Академический Документы
Профессиональный Документы
Культура Документы
Igniter, Class 2
An igniter applied to ignite the fuel input
Igniter, Class 1 through the burner under prescribed light-
An igniter applied to ignite the fuel input conditions. The range of capacity of such igniters
through the burner and to support ignition un- generally is 4 percent to 10 percent of full load
der any burner light- conditions. burner fuel input.
Its location and capacity are such that it provides Igniter, Class 3
gnition energy (generally in excess of
10 percent of fuel load burner input) at its asso- A small igniter applied particularly to gas and oil
ciated burner to raise any credible combination burners to ignite the fuel input to the burner un-
of burner inputs of both fuel and air above the der prescribed light- conditions. The capacity
minimum ignition temperature. Class 1 igniters of such igniters generally does not exceed 4 per-
also shall be permitted to operate as Class 2 or cent of the full load burner fuel input.
Class 3 igniters. Igniter, Class 3 Special
A special Class 3 high energy electrical igniter ca-
pable of directly igniting the main burner fuel.
Source: NFPA 85
300 kW Tube
Flame Length
2 in
(50 mm)
max. 23.75 in
max. 600 mm
Ignition and warm-up of boilers according
to American standard 14.25 - 197 in
Igniter Tube Length L
(360 - 5000 mm)
Gas Inlet 1/2, left or right
Ignition 5 kV
-22F up to +140F
Ambient Temperature
(-30C up to +60C)
Protection IP 54
Models
.43 in
n
(11 mm) 5i )
3.20 mm
(50 mm)
(8 m)
2 in
n
4 i 00 m
(44 mm)
(1
1.75 in
.35 in
13 in (9 mm)
(330 mm) 9.5 - 197 in
(240 - 5000 mm)
18
1355 Mendota Heights Rd Suite 200, Mendota Heights, MN 55120