Академический Документы
Профессиональный Документы
Культура Документы
CMS AVAILABLE
None
FAULTS AVAILABLE
None
3-203
DC Fundamentals
UNIT TEST
Depending on configurator settings, these questions may be randomized onscreen.
Location: Unit Test Question page: sut1, Question ID: ut1
To connect an ammeter in a circuit,
a. open the circuit at one point and insert the ammeter to complete the circuit.
b. attach the test leads across the component to be measured.
c. remove the power from the circuit.
d. attach the test leads across the voltage source.
Location: Unit Test Question page: sut2, Question ID: ut2
A milliammeter shunt
a. decreases the range.
b. is connected in series with the meter.
c. increases the range.
d. converts the meter to a voltmeter.
Location: Unit Test Question page: sut3, Question ID: ut3
A 0-1 mA meter with an internal resistance of 1000 is converted to a 0-10 mA meter. What is
the value of shunt resistance needed for full-scale deflection at 10 mA?
a. 144.4
b. 111.1
c. 0.144
d. 0.111
Location: Unit Test Question page: sut4, Question ID: ut4
An ohmmeter is connected in
a. series with the component being measured.
b. parallel with the voltage source.
c. series/parallel to a circuit.
d. parallel with the component being measured.
Location: Unit Test Question page: sut5, Question ID: ut5
What is the current flowing in an ohmmeter when it indicates infinite resistance?
a. minimum
b. maximum
c. halfway between minimum and maximum
d. None of the above.
3-204
DC Fundamentals
3-205