Академический Документы
Профессиональный Документы
Культура Документы
Purpose
To ensure conformity of the product as per ASME, EN Standards and additional Saudi
Aramco requirement.
Document Reference
ASME B16.20 Metallic Gaskets for Pipe Flanges (Ring Joint, Spiral Wound, Jacketed)
ASME B16.21 Non Metallic Flat Gaskets for Pipe Flanges
IR Form 175 060100 Saudi Aramco Inspection & Testing Requirement for Metallic GASKETS.
EN 10204 for certification requirements for metallic material
Procedure
1) Document Review:
For Metallic Gaskets:
Inspector to review the purchase order and its attachments i.e. approved
drawings and manufacturer catalogue (If available) pertaining to the
Gaskets.
MTC should mention the melt/heat or any other identification so that the
material can be traced.
All the MTC after review should be stamped Reviewed with signature and
position of the reviewer. Only reviewed MTC should be offered to Third
party inspector. This MTC should have the correct reference to the
Purchase Order and its item nos.
Inspector to review the purchase order and its attachments i.e. approved
drawings and manufacturer catalogue (If available) pertaining to the
Gaskets.
All the MTC after review should be stamped Reviewed with signature and
position of the reviewer. Only reviewed MTC should be offered to Third
party inspector. This MTC should have the correct reference to the
Purchase Order and its item nos.
4) Dimensional Inspection:
5) Marking Inspection:
For Ring Joint Gaskets: The Ring Joint Gasket shall be marked with:
o
Manufacturer Name or Identification trademark.
o
ASME B16.20 Designation
For Spiral Wound Gasket: The Spiral Wound Gasket shall be marked with the
lettering height 0.1 inch minimum. The centering ring of each spiral wound
GASKET shall be permanently marked with:
o Manufacturers name or trademark
o Flange Size (NPS)
o Pressure Class
o Winding Metal Abbreviation (Table 19, ASME B16.20)
o Centering and Inner ring metal abbreviation (Table 19, ASME B16.20)
o Flange Identification
o ASME B16.20 Designation
For Jacketed Gasket: The Jacketed Gasket shall be marked with the water proof
ink or equivalent and lettering height of 0.2 inch minimum, with the following:
o Manufacturers name or trademark
o Flange Size (NPS)
o Pressure Class
o Jacketed Material Abbreviation (Table 24, ASME B16.20)
o Filler Material abbreviation (Table 24, ASME B16.20)
o Flange Identification
o ASME B16.20 Designation
Report:
A report shall be generated in standard approved format with respect to the activities
mentioned above.
Responsibility:
QC inspectors are responsible for performing the inspection.