Академический Документы
Профессиональный Документы
Культура Документы
EMERGENCY TELEPHONES:
SUPPLIER:
TELEPHONE:
2. COMPOSITION/INFORMATION ON INGREDIENTS:
INGREDIENT NAME:
ASPHALT FUMES
ALKYL ARYL SULPHONIC ACID
CALCIUM HYDROXIDE
HYDROGEN SULPHIDE
DIATOMACEOUS EARTH
CAS No.:
8052-42-4
1305-62-0
7783-06-4
68855-54-9
CONTENT
60-100 wt%
5-10 wt%
20-40 wt%
0-0.1 wt%
1-5 wt%
HEALTH:
NC
Xn
NC
T+, N
NC
RISK:
22, 36/37/38
26, 50
3. HAZARDS IDENTIFICATION:
Irritating to respiratory system and skin. Risk of serious damage to eyes.
Move the exposed person to fresh air at once. Get medical attention if any discomfort continues.
If breathing stops, provide artificial respiration. For breathing difficulties oxygen may be necessary. Keep the affected
person warm and at rest. Get prompt medical attention.
INGESTION:
DO NOT INDUCE VOMITING! NEVER MAKE AN UNCONSCIOUS PERSON VOMIT OR DRINK FLUIDS!
Immediately rinse mouth and provide fresh air. Contact physician if large quantity has been consumed or if adverse
symptoms develop.
SKIN:
Wash the skin immediately with soap and water. Get medical attention if irritation persists after washing. Remove
contaminated clothing and launder before re-use.
EYES:
Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes with plenty of water while
lifting the eye lids. Continue to rinse for at least 15 minutes. Get medical attention if any discomfort continues.
1/4
CAS No.:
8052-42-4
1305-62-0
7783-06-4
68855-54-9
STD:
OES.
OES.
OES.
OES.
LT EXP. 8 HRS:
5 mg/m3
5 mg/m3
10 ppm
1.2 mg/m3
ST EXP. 15 MIN:
10 mg/m3
No std.
15 ppm
INGREDIENT COMMENTS:
OES = Occupational Exposure Standard. The OES for Calcium Carbonate refers to Total Inhalable Dust.
PROTECTIVE EQUIPMENT:
VENTILATION:
General\Local exhaust ventilation to keep airborne levels below the designated exposure limits.
RESPIRATORS: Exposure should be avoided\controlled by ventilation or extraction if exposure limits are likely to be exceeded. Wear
suitable dust mask.
2/4
PROTECTIVE GLOVES:
Use protective gloves made of: Neoprene. Butyl rubber.
EYE PROTECTION:
Wear safety glasses or goggles at all times.
OTHER PROTECTION:
Wear chemical resistant rubber boots and apron.
HYGIENIC WORK PRACTICES:
DO NOT SMOKE IN WORK AREA! Wash at the end of each work shift and before eating, smoking and using the
toilet. Promptly remove any clothing that becomes contaminated. Wash promptly if skin becomes contaminated. No
eating or drinking while working with this material.
Solid.
Grey.
Hydrocarbon.
Slightly soluble in water.
1.04
TEMPERATURE (C):
Normally stable.
CONDITIONS TO AVOID:
Avoid dust close to ignition sources. Avoid heat, flames and other sources of ignition. Avoid contact with acids and
oxidising substances.
HAZARDOUS POLYMERIZATION:
Will not polymerize.
HAZARDOUS DECOMP. PRODUCTS:
Fire creates: Toxic gases/vapours/fumes of: Carbon monoxide (CO). Carbon dioxide (CO2).
INGESTION:
SKIN:
Causes irritation. Prolonged or repeated contact may lead to skin irritation and dermatitis or aggravate an existing
condition.
EYES:
3/4
RISK PHRASES:
SAFETY PHRASES:
S-26 In case of contact with eyes, rinse immediately with plenty of water and seek
medical advice.
S-39 Wear eye/face protection.
S-24/25 Avoid contact with skin and eyes.
EU DIRECTIVES:
REVISION DATE:
19 February 1998
1 / All versions.
DISCLAIMER:
THIS INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR SUCH MATERIAL
USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY PROCESS. SUCH INFORMATION IS, TO THE REST OF THE
COMPANY'S KNOWLEDGE AND BELIEF, ACCURATE AND RELIABLE AS OF THE DATE INDICATED. HOWEVER, NO WARRANTY,
GUARANTEE OR REPRESENTATION IS MADE AS TO ITS ACCURACY, RELIABILITY OR COMPLETENESS. IT IS THE USER'S
RESPONSIBILITY TO SATISFY HIMSELF AS TO THE SUITABILITY OF SUCH INFORMATION FOR HIS OWN PARTICULAR USE.
4/4