Академический Документы
Профессиональный Документы
Культура Документы
Mode
Encapsulation
Status
Native vlan
Fa0/8
on
802.1q
other
To change it use the following command: switchport trunk native vlan <vlan number>
(config-if)#switchport trunk native vlan 2
(config-if)#do show interface f0/8 trunk
Port
Mode
Encapsulation
Status
Native vlan
Fa0/8
on
802.1q
other
Ports
- -
1 default active
Fa0/8, Gi0/1
I am having two switches connected by access port but with two different vlan at both end. On
both ends I got following Native VLAN mismatch discovered errors.
SW1# sh log
Aug
Interface: GigabitEthernet1/39,
Holdtime : 151 sec
Version :
Cisco
IOS
Software,
ISR
Software
(X86_64_LINUX_IOSD-UNIVERSALK9-M),
Version
description MS-Network-MGMT
switchport access vlan 2
spanning-tree portfast
SW2#show cdp nei det
Interface: GigabitEthernet0/1/0,
In circumstances like this, where you are sure the mismatch is not a real problem, you may
consider to disable cdp for those interfaces to shut up those noise information.