Академический Документы
Профессиональный Документы
Культура Документы
d. Relive the pump of its load when no actuating units are being operated
35.How is the cabin pressure of a pressurised aircraft usually controlled?
36. A wing whose tip is lower than root , would be described asa. Anhedral
b. Dihedral
c. Low fly
d. High fly
37.An aircraft in straight and level flight at constant IAS begins a banked turn,
keeping the IAS constant
a. The drag will remain constant
b. The drag will increase
c. The drag will decrease
d. Only induced drag will decrease
38.Dutch roll is
39.On an aircraft with the variable incidence trimming tail plane, the tail
plane incidence change whena. Automatically, the elevator moves
b. Control column moves back or forward
c. Both oil temperature and oil pressure will be too low or fluctuate
d. None of the above is correct
51.Reduced air density at a high altitude has a decided effect on a
carburettor resulting in a reduced engine power bya. Excessively enriching the air/fuel mixture
b. Excessively leaning the air/fuel mixture
c. Reducing fuel vaporisation
d. None of the above is correct
52.When starting a turbine enginea. A hot start is indicated if the exhaust gas temperature exceeds
specified limit
b. An excessively lean mixture is likely to cause hot start
c. Release the starter switch as soon as indication of light off occurs
d. Both (1) and (3) are correct
53.What is the function of the thrust reverser of a turbojet engine?
a. To extend the reverser flap
b. To reverse the flow of exhaust gas
c. To reverse the airflow through engine inlet
d. To reduce the velocity of the exhaust gas
54.Alternators (AC generator) that are driven by a constant speed drive unit
mechanism regulate the alternator to a constant
a. Voltage output
b. Amperage output
c. Hertz output
d. All of the above are correct
55.In most reciprocating multiengine aircraft, automatic propeller
synchronisation .............................. the actuator of thea. Throttle levers
b. Propeller governors
c. Propeller control levers
d. None of the above are correct
56.In propeller the main function of the blade cuff is
a. Improve strength to the balde
b. Improve efficiency of the propeller
68.The recommended engine oil can be mixed with other grade of oil
provideda. There is no significant variation in the viscosity of both oils
b. The flash point and fire point of the oils are same
c. As in (1) and (2) and can be used in extreme emergency requirements
only
d. None of the above is correct
69.A manifold pressure is designed to
a. Maintain constant pressure in the intake manifold
b. Indicate differential pressure between the intake manifold and
atmospheric pressure
c. Indicate absolute pressure in the intake manifold
70.When an electrical circuit is open circuiteda. Components will operate normally
b. Resistance will be low
c. Resistance will be high
d. Resistance will be zero
71.In hydraulic braking system the hydraulic fluid leak isa. Not permitted
b. Permitted but one drop per minute only
c. As in (2) and so the parking brakes should not be used
d. As in (1) and so the pilot must check the serviceability of the braking
system by visually and inspecting the brake disc assembly attached to
the main wheel
72.The purpose of fuel boost pumps or auxiliary pumps area. To provide fuel at the required pressure to the carburettor
b. As in (1) and / or to the fuel metering unit of a fuel injection system
c. As in (2) and to supply fuel if the engine driven pump fails
d. As in (3) and to purge the fuel lines of any vapour
73.In the dual axial flow or twin spool compressor system , the first stage
turbine drivesa. N1 and N2 compressor
b. N2 compressor
c. N1 compressor
74.What is used in turbine engines to aid stabilization of compressor of
airflow during low thrust engine operationa. Stator vanes and rotor vanes
b. Variable guide vanes
c. As in (2) and / or compressor bleed valves
d. Pressurization and dump valves
75.On a highly tapered wing without wing twist , the stall will commence
a. At the tip
b. At the root
c. At the mid section of the wing
76.For an aircraft in straight and level balanced flight, if the tail plane is
producing a download, the centre of pressure should bea. On the C.G
b. Aft of the C.G
c. Forward of the C.G
d. Anywhere but within the C.G
77.The purpose of a leading edge drop isa. To give amore cambered section for high speed flight
b. To increase wing camber and prevent separation of the airflow when
travel lowered
c. To increase the wing area for takeoff and landing
d. To ensure good visibility on approach
78.The boundary layer
82.What indication will be given high when a gas turbine engine anti icing
(bleed air) system Turned ONa. Fuel flow
b. EGT
c. EPR
d. All above are correct
83.Jdgqjdgasojdgasj
84.s