3

SCR, 5/16-18 X 3/4HHCSGR5PLTDL


SCR, 5/16-18 X 1.25HHCS GR5PLT
WASHER, 5/16 FLAT SS
WASHER, .52 I.D. X .875 O.D.SS
WASHER, WAVE 1/2ID X3/4D X.125
WASHER, THRUST.51 ID X 1 ODBRO
WASHER, THRUST.51 ID X1ODX.063
BRKT, TOWER
SCR, 5/16-18 X 1/2 HHCS GR5

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

SCC20, SCC20T,
SCXC20T

5-22

SCRUBHEAD LIFT GROUP - TRACTION

27
10

28
18

21

21

21
16

21
2

12

25

12

13

3
4
26

19
19
1

22

23

25

20
24

12

1
19

17

2
26

6
12

15
21

1
12

11

5-23

26

21
19

25

14

SABER (SC) 86038350 01/29/07

18

SCRUBHEAD LIFT GROUP - TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17

PART NO.
86228840
86228880
86072350
86072360
86072370
86072380
86072390
86066970
86238310
86238430
86005680
86005750
86081760
86273810
86274690
86006730
86006750

PRV NO.
09124
09132
14360
14361
14363
14364
14365
14370
36133
36191
57047
57113
62828
70018
70258
70259
70302

QTY
10
2
1
1
1
1
1
2
1
1
4
12
1
4
1
1
2

18
19
20
21
22
23
24
25
26
27
28

86006760
86274910
86254880
86010670
86279320
86279350
86090270
86259400
86259410
86072340
86275180

70305
70325
730005
87029
87136
87140
87204
87205
87206
14358
70375

2
8
1
13
2
4
4
5
11
1
3

DESCRIPTION
BEARING, FLANGED.314IDX.502OD
BEARING, .314 ID X .503 OD X 1
BRKT, LIFT LEVER HANDLE
BRKT, LIFT LEVER
BRKT, LIFT LEFT
BRKT, LIFT, RIGHT
BRKT, SCRUB DECK MOUNT
BAR, TENSIONER
GRIP, 3/16" X 1.0" FLAT BAR
GROMMET 1.00 ID 3/16 GRIP
NUT, 1/4-20 HEX NYLOCK
NUT, 5/16-18 HEX NYLOCK
PLATE, SCRUB DECK POSITION
SCR, 1/4-20 X 1 HHCS SS
SCR, 5/16-18 X 1.5 HHCS GR5PLT
SCR, 5/16-18 X 1.75 HHCS PLTD
SCR, 5/16-18 X 1"HHCSGR5PLT DL

SERIAL NO.
FROM

NOTES:

SCR, 5/16-18 X 3/4HHCSGR5PLTDL


SCR, 5/16-18 X 1.25HHCS GR5PLT
SPRING,COMP 1.687ODX4.5LX.234W
WASHER, 5/16 FLAT SS
WASHER, .52 I.D. X .875 O.D.SS
WASHER, WAVE 1/2ID X3/4D X.125
WASHER, RECTANGULAR HOLE
WASHER, THRUST.51 ID X 1 ODBRO
WASHER, THRUST.51 ID X1ODX.063
BRKT, TOWER
SCR, 5/16-18 X 1/2 HHCS GR5

SABER (SC) 86038350 01/29/07

5-24

SOLUTION TANK GROUP- NON-TRACTION


3

20
21

23
24

24
13
25

12

7
1
8
11

5
19
9

9
26
1
27

14

16

10
36
34

4
17

17

41

42

5-25

SABER (SC) 86038350 03/20/08

SOLUTION TANK GROUP NON-TRACTION


SERIAL NO.
REF PART NO. PRV NO. QTY
DESCRIPTION
NOTES:
FROM
1
86233150
20042
5 CLAMP, 3/8 HOSE (D-SLOT)
2
86279880
27425
1 CORD, SOLUTION COVER
3
86234780
27772
1 COVER, SOLUTION TANK
4
86238430
36191
2 GROMMET 1.00 ID 3/16 GRIP
5
86282040
39558
1 HOSE, 1/2 ID NYLOBRAID X 40"
6
86050350
39482
1 HOSE, 1/2 ID NYLOBRAID X 15
*(4)
7
86197940
40027
1 HOSEBARB, 3/8MPTX1/2 90D DL
8
86004460
41333
2 HINGE, SCRUBBER TANK
9
86005750
57113
2 NUT, 5/16-18 HEX NYLOCK
10
86006760
70305
4 SCR, 5/16-18 X 3/4HHCSGR5PLTDL
11
86007000
70632
2 SCR, 5/16-18 X 3/4 FHSCS BLKZC
12
86007970
73864
1 STRAINER, 3/8 IN. NPT 60 MESH
13
86008250
75293
1 TANK, SOLUTION
14
86233410
81270
2 CLAMP, 3/4 DIA CUSHION .406DIA
15
86258720
84075*
1 VALVE, 3/8 FPT BALL
*(3)
16
86010670
87029
3 WASHER, 5/16 FLAT SS
17
86005680
57047
4 NUT, 1/4-20 HEX NYLOCK
18
86257310
73886*
1 SWIVEL, SOLUTION CABLE
19
86002800
270121
1 CABLE, .062 X 43 SS PUSH/PULL
20
86009700
82267
1 PLUG, 5/8" DRAIN HOSE
21
86001600
40076
1 SLEEVE .63 ID X 1.0 OD
22
86197310
141045
1 BUSHING, 3/8 X 3/8 NPT (F18-3)
23
86008400
78499
1 TETHER, DRAIN PLUG
24
86002390
20063
2 CLAMP, 1.75" WORM GEAR X .312
25
86004310
39505
1 HOSE, 1.0 X 18.0 DRAIN
26
86010540
84141
1 VALVE, 24VDC SOL. 1/2" HOSEBARB
*(4)
27
86281990
39552
1 HOSE, 1/2 ID NYLOBRD X 4
*(4)
28
86197940
40027
1 HOSEBARB, 3/8 MPT X 1/2 90D DL
*(3)
29
86275370
70447
1 SCR, 10-24 X 1/2 FHTC
*(3)
30
86279470
87165
1 WASHER, #10 SPLIT LOCK PLTD
*(3)
31
86010650
87018
1 WASHER, #10 X 9/16 OD
*(3)
32
86077300
51406
1 LEVER, VALVE
*(3)
33
86087350
730342
1 SPACER, VALVE
*(3)
34
86255910
73659
1 STANDOFF, 1/4-20 X 1.0 HEX INS
35
86001590
40049
1 HOSEBARB, 3/8 MPT X 1/2 NYLON
*(3)
36
86270930
57065
1 NUT, 1/4-20 JAM SS
37
86010660
87025
1 WASHER, 1/4 LOCK EXT STAR SS
38
86005750
57113
2 NUT, 5/16-18 HEX NYLOCK
39
86274920
70327
1 SCR, 1/4-20 X 3/8 PTHMS PL
40
86075270
20108
1 CLAMP, VALVE
41
86025960
47472
1 VALVE, SOLUTION
WAS 84167
42
86003190
27890
1 CABLE, .062 X 41 SS PUSH/PULL
86026950
84202
- VALVE ASM, 3/8 FPT BALL

INCLUDES ITEMS: 86068510-PRV NO. 40027, 86275370-PRV NO.70447, 86279470-PRV NO. 87165,
86010650-PRV NO. 87018, 86077300-PRV NO. 51406, 86087350-PRV NO. 730342,
86001590-PRV NO. 40049, 86197310-PRV NO. 141045, 86258720-PRV NO. 84075,
86257310-PRV NO. 73886
* SEE SERIAL NUMBER PAGE

SABER (SC) 86038350 03/19/08

5-26

SOLUTION GROUP - TRACTION

17
2

20

18

21

21

13

22

12

8
11

9
15
1
6

14

16

10
4

10

5-27

SABER (SC) 86038350 01/29/07

SOLUTION GROUP - TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17

PART NO.
86233150
86279880
86234780
86238430
86281920
86281990
86197940
86004460
86005750
86006760
86007000
86007970
86008250
86233410
86010540
86010670
86009700

PRV NO.
20042
27425
27772
36191
39538
39552
40027
41333
57113
70305
70632
73864
75293
81270
84141
87029
82267

QTY
3
1
1
2
1
1
1
2
4
4
2
1
1
1
1
2
1

18
19
20
21
22

86001600
86008400
86002390
86004310

40076
OPEN
78499
20063
39505

1
1
2
1

DESCRIPTION
CLAMP, 3/8 HOSE (D-SLOT)
CORD, SOLUTION COVER
COVER, SOLUTION TANK
GROMMET 1.00 ID 3/16 GRIP
HOSE, 1/2 ID NYLOBRAID X 52"
HOSE, 1/2 ID NYLOBRAID X 4
HOSEBARB, 3/8MPTX1/2 90D DL
HINGE, SCRUBBER TANK
NUT, 5/16-18 HEX NYLOCK
SCR, 5/16-18 X 3/4HHCSGR5PLTDL
SCR, 5/16-18 X 3/4 FHSCS BLKZC
STRAINER, 3/8 IN. NPT 60 MESH
TANK, SOLUTION
CLAMP, 3/4 DIA CUSHION .406DIA
VALVE, 24VDC SOL.1/2"HOSEBARB
WASHER, 5/16 FLAT SS
PLUG, 5/8" DRAIN HOSE

SERIAL NO.
FROM

NOTES:

SLEEVE .63 ID X 1.0 OD


TETHER, DRAIN PLUG
CLAMP, 1.75" WORM GEAR X .312
HOSE, 1.0 X 18.0 DRAIN

SABER (SC) 86038350 01/29/07

5-28

SQUEEGEE GROUP

3
2

5
4

8
7
6

13

10
11
12

17

15ABC

18

15B
16
14A

5-29

14AB

SABER (SC) 86038350 01/29/07

SQUEEGEE GROUP

REF
1
2
3
4
5
6
7
8
9
10
11
12
13

PART NO.
86096000
86010890
86278350
86003980
86219690
86008660
86010670
86276780
86010880
86006200
86001810
86008320
86279650

PRV NO.
89215
89059
70729
35249
48080
80605
87029
70728
89058
66161
14390
78356
87222

QTY
1
2
2
1
2
2
2
2
2
2
2
2
2

DESCRIPTION
WELDMENT, SQUEEGEE MAIN
WHEEL, BUMPER
SHOULDER BOLT, 3/8 OD X 1.0 L SS
GASKET, SQG .13 THK X 8.00 LG
KNOB, 1.50 OD X 5/16-18
COTTER, 5/16" RING
WASHER, 5/16 FLAT SS
SCR, 5/16-18 X 3/4HHCS SS
WHEEL,1.5OD X .31ID X.75W GRY
PIN, CLEVIS 5/16" X 1.50" PLTD
BRKT, SQG WHEEL
SPACER, .314 X .59 X .36 NYLON
WASHER, SEAL 5/16 X 3/4 OD
STRAP, FRONT AND REAR
STANDARD
STRAP, REAR CLOSED END HIGH
VAC
BLADE, RED REAR SOFT DURO 40
BLADE, BLU RIB FRT/REAR
URETHAN

14A

86087870

730002

14B

86088090

730226

15A

86007370

730058

15B

86007260

730003

15C
16
17
18

86007610
86007360
86276650
86271770

730227
730057
70707
57252

1
2
8

BLADE, RED REAR MEDIUM DURO 60


BLADE, RED FRONT 5 SLOT DURO 40
SCR, 5/16-18 X 1.5 BSHCS SS
NUT, 10-24 HEX NYLOCK SS

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

OPTIONAL

OPTIONAL
OPTIONAL

5-30

SQUEEGEE LIFT GROUP


1

13

6
14

16

10

12
8

5
2

12
8

10
6
15
14

3
13
1
7

11

5-31

SABER (SC) 86038350 01/29/07

SQUEEGEE LIFT GROUP

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16

PART NO.
86228840
86077220
86072410
86003180
86238330
86005750
86274910
86008650
86008670
86009560
86272710
86010630
86259400
86259410
86095990
86276760

PRV NO.
09124
14359
14367
27870
36201
57113
70325
80604
80606
82053
82060
87013
87205
87206
89214
70724

QTY
4
1
1
1
1
4
2
2
1
2
1
2
4
4
1
2

DESCRIPTION
BEARING, FLANGED.314IDX.502OD
LEVER, SQUEEGEE LIFT
BRKT, SQG PIVOT, LIFT
CABLE, .09X29, 0707,SS,LB,E-E
GRIP, .187 X 1.0 X 3.5
NUT, 5/16-18 HEX NYLOCK
SCR, 5/16-18 X 1.25HHCS GR5PLT
COTTER, 1/4 RING
COTTER, 3/8 RING
PIN, CLEVIS 1/4X5/8 PLTD
PIN, CLEVIS 3/8 X 5.25 PLTD
WASHER, 1/4 ID X 5/8 OD SS
WASHER, THRUST.51 ID X 1 ODBRO
WASHER, THRUST.51 ID X1ODX.063
WELDMENT, SQUEEGEE LINK
SCR, 5/16-18 X 1.25 BSHCS

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-32

DELUXE SQUEEGEE GROUP


27
16

28

7
24
6
30

22

14

31
18

11
21

29
8
23

10

12
7
4

26

25

9
15

15

3
2

20
5

PRIOR TO SERIAL
NUMBER 1000121941

19
1

13
17

5-33

SABER (SC) 86038350 01/29/07

DELUXE SQUEEGEE GROUP

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17

PART NO.
86001840
86001850
86001860
86001870
86001880
86069370
86005680
86005730
86005770
86005840
86271820
86249510
86249520
86006270
86006400
86231570
86274790

PRV NO.
14412
14413
14414
14415
14416
140385
57047
57111
57119
57269
57270
62869
62870
66276
67380
70105
70291

QTY
1
1
1
1
1
2
4
2
4
2
3
8
1
2
4
2
2

18
19
20
21
22
23
24
25
26
27
28
29
30
31

86006820
86276530
86276540
86007040
86007780
86088860
86008660
86009170
86009180
86009200
86010680
86010890
86011000
86081970

70385
70678
70679
70680
73576
78034
80605
81488
81489
81535
87030
89059
89197
62868

2
2
2
3
2
1
2
1
1
4
2
2
2
1

DESCRIPTION
BAND, SQUEEFEE FRONT
BAND, SQUEEGEE REAR
BAND, SQUEEGEE REAR
BLADE, SQUEEGEE FRONT
BLADE, SQUEEGEE REAR
BRKT, WHEEL MOUNT
NUT, 1/4-20 HEX NYLOCK
NUT, 3/8-16 HEX
NUT, 3/8-16 HEX NYLOCK
NUT, 3/8-16 HEX COUPLING SS
NUT, 5/16-18 CAPTIVE "J" PLTD
PLATE, SQUEEGEE FILLER
PLATE, SQG BLADE RETAINER
PIN, CLEVIS 5/16 X 1.625 LG
RIVET, 5/32 OF X 1/8 GRIP
SCR, 1/4-20 X 1.75 HHCS PLTD
SCR, 1/4-20 X 1.5 ELEVATOR

SERIAL NO.
FROM

NOTES:

SCR, 3/8-16 X 2.0 HHCS GR5 PLT


SCR, 3/8-16X3.5 CARRIAGE PLTD
SCR, 3/8-16 X 2.5 HHTB GR5 PLT
SCR, 5/16-18X1 THUMB SS TYPE P
SPRING, COMP .60D X2.0L X.045W
TUBE, 1.5 OD X 2.5 VAC INTAKE
COTTER, 5/16" RING
LATCH, SQUEEGEE STRAP
STRIKER, SQUEEGEE STRAP REAR
KNOB, 3/8-16 4 PRONG
WASHER, 3/8 ID X 3/4 OD NYLON
WHEEL, BUMPER
WHEEL, 2 OD X.31IDX.875W, GRY
PLATE, SQG RETAINER TOP

SABER (SC) 86038350 01/29/07

5-34

DELUXE SQUEEGEE GROUP


37

30
32
31
29

5
6

19

28

24

13

27
34

28
29

33

1
26
25

11
22
23
3
2
12

10
36

21

15

16

17

9
14

18
8

BEGINNING WITH SERIAL


NUMBER 1000121941
35

5-35

SABER (SC) 86038350 01/29/07

20

DELUXE SQUEEGEE GROUP

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37

PART NO.
86082500
86082510
86082520
86082530
86274130
86009910
86009200
86276870
86005630
86010680
86008390
86001850
86007780
86276990
86009170
86009180
86006400
86001860
86005810
86001880
86277000
86270830
86005840
86276980
86276920
86005650
86010670
86001350
86011020
86069870
86006270
86008660
86271820
86007040
86001870
86001840
86004890

PRV NO.
62979
62980
62981
62982
70098
82576
81535
70748
57022
87030
78493
14413
73576
70776
81488
81489
67380
14414
57245
14416
70777
57023
57269
70775
70755
57031
87029
140390
89202
140531
66276
80605
57270
70680
14415
14412
48095

QTY
1
1
1
1
2
1
2
2
4
2
1
1
2
2
1
1
4
1
2
1
2
2
2
2
2
2
2
4
4
2
2
2
3
3
1
1
2

DESCRIPTION
PLATE, SQUEEGEE TOP 32 IN
PLATE, SQG VERTICAL FILLER (F)
PLATE, SQG VERTICAL FILLER (R)
PLATE, SQUEEGEE BOTTOM 32 IN
SCR, 8-32 X 3/8 PHTC F PLTD
VIAL, LEVEL
KNOB, 3/8-16 4 PRONG ALUM
SCR, 3/8-16 X 2.50 CARRIAGE SS
NUT, 3/8-16 HEX NYLOCK THIN SS
WASHER, 3/8ID X 3/4OD NYLON
TUBE ASM, SQUEEGEE VAC
BAND, REAR SQUEEGEE
SPRING, COMP .60D X 2.0L X .045W
SCR, 3/8-16 X 3.5 CARRIAGE SS
LATCH, SQUEEGEE STRAP
STRIKER, SQUEEGEE STRAP REAR
RIVET, 5/32 OF X 1/8 GRIP
BAND, REAR SQUEEGEE
NUT, 1/4-20 HEX NYLOCK SS
BLADE, SQUEEGEE REAR LINATEX 3/16
SCR, 1/4-20 X 1.75 CARRIAGE SS
NUT, 5/16-18 HEX NYLOCK SS
NUT, 3/8-16 HEX COUPLING SS
SCR, 5/16-18 X 2 HHCS SS
SCR, 3/8-16 X 1 HHCS SS NP
NUT, 5/16-18 HEX
WASHER, 5/16 FLAT SS
BUSHING, SPANNER .435 X 1.10
WHEEL, 3 DIA CUSHION RUBBER
BRACKET, SQG WHEEL
PIN, CLEVIS 5/16 X 1.625 LG
COTTER, 5/16 RING
NUT, 5/16-18 CAPTIVE J PLTD
SCR, 5/16-18 X 1 THUMB SS TYPE P
BLADE, SQUEEGEE FRONT (3-SLOTS)
BAND, SQUEEGEE FRONT
KNOB, ALUM 3/8-16 NYLOCK NUT SS

SERIAL NO.
FROM

NOTES:

NOTE: COMPLETE SQUEEGEE ASSEMBLY IS AVAILABLE, PN 86026560, PRV NO. 47442

SABER (SC) 86038350 01/29/07

5-36

DELUXE SQUEEGEE LIFT GROUP


1

14

6
13

10

12

12
8

21
23
9

20

16
6

22
19

1
14

17
3
15

13
18
7
11

5-37

10

SABER (SC) 86038350 01/29/07

DELUXE SQUEEGEE LIFT GROUP

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23

PART NO.
86228840
86077220
86065100
86003180
86238330
86271840
86277130
86008650
86008670
86009560
86272710
86010630
86259400
86259410
86072530
86073710
86005630
86276870
86007310
86008870
86009200
86249060
86279510

PRV NO.
09124
14359
14417
27870
36201
57285
70795
80604
80606
82053
82060
87013
87205
87206
14409
14410
57022
70748
730022
80815
81535
82061
87171

QTY
4
1
1
1
1
4
4
2
1
2
1
2
4
4
1
1
1
1
1
2
1
1
1

DESCRIPTION
BEARING, FLANGED.314IDX.502OD
LEVER, SQUEEGEE LIFT
BRKT, SQG PIVOT/LIFT
CABLE, .09X29, 0707,SS,LB,E-E
GRIP, .187 X 1.0 X 3.5
NUT, 5/16-18 HEX NYLOCK THIN SS
SCR, 5/16-18 X 1.00 CARRIAGE SS
COTTER, 1/4 RING
COTTER, 3/8" RING
PIN, CLEVIS 1/4'X5/8" PLTD
PIN, CLEVIS 3/8 X 5.25 PLTD
WASHER, 1/4 ID X 5/8 OD SS
WASHER, THRUST.51 ID X 1 ODBRO
WASHER, THRUST.51 ID X1ODX.063
BRKT, CAMBER PIVOT
BRKT, SQUEEGEE MOUNT
NUT, 3/8-16 HEX NYLOCK THIN SS
SCR, 3/8-16 X 2.50 CARRIAGE SS
SPRING, COM .97 ODX1.5LX .135W
BEARING,FLANGED 3/8" ID 11/16"
KNOB, 3/8-16 4 PRONG
PIN, CLEVIS 3/8 X 4.63 PLTD
WASHER, 3/8 FLAT

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-38

VACUUM GROUP

8
2
7
3

5-39

SABER (SC) 86038350 01/29/07

VACUUM GROUP

REF
1
2
3
4
5
6
7
8

PART NO.
86240210
86002390
86236400
86237230
86004790
86005460
86135370
86135310
86081750
86278110

PRV NO.
39559
20063
34366
35087
48012
53801
14548
140686
62827
81491

QTY
1
1
1
1
1
1
1
1

DESCRIPTION
HOSE ASM, 1.5 BLK VAC X 6.0
CLAMP, 1.75" WORM GEAR X .312
FLOAT SHUT-OFF
GASKET, 5.7 VAC MOTOR
KNOB, 5/16-18 4 PRONG
VAC MOTOR ASM, 24VDC 3 STAGE
BRUSH SET, 24V 3ST VAC AMETEK
BRUSH SET, 24V/36V VAC WINDSOR
PLATE, VAC RETAINER
SET SCR, 5/16-18 X1.5 CP SS DL

SERIAL NO.
FROM

NOTES:

*(5)

SERVICE ONLY
SERVICE ONLY

* SEE SERIAL NUMBER PAGE

SABER (SC) 86038350 01/29/07

5-40

WHEELS AND FRAME GROUP - NON-TRACTION

4
5

5
12

1
2

12
8
6
13

14

5-41

SABER (SC) 86038350 01/29/07

10
11

WHEELS AND FRAME GROUP - NON-TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15

PART NO.
86072400
86002300
86233600
86075780
86270830
86081870
86273830
86006560
86274690
86278940
86010660
86010670
86011100
86066290
86230250

PRV NO.
14366
18039
27122
34368
57023
62844
70020
70083
70258
87008
87025
87029
89257
05219
09136

QTY
1
2
2
1
14
10
2
10
4
2
2
14
2
1
-

DESCRIPTION
BRKT, FRAME BOTTOM
CASTER, SWIVEL 3.50 X 4.69
COLLAR, 1.0X.625X.50 TAP'D STL
FRAME, MAIN
NUT, 5/16-18 HEX NYLCK
PLATE, TRANSAXLE SPACER
SCR, 1/4-20 X 1/2 HHCS SS DL
SCR, 5/16-18 X 1"HHCSGR5PLT DL
SCR, 5/16-18 X 1.5 HHCS GR5 PLTD
WASHER, 1/4 ID X 1-1/4 OD PLT
WASHER, 1/4 LOCK EXT STAR SS
WASHER, 5/16 FLAT SS
WHEEL, 8 X 2 X .63 ID PERFORMA
WELDMENT, AXLE
BEARING, REPLACEMENT FOR 89181

SERIAL NO.
FROM

NOTES:

SERVICE ONLY

*(6)
*(6)

WAS 89181
WAS 89217
(NOT SHOWN)

* SEE SERIAL NUMBER PAGE

SABER (SC) 86038350 01/29/07

5-42

WHEELS AND FRAME GROUP - TRACTION

4
5

5
11

1
3

11
8
7

12

10

2
9

5-43

SABER (SC) 86038350 01/29/07

WHEELS AND FRAME GROUP - TRACTION

REF
1
2
3
4
5
6
7
8
9
10
11
12

PART NO.
86072400
86230330
86002300
80675780
86270830
86005780
86081870
86006560
86274910
86008380
86216150
86135880
86241840
86010670
86011080

PRV NO.
14366
14369
18039
34368
57023
57128
62844
70083
70325
78440
140588
47372
48091
87029
89222

QTY
1
2
2
1
14
8
8
10
4
1
14
2

DESCRIPTION
BRKT, FRAME BOTTOM
BRKT, TRANSAXLE MOUNT
CASTER, SWIVEL 3.50 X 4.69
FRAME, MAIN
NUT, 5/16-18 HEX NYLCK
NUT, 5/16-24 HEX NYLOCK PLTD
PLATE, TRANSAXLE SPACER
SCR, 5/16-18 X 1"HHCSGR5PLT DL
SCR, 5/16-18 X 1.25 HHCS GR5
TRANSAXLE, 24VDC
BRUSH SET, 24V TRANSAXLE
HUB KIT, 78440 TRANSAXLE
KEY, WOODRUFF .75ID HUB
WASHER, 5/16 FLAT SS
WHEEL, 7.87 X 2 X 1.77 BLK

SERIAL NO.
FROM

NOTES:

*(7)

*(7)

NOT SHOWN
SERVICE ONLY
SERVICE ONLY
*(8)

* SEE SERIAL NUMBER PAGE

SABER (SC) 86038350 08/10/09

5-44

ONBOARD CHARGER

5-45

SABER (SC) 86038350 09/30/09

ONBOARD CHARGER

REF
1
2
3
4
5
6
7
8
9
10
11

PART NO. PRV NO. QTY


DESCRIPTION
86329590
1 CHRGR, 24V 9A, 20" LEAD ACID
86065090
140919
1 BRKT, CHARGER 20 INCH
86329650
1 LOCK PLATE, 20" SPE CHARGER
86198530
99809
0.8 FOAM TAPE, 1/8T X 3/4 1SDA
86275210
70384
1 SCR, 1/4-20 X 1/2 PHTR BLK DL
86006760
70305
3 SCR, 5/16-18 X 3/4 HHCS GR5 PLTDL
86005710
57105
1 NUT, 1/4-20 HEX W/STAR WASHER
86234390
23725
1 CORD ASM, 16/3 SJTW X 2M IEC
86010670
87029
3 WASHER, 5/16 FLAT SS
86232960
270137
1 CHARGER, CURTIS 1608FS SC20
86079380
620109
1 PLATE, CHARGER 20 INCH
* SEE SERIAL NUMBER PAGE

SABER (SC) 86038350 09/30/09

SERIAL NO.
FROM
*(9)

NOTES:

*(9)

5-46

WIRING GROUP BATTERY CABLES

1
5

10

6A
6B

3
4
2

5-47

SABER (SC) 86038350 01/29/07

WIRING GROUP - BATTERY CABLES

REF
1
2
3
4
5
6A

PART NO.
86275550
86006760
86233410
86010670
86270920
86260460

PRV NO.
70500
70305
81270
87029
57049
880261

QTY
2
1
1
1
2
1

6B
7
8
9

86260470
86002510
86002540
86264980

880268
23125
23174
14406

1
1
1
2

DESCRIPTION
SCR, 6-32 X 1.25 PPHMS
SCR, 5/16-18 X 3/4HHCSGR5PLTDL
CLAMP, 3/4 DIA CUSHION .406DIA
WASHER, 5/16 FLAT SS
NUT, 6-32 HEX NYLOCK SS
WIRE ASM, 33, 6G 1/4 RING
WIRE ASM, 26.5, 6G RING
WIRE 4X15 BCLAMPXBCLAMP
WIRE ASM 2X21 BATT W/ANDERSON
BLOCK, 10.0 X 7.0 X 3.0

10

86064650

78452

TRAY, BATTERY

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

NON-TRACTION
TRACTION

OPTIONAL

5-48

WIRING GROUP CONTROL PANEL - NON-TRACTION

5-49

SABER (SC) 86038350 03/20/08

WIRING GROUP CONTROL PANEL NON-TRACTION

REF
1
2
3

PART NO.
86238880
86268650
86266690

PRV NO.
41367
88490
880034

QTY
DESCRIPTION
1 HARNESS, MAIN
1 WIRE, 4 RED/18 76040 X 76040
1 WIRE, 6 BLK/18 76011 X 76040

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-50

WIRING GROUP CONTROL PANEL - NON-TRACTION


WITH BATTERY CHARGER

VAC
MOTOR

OPTIONAL
ACCESSORY
PUMP

3 BLK

5 RED
13A BLK

2 BLK

12A RED

86266840 - PRV NO. 880075

BRUSH

VAC

7 RED

SWITCH

9 RED

1 BLK

10 RED

11 RED

BATTERY
METER

SWITCH
1 RED

2
3

POSITIVE
TERMINAL
8 RED

30A

4 RED

BRUSH
MOTOR

HOUR METER
OPTIONAL
30A

13 BLK
2 BLK
3 BLK

VAC
MOTOR

NEGATIVE
TERMINAL

5 RED
BLK FROM CHARGER

12 RED

BLK FROM CHARGER


RED FROM CHARGER

POSITIVE
BATTERY
CABLE

NEGATIVE
BATTERY
CABLE

BATTERY
CHARGER

AC INPUT

1
7

5-51

SABER (SC) 86038350 09/30/09

WIRING GROUP CONTROL PANEL NON-TRACTION


WITH BATTERY CHARGER
REF
1
2
3
4
5
6
7

PART NO.
86238880
86268650
86266690
86268030
86268040
86268050
86268070

PRV NO.
41367
88490
880034
880456
880458
880459
880463

QTY
1
1
1
1
1
1
1

DESCRIPTION
HARNESS, MAIN
WIRE, 4 RED/18 76040 X 76040
WIRE, 6 BLK/18 76011 X 76040
WIRE, 14 RED/10 76081 X 76064
WIRE, 14 RED/14 76001 X 76029
WIRE, 14 RED/12 76064 X 76064
WIRE, 2 YLW/16 76029 X 76029

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-52

5-53

SABER (SC) 86038350 03/20/08

12 VOLTS
BATTERY

BATT CONN.

BATT CONN.

TERMINAL POST (-)

13/BLK

BLK 3

BLK 2

BLK 2

RED 11

RED 7

BATTERY METER

RED 10

VAC SWITCH

BRUSH SWITCH

BLK 1

RED 9

RED 8

12 VOLTS
BATTERY

3
TERMINAL POST (+)

RED 6

HOUR METER
OPTIONAL

RED 1

VAC CIRCUIT BREAKER

30 AMPS

BRUSH CIRCUIT BREAKER

30 AMPS

RED 5

RED 4

PM

VAC MOTOR

PM

BRUSH MOTOR

SOLENOID

OPTIONAL
ACCESSORY PUMP

OPTIONAL WIRE

STANDARD WIRE

NOTES

BLK 3

12/RED

BLK 2

WIRING GROUP SCHEMATIC NON-TRACTION

WIRING GROUP SCHEMATIC NON-TRACTION

REF
1
2
3

PART NO.
86268650
86266690
86266840

PRV NO.
88490
880034
880075

QTY
DESCRIPTION
1 WIRE, 4 RED/18 76040 X 76040
1 WIRE, 6 BLACK/18 76011 X 76040
1 WIRE, 8 RED/18 76031 X 76031

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-54

5-55

12 VOLTS
BATTERY

12 VOLTS
BATTERY

AC INPUT

NOTES

BATT CONN.

BATTERY
CHARGER

BATT CONN.

86

85

SABER (SC) 86038350 09/30/09


TERMINAL POST (-)

13/BLK

30

TERMINAL POST (+)

87

RELAY

BLK FROM CHARGER


RED FROM CHARGER

8
3

BLK 3

BLK 2

BLK 2

BATTERY METER

RED 10

VAC SWITCH

BRUSH SWITCH

HOUR METER
OPTIONAL

RED 11

BLK 1

RED 9

RED 8

RED 1

VAC CIRCUIT BREAKER

30 AMPS

BRUSH CIRCUIT BREAKER

30 AMPS

RED 5

RED 4

PM

VAC MOTOR

PM

SOLENOID

OPTIONAL
ACCESSORY PUMP

BRUSH MOTOR

BLK 3

12/RED

BLK 2

WIRING GROUP SCHEMATIC NON-TRACTION ONBOARD CHARGING

BLACK FROM CHARGER

WIRING GROUP SCHEMATIC NON-TRACTION ONBOARD CHARGING

REF
1
2
3
4
5
6
7
8

PART NO.
86268650
86266690
86266840
86268030
86268040
86268050
86251390
86268070

PRV NO.
88490
880034
880075
880456
880458
880459
67445
880463

QTY
1
1
1
1
1
1
1
1

DESCRIPTION
WIRE, 4 RED/18 76040 X 76040
WIRE, 6 BLK/18 76011 X 76040
WIRE, 8 RED/18 76031 X 76031
WIRE, 14 RED/10 76081 X 76064
WIRE, 14 RED/14 76001 X 76029
WIRE, 14 RED/ 12 76064 X 76064
RELAY, 24 VDC 40A
WIRE, 2 YLW/16 76029 X 76029

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-56

BATTERY

12 VOLTS

BATTERY

12 VOLTS
1
2

RED 17

BATT CONN

BATT CONN

3 AMPS
MAIN
CIRCUIT BREAKER

RED 15
MAIN

86003410
PRV NO. 29215
DIODE

RELAY

SABER (SC) 86038350 05/05/09

RED 27

BLK 5

BLK 21

BLK 39

RELAY

BRUSH

RED 9

RED 1

VACUUM
MOTOR

PM

RED 2

BLK 21

GRN 28

SOLUTION VALVE

RED 1

86267340
PRV NO. 880269

QUICK CONNECT

WHT 35

BLU 20

86010830 - RED PRV NO. 880022

(NOT USED)

VAC SWITCH

86267360 - PRV NO. 880271

BLK 25

BLK 6

RED 8

RED 33

RED 10

86261210
PRV NO. 29204
DIODE

RED 11

25 AMP
PROPEL
CIRCUIT BREAKER

30 AMPS
VAC
CIRCUIT BREAKER

BLK 7

RED 18
86261210
PRV NO. 29204
DIODE

30 AMPS
BRUSH
CIRCUIT BREAKER

RED 13

BATTERY METER
1
2

880270

BLK 31

BRUSH
MOTOR

PM

86260400
PRV NO. 880212

GROUND STUD

RED 14

RED 18

RED 12
RED 12

RED 34
RED 14
RED 14

RED 16

BLK 7

KEY SWITCH

REVERSE

BRUSH SWITCH

BLU 20

RED 10

BLK 25

HOUR METER

RED 27

RED 26

86261210
PRV NO. 29204

WHT 24

RED 34

BLK 22

GRN 23

WHT 35

J2

GRN 28

BLK 32

MOLEX

+ +

+ +

+ +

+ +

J3

BLU 19

MOLEX

+ +

+ +

+ +

+ +

RED 29

YEL 30

BLK 32

YEL 30

3A

4A

14A

50K ohms

SPEED CONTROL

SOLUTION
CONTROLLER

RED 34

3
1

5-57
6
7
8

2
3
4

6A
17A

WHT 24

PRV NO. 49501

13A

ADAPTER HARNESS
86004900

5.6K

17A
6A
14A
4A
13A
3A

BLK 31

PM

1 10

2 11

3 12

4 13

5 14

6 15

7 16

8 17

9 18

RED 10

TRACTION
MOTOR

PROPEL SWITCH

5A

RED 3
PROPEL SWITCH

5B

17
6
14
4
13
3

BLK 37

RED 27

BLK 5

CURTIS
CONTROLLER

M1

M2

B-

B+

WIRING GROUP SCHEMATIC TRACTION

NOTE: TERMINAL
NOT USED

BLK 4
WHT 36

BLK 6

WIRING GROUP SCHEMATIC TRACTION

REF
1
2
3
4

PART NO.
86269300
86261210
86267340
86004900

PRV NO.
88868
29204
880269
49501

QTY
1
2
1
1

DESCRIPTION
WIRE, 16 RED/18 STRIP X STRIP
DIODE ASM, 76008 X 76008
WIRE, 22 RED/18 76040 X 76075
HARNESS, ADAPTER SC20

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-58

BATTERY

12 VOLTS

BATTERY

12 VOLTS
1
2

RED 17

OPTIONAL WIRE

STANDARD WIRE

NOTES

BATT CONN

RED 17

BATT CONN

3 AMPS
MAIN
CIRCUIT BREAKER

RED 17

RED 15

86003410
PRV NO. 29215
DIODE

RELAY

MAIN

RED 16

GROUND STUD

RED 14

EMERGENCY SWITCH

BLK 7

BLK 21

BLK 5

BLK 39

RELAY

BRUSH

RED 10

RED 1

RED 9

VACUUM
MOTOR

PM

BLK FROM CHARGER

RED 2

RED 1

QUICK CONNECT

WHT 35

BLU 20

BATTERY METER
1
2

86267350
PRV NO. 880270

RED 34

86010830 - RED PRV NO. 880022

(NOT USED)

RED 33

VAC SWITCH

86267360 - PRV NO. 880271

BLK 25

BLK 6

PUMP

OPTIONAL

RED 8

RED 11

25 AMP
PROPEL
CIRCUIT BREAKER

30 AMPS
VAC
CIRCUIT BREAKER

BLK 2

RED 18
DIODE

30 AMPS
BRUSH
CIRCUIT BREAKER

RED 13

RED 18

RED 12
RED 12

RED 34
RED 14
RED 14

KEY SWITCH

GRN 28

PM
BRUSH
MOTOR

BLK 31

SOLUTION VALVE

RED 1

BLK 21

RED 2
BLK 7

BLU 20

RED 10

BLK 25

RED 26

RED 27
1

REVERSE

BRUSH SWITCH

OPTIONAL
HOUR METER

WHT 24

OPTIONAL

BLK 5

J2

+ +

+ +

+ +

GRN 28

BLK 32

MOLEX

+ +

+ +

+ +

+ +

J3

BLU 19

RED 29

YEL 30

BLK 32

SPEED
CONTROL
50K ohms

SOLUTION
CONTROLLER

RED 34

+ +

MOLEX

BLK 31

BLK 22

GRN 23

WHT 35

YEL 30

3
1

SABER (SC) 86038350 09/30/09


3A

4A

14A
6
7
8

2
3
4

6A
17A

13A
ADAPTER HARNESS

5.6K

17A
6A
14A
4A
13A
3A

5A

WHT 36

RED FROM CHARGER

11
10
1

3 12

4 13

5 14

6 15

7 16

8 17

9 18

PROPEL SWITCH

17
6
14
4
13
3

RED 10

TRACTION
MOTOR

PM

PROPEL SWITCH

5B

BLK FROM CHARGER

BATTERY
CHARGER

BLK 4

5-59
BLK 37

RED 27

CURTIS
CONTROLLER

M1

M2

B-

B+

BLK 5

AC INPUT

WIRING GROUP SCHEMATIC TRACTION AND ONBOARD CHARGING

RED 3

BLK 6

RED 27

WIRING GROUP SCHEMATIC TRACTION AND ONBOARD CHARGING

REF
1
2
3
4

PART NO.
86269300
86261210
86267340
86004900

PRV NO.
88868
29204
880269
49501

QTY
1
2
1
1

DESCRIPTION
WIRE, 16 RED/18 STRIP X STRIP
DIODE ASM, 76008 X 76008
WIRE, 22 RED/18 76040 X 76075
HARNESS, ADAPTER SC20

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-60

WIRING GROUP CONTROL PANEL - TRACTION


BRUSH
SWITCH

2
3

REVERSE
SWITCH

POT
24 WHT
22 BLK
23 GRN
19 BLU
20 BLU

PROPEL SWITCH

86238930
PRV NO. 41377

32 BLK
30 YLW
29 RED

PROPEL SWITCH

31 BLK
37 BLK
36 WHT
5 RED

24 WHT

19 BLU
34 RED
30 YEL
29 RED
35 WHT
23 GRN
22 BLK
32 BLK

ADAPTER HARNESS
86004900
PRV NO. 49501

CONTROLLER

5.6K

34 RED

BRUSH
RELAY

18 WHT

4 BLU
6 BLK
3 WHT
5 RED
13 GRN
17 BLU
14 ORG

MAIN
RELAY
12 YLW

31 BLK

86010830
RED PRV NO. 880022

86261210
PRV NO. 29204
DIODE
35 WHT
20 BLU

5-61

SABER (SC) 86038350 01/29/07

WIRING GROUP CONTROL PANEL- TRACTION

VAC
SWITCH
16 RED

8 RED

KEY
SWITCH

SOLUTION
CONTROL
BOARD

2
3

9 RED

21 BLK
86269300
PRV NO. 88868

28 GRN
27 RED

18 RED

26 RED

25 BLK
1

HOUR METER
OPTIONAL

E-SWITCH
OPTIONAL
33 RED

BATTERY
METER
1

17 RED
3

86261210
PRV NO. 29204

17 RED

25A

PROPEL

30A

30A

BRUSH

3A

VAC

MAIN
15 RED

14 RED
11 RED
12 RED

1 RED

13 RED
10 RED

86267340
PRV NO. 880269

ACCESSORY PUMP
OPTIONAL

880271
PRV NO. 880271

86267350
PRV NO. 880270

86238930
PRV NO. 41377

CONTROLLER

M1

M2

B-

B+

2 BLK

11 RED
1/2 RED

BRUSH
RELAY

MAIN
RELAY

10 RED
5 BLK
4 BLK

15 RED

3 RED

21/25 BLK
5/38 BLK

6/7/39 BLK

12/13/14 RED

GROUNDING
POST

NEGATIVE
BATTERY
CABLE

39 BLK

38 BLK

27 RED

16/18 RED

NOT USED

POSITIVE
BATTERY
CABLE

SABER (SC) 86038350 01/29/07

5-62

WIRING GROUP - MAIN HARNESS - TRACTION

2 RED

BRUSH
MOTOR
6 BLK

SOLENOID
VALVE

VAC
MOTOR

7 BLK
9 RED
28 GRN
1 RED

PROPEL
MOTOR

4 BLK
3 RED

41377

R
E
M

1 RED
2 BLK

OPTIONAL
ACCESSORY
PUMP

5-63

SABER (SC) 86038350 01/29/07

WIRING GROUP - MAIN HARNESS - TRACTION

REF
1
2
3

PART NO.
86238930
86261210
86003410

PRV NO.
41377
29204
29215

QTY
DESCRIPTION
1 HARNESS, SC20T MAIN
2 DIODE ASM, 76008 X 76008
1 DIODE ASM, 76075 X 76065

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:
NOT SHOWN
NOT SHOWN

5-64

EMERGENCY STOP OPTION

5-65

SABER (SC) 86038350 01/29/07

EMERGENCY STOP OPTION

REF
1
2

PART NO.
86007180
86269300

PRV NO.
72160
88868

QTY
DESCRIPTION
1 SWITCH, EMERGENCY STOP
1 WIRE, 16" RED/18 STRIP X STRIP

SABER (SC) 86038350 01/29/07

SERIAL NO.
FROM

NOTES:

5-66

ACCESSORY PUMP OPTION

13
19

16

6
7
2

12
11

15

18
5

14
9
20
21

17
4

5-67

SABER (SC) 86038350 01/29/07

ACCESSORY PUMP OPTION

REF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17

PART NO.
86233150
86002470
86264920
86281770
86282720
86197940
86197620
86001550
86240410
86238940
86005580
86005590
86005640
86271820
86081860
86026370
86006760

PRV NO.
20042
22072
27049
39500
82859
40027
40038
40043
40078
41378
56012
56014
57030
57270
62843
65180
70305

QTY
6
1
1
1
1
1
1
1
1
1
1
1
4
3
1
1
3

18
19
20
21

86006830
86010650
86010670
86279130

70386
87018
87029
87083

4
4
3
3

DESCRIPTION
CLAMP, 3/8 HOSE (D-SLOT)
COUPLING, 1/4 ANCHOR W/1" HEX
CABLE TIE, 7" UL/CSA
HOSE, 3/8" NYLOBRAID X 15"
HOSE, 1/2 NYLOBRAID X 20"
HOSEBARB, 3/8MPTX1/2 90D DL
HOSEBARB, 1/4MPT X 3/8 45D DL
HOSEBARB, 3/8MPT X3/8 90D
HOSEBARB, 1/2 TEE
HARNESS, PUMP
NIPPLE, 1/4 FPT QD
NIPPLE, 1/4 CLOSE
NUT, 10-32 HEX NYLOCK
NUT, 5/16-18 CAPTIVE "J" PLTD
PLATE, PUMP MOUNT
PUMP ASM, 24V ACCESSORY
SCR, 5/16-18 X 3/4HHCSGR5PLTDL

SERIAL NO.
FROM

NOTES:

NOT SHOWN

SCR, 10-32 X 1.0 PPHMS


WASHER, #10 X 9/16 OD
WASHER, 5/16 FLAT SS
WASHER, 5/16 SPLIT LOCK PLTD

SABER (SC) 86038350 01/29/07

5-68

SUGGESTED SPARE PARTS

PART NO.

PRV NO.

DESCRIPTION

86216150

140588

BRUSH SET, 24V TRANSAXLE

86135370

14548

BRUSH SET, 24V 3ST VAC AMETEK

86135310
86001910

140686
14606

BRUSH SET, 24V/36V VAC WINDSOR


BREAKER, 30A 50VDC CIRCUIT

86001920

14607

BREAKER, 25A 50VDC CIRCUIT

86001970

14695

BRUSH SET, IMPERIAL 53185/630

86002000

14717

BREAKER, 3 AMP

86002510
86002540

23125
23174

WIRE 4X15 BCLAMPXBCLAMP


WIRE ASM 2X21 BATT W/ANDERSON

86003180

27870

CABLE, .09X29, 0707,SS,LB,E-E

86232180

27877

CAP, 3 INCH MPT

86002800

270121

CABLE, .062X43 SS PUSH/PULL

86236400

34366

FLOAT SHUT-OFF

86237230
86003980

35087
35249

GASKET, 5.7 VAC MOTOR


GASKET, SQG .13 THK X 8.00 LG

86004790

48012

KNOB, 5/16-18 4 PRONG

86006360

67118

RELAY, 24VDC SOLENOID

86007220

72166

SWITCH, SPST MOMENTARY

86007140

72130

SWITCH, SPST 2-POSITION ROCKER

86007260
86007840

730003
73790

BLADE, SQUEEGEE (URETHANE)


SKIRT, SHROUD 3.25 X 58.0 L

86007970

73864

STRAINER, 3/8 IN. NPT 60 MESH

86252520

80885

SAFETY DECAL, BATTERY CAUTION

86252530

81494

SAFETY DECAL, SOLUTION WARNING

86037860

980300

MANUAL, CURTIS 1604/1608 CHRGR

* SEE SERIAL NUMBER PAGE

5-69

SABER (SC) 86038350 08/10/09

SERIAL NO.
FROM

*(5)

*(3)

NOTES:

SERIAL NUMBERS
REF.
NO.
1

MODEL: SERIAL #
SC20, SCC20, SC20T, SCC20T, SCX20T, SCXC20T: 1000097107

SC20T, SCC20T, SCX20T, SCXC20T: 1000136001

SC20, SCC20: 1000149238

SC20, SCC20: 10052190000134, 10052230000101

5
6

SC20, SCC20, SC20T, SCC20T, SCX20T, SCXC20T: 1000122411


SC20, SCC20: 100011685

SC20T, SCC20T, SCX20T, SCXC20T: 1000049753

SC20T, SCC20T, SCX20T, SCXC20T: 1000060885

SCC20: 10052230000227, SCC20T: 10052240000144, SCXC20T: 10052420000121

SABER (SC) 86038350 09/30/09

5-72

Вам также может понравиться