Академический Документы
Профессиональный Документы
Культура Документы
Features
Percussion
Rotary
The hydraulic side shift system allows the drive sampler/ rotary drill to be positioned over the borehole
when required. With this new innovation it is possible to sample and perform a standard penetration
test to a depth of 20m+ and core to approximately 50m.
Tooling Winch
Telescopic Mast
Using the telescopic winch system, the Terrier is designed to trip out drilling equipment in 4m lengths.
Features
Compact manoeuvrable crawler-mounted design ideally suited for long wheel-base transit type vans
for fast mobilisation to site and secure storage of all equipment.
DROP HAMMER
A two-piece drop hammer runs on two guide
rods and is fully guarded. Next to the drilling
controls a blow counter is installed which is
illuminated with large digits for easy reading.
An extension loom is provided when operating
the mast remotely. Attached to the mast is a 1m
measurement scale for the easy monitoring of
progress.
Rotary Specification
HYDRAULIC ROTARY DRILLING MAST AND
HEAD
Driven by a hydraulic motor fitted with a
7:1 ratio gearbox with manual gear change,
providing full controlled power and rotational
speeds in forward or reverse. Integral side inlet
water swivel and BW Rod connection fitted to
travelling carriage plate with bolts.
Dando also offer a number of motor options to
cater for specific customer requirements. See
standard specification below:
High Range:
Maximum Torque 155.6 ft-lb, 211Nm
Maximum Spindle Speed 360 r.p.m.
Low Range:
Maximum Torque 1089 ft-lb, 1477Nm
Maximum Spindle Speed 70 r.p.m.
Guide Ring: 280mm effective ID (other options
available)
MAST AND CARRIAGE ASSEMBLY
A fabricated welded steel box section
construction fitted with a pair of wheels and two
levelling jacks. Hydraulically raised and lowered
by a single double-acting ram on the main Terrier
undercarriage and attached via the pivot frame
assembly.
Length= 2750mm
Height= 1962mm (1.6m stroke)
FEED AND HOIST SYSTEM
Provided by a single double-acting ram
transmitting adjustable hydraulic load to the
rotary head.
1.6m stroke to accommodate 1.0m effective
length drill rods.
Extendable option available to accommodate
1.5m effective length drill rods.
Feed Force: 1000kgf
Pullback: 7000kgf