Академический Документы
Профессиональный Документы
Культура Документы
Range 1.5 TR to 6 TR
( 5 kW to 21 kW )
www.skm.ae
Sharjah Economic Excellence
facebook.com/skmuae youtube.com/marketingskm Award winner
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Contents
Introduction..........................................2 Recommended Line Sizes................19
Legend................................................2 Typical Refrigeration Piping...............20 Introduction
Nomenclature......................................3 Typical Wiring Diagram.....................22
Features & Specification............... 4-10 Dimensional Data..............................26
Combination Ratings.........................11 Outdoor Unit Clearance The Ducted Mini Split system from SKM
Electrical Data...................................13 and Spacing......................................29
Options..............................................16 consists of RXV (a high efficiency- TOP discharge
Guide Specification...........................31
Fan Performance...............................17 Air Cooled Condensing Unit); and RXH-DC (a high
efficiency-SIDE Discharge Air cooled Condensing
Unit) matching with DCYP (a low noise, ceiling
suspended indoor fan coil unit).
AFR ...... Air Flow Rate LAWB ... Leaving Air Wet Bulb
them ideally suited for a very small foot print for
cfm ....... Cubic feet per minute lbs ......... Pounds weight (British units) space saving and a pleasant exterior appearance.
dB ........ Decibels l/s .......... Liters per second
EADB .... Entering Air Dry Bulb Mbh ...... 1000 Btuh
EAWB .... Entering Air Wet Bulb OD ........ Outside Diameter
ET ......... Evaporating Temperature SKM Ducted Mini Split units are suitable to
Ph ......... Phase
Hz ........ Hertz Pa ......... Pascals operate in a wide range of ambient temperature.
kW ........ Kilowatts SC ........ Sensible Capacity
kg ......... Kilograms TC ......... Total Capacity
kPa ...... Kilo Pascals TR ........ Tons of refrigeration = 12 MBH SKM Ducted Mini Split units are internally wired
LADB .... Leaving Air Dry Bulb V ........... Volts
and all that required to be done on site is ducting,
refrigerant piping, power supply and suitable room
thermostat installation and field wiring, which
reduces the installation work and consequently
keeps to a minimum cost.
Nomenclature
Outdoor (Top Discharge Air Cooled Condensing Unit)
R X V - 020- Y
S1: 220-240V/1Ph/50Hz
Remote Air Cooled Condenser Y: 380-415V/3Ph/50Hz
Direct Expansion
R X V - 021- R
S2: 220V/1Ph/60Hz
Remote Air Cooled Condenser R: 380V/3Ph/60Hz
T: 220-230V/3Ph/60Hz
Direct Expansion
R X H - 020 - 5 D C
Remote Air Cooled Condenser
Direct Expansion C = Cooling only
Horizontal Discharge
Power Supply 5 : 50 Hz
Nominal Capacity in MBh
Frequency 6 : 60 Hz
Indoor Unit
FCU - DCY P - 12 / 4 / X G
G=Galvanised Finish
Fan Coil Unit F=Painted FInish
3
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Design - Outdoor condensing units are ideal for rooftop or ground installation. Units have a pleasant exterior appearance
and have a very small footprint for space saving installation.
High efficiency Coils - 3/8 OD Hi-x tubes; mechanically bonded to hi-efficiency aluminium fins to match for a maximum
efficiency.
Hermetic Compressor - High efficiency hermetically sealed compressor located on engineered mounts for safe, quiet
and vibration free operation.Compresssors are selected for reliability and power efficiency.
Cabinet Construction - Heavy gauge zinc clad steel, latest technology electrostatic powder baked finish to ensure a
long lasting, durable cabinet.
Brass Service Valves Factory installed service valve with sweat connections to provide quick and accurate installation
for start-up and servicing.
Ease of Service and Installation Designed to make servicing easier for the contractor, access panels are provided
for all controls and the compressor from the side of the unit.
Compressor Short Cycling Protection To protect the compressor against rapid short cycling.
High and Low Pressure Protection - To protect the compressor against high discharge pressure and low suction
pressure, and to guarantee safe operation of compressor.
Liquid Line Filter Drier - Filter drier is factory supplied (Field Installed) for all sizes.
4
SKM Air Cooled Condensing Units
SKM Ducted Mini Split
RXV/RXH-D+DCYP - R-22Systems
SPECIFICATION (RXV - VERTICAL DISCHARGE CONDENSING UNITS) - 50Hz
Model RXV 020 025 030 040 045 050 060 070
(1) MBh 18.5 23.7 28.7 32.5 41.0 50.9 59.9 61.3
Cooling Capacity
kW 5.4 6.9 8.4 9.5 12.0 14.9 17.6 18.0
MBh 16.6 21.4 26.1 29.3 37.8 47.4 55.2 56.7
Cooling Capacity (2)
kW 4.9 6.3 7.6 8.6 11.1 13.9 16.2 16.6
Power Supply V / Ph / Hz 220-240/1/50 380-415/3/50
Type - Reciprocating Scroll
Compressor
Qty. - 1 1 1 1 1 1 1 1
Type Waffle Louver Fins and Inner Grooved tubes 3/8"OD
Coil ft 8 12 16 16 16 16 16 16
Face Area
Condenser
(1) MBh 20.3 23.3 29.6 35.2 48.4 56.3 66.6 68.5
Cooling Capacity
kW 5.9 6.8 8.7 10.3 14.2 16.5 19.5 20.1
MBh 18.3 20.8 26.9 31.7 44.7 52.6 62.0 63.8
Cooling Capacity (2)
kW 5.4 6.1 7.9 9.3 13.1 15.4 18.2 18.7
Power Supply V / Ph / Hz 220/1/60Hz 380/3/60Hz / 220/3/60Hz
Type - Reciprocating Scroll
Compressor
Qty. - 1 1 1 1 1 1 1 1
Type Waffle Louver Fins and Inner Grooved tubes 3/8"OD
Coil ft 8 12 16 16 16 16 16 16
Face Area
m 0.74 1.11 1.49 1.49 1.49 1.49 1.49 1.49
Condenser
5
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Design - Outdoor condensing units with side discharge air delivery are ideal for rooftop or ground installation and ledge
installation. This unit has a pleasant exterior aesthetic design and has a very small footprint for space saving installation.
High Efficiency Coils Inner grooved copper tubes with mechanically bonded to aluminium corrugated fins to attain
maximum efficiency.
Compressor Uses high efficiency rotary or scroll hermetic compressor located on engineered mounts for safe, quite and
vibration free operation.
Cabinet Construction- Heavy gauge zinc clad steel, latest technology electrostatic powder baked finish to ensure a
long lasting, durable cabinet.
Brass Service Valves Factory installed service valve with sweat connections to provide quick and accurate installation
for start-up and servicing.
High efficiency fan motor permanently lubricated fan motor and it is precisely matched to plastic propeller type
blades which provides a maximum efficiency.
Ease of service and installation designed to make servicing easier for the contractor; access panel are also
provided for all controls from the side of the unit.
Compressor Short Cycling Protection To protect the compressor against rapid short cycling.
High and Low Pressure Protection To protect the compressor against high discharge pressure and low suction
pressure, and to guarantee safe operation of compressor.
Liquid Line Filter Drier size 60 mbh is with standard filter drier. (factory installed)
size 20 to 50 mbh are optional. (field installed)
6
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
SPECIFICATION (RXH - SIDE DISCHARGE CONDENSING UNITS) - 50Hz
Model RXH 020 - 5DC 025 - 5DC 030 - 5DC 040 - 5DC 045 - 5DC 050 - 5DC 060 - 5DC
MBh 18.0 24.3 30.4 36.5 42.8 49.5 58.6
Nominal Cooling Capacity
kW 5.3 7.1 8.9 10.7 12.5 14.5 17.2
Power Supply V / Ph / Hz 220-240/1/50 380-415/3/50
Type Rotary Scroll
Compressor
Qty. 1 1 1 1 1 1 1
Coil Type Hydrophilic aluminium Corrugated Fin and Innergroved Copper Tube
Type Propeller Direct Drive
Qty 1 1 1 1 1 2 2
Condenser
Fan
cfm 1766 1766 2510 2510 3414 3902 3902
Air Flow
l/s 833 833 1185 1185 1611 1841 1841
Type TEAO (Totally Enclosed Air Over) Motor
Motor Size Watts 55 53 75 75 190 65 65
Qty 1 1 1 1 1 2 2
Type R-22
Refrigerant Operating Charge
kg 1.6 2.1 2.7 3.0 3.5 3.9 4.4
Unit Approximate Weight kg 42 49 62 84 97 99 103
Width 33.1 33.1 35.2 35.2 39.0 35.4 35.4
Dimensions (inches) Depth 12.8 12.8 12.3 12.3 13.9 13.4 13.4
Height 27.4 27.4 33.9 33.9 38.0 46 46
Liquid 1/4 3/8 3/8 3/8 3/8 3/8 3/8
Pack valves Connections (inches)
Suction 1/2 5/8 5/8 3/4 3/4 3/4 3/4
Table 3
SPECIFICATION (RXH - SIDE DISCHARGE CONDENSING UNITS) - 60Hz
Note:
Model RXH 020 - 6DC 025 - 6DC 030 - 6DC 040 - 6DC 045 - 6DC 050 - 6DC 060 - 6DC
Nominal cooling capacity is based on 80/67F (27/19.5C) dry bulb/wet bulb evaporator entering air temperature and 95F (35C) conden
MBh 19.7 23.5 31.7 35.2 47.4 48.6 57.0
Nominal Cooling Capacity
kW 5.8 6.9 9.3 10.3 13.9 14.2 16.7
Power Supply V / Ph / Hz 220/1/60
Type Rotary Scroll
Compressor
Qty. 1 1 1 1 1 1 1
Coil Type Hydrophilic aluminium Corrugated Fin and Innergroved Copper Tube
Type Propeller Direct Drive
Qty 1 1 1 1 1 2 2
Fan
Condenser
Notes:
Note:
Nominalcooling
Nominal coolingcapacity
capacityisisbased
based on
on 80/67F
80/67F (27/19.5C) dry bulb/wet
bulb/wetbulb
bulbevaporator
evaporatorentering
enteringairairtemperature
temperature and
and 95F(35C)
95F (35C) conde
condenser entering air temperature.
7
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Design Features
Heavy gauge galvanized casing and fan housing. Hot dip is standard.
Evaporator coils equipped with plain tubes and aluminium fins which give high capacity sensible and latent cooling capabilities.
8
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
SPECIFICATION (INDOOR UNIT DCYP MATCHED WITH RXV) - 50Hz
Indoor Unit DCYP 06 08 10 12 15 18 21 21
Matched Outdoor Unit RXV 020 025 030 040 045 050 060 070
(1)
Mbh 18.5 23.7 28.7 32.5 41.0 50.9 59.9 61.3
Cooling Capacity
kW 5.4 6.9 8.4 9.5 12.0 14.9 17.6 18.0
(2)
Mbh 16.6 21.4 26.1 29.3 37.8 47.4 55.2 56.7
Cooling Capacity
kW 4.9 6.3 7.6 8.6 11.1 13.9 16.2 16.6
cfm 686 785 1061 1331 1536 1914 2200 2200
Nominal Air Flow Rate
l/s 324 370 501 628 725 903 1038 1038
Type Copper Tubes mechanically bonded to Hi-effeciency wavy corrugated Aluminium Fins
No. Of Row / FPI # 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12
inch 12 12 16 12 12 16 16 16
Height
mm 305 305 406 305 305 406 406 406
Coil
inch 20 24 24 36 42 42 48 48
Length
mm 508 610 610 914 1067 1067 1219 1219
ft2 1.67 2.00 2.67 3.00 3.50 4.67 5.33 5.33
Face Area 2
m 0.15 0.19 0.25 0.28 0.33 0.43 0.50 0.50
Metering Device Type Orifice Expansion valve
Type Double Inlet Double Width Centrifugal Forward Curve Direct Drive
Fan Code 7-7 7-7 9-7 7-7 7-7 9-7 9-7 9-7
Quantity # 1 1 1 2 2 2 2 2
Type 220-240V/1Ph/50-60Hz,3 Speed Electric Motor with Permanent Split Capacitor
Motor Size Watts 150 150 150 150 150 150 150 150
Quantity # 1 1 1 2 2 2 2 2
inch 3/8 3/8 3/8 3/8 1/2 1/2 1/2 1/2
Liquid
mm 9.5 9.5 9.5 9.5 12.7 12.7 12.7 12.7
Connection Sizes
inch 5/8 5/8 5/8 5/8 7/8 1 1/8 1 1/8 1 1/8
Suction
mm 15.8 15.8 15.8 15.8 22.2 28.5 28.5 28.5
lbs. 60 67 82 87 109 134 141 141
Unit Approximate Weight
Kg. 27.3 30.5 37.3 39.5 49.5 60.9 64.1 64.1
Table 5
SPECIFICATION (INDOOR UNIT DCYP MATCHED WITH RXV) - 60Hz
Indoor Unit DCYP 06 08 10 12 15 18 21 21
Matched Outdoor Unit RXV 021 026 031 041 046 051 061 071
(1) MBh 20.3 23.3 29.6 35.2 48.4 56.3 66.6 68.5
Cooling Capacity
kW 5.9 6.8 8.7 10.3 14.2 16.5 19.5 20.1
MBh 18.3 20.8 26.9 31.7 44.7 52.6 62.0 63.8
Cooling Capacity (2)
kW 5.4 6.1 7.9 9.3 13.1 15.4 18.2 18.7
cfm 583 735 984 1147 1450 1804 2190 2190
Nominal Air Flow Rate
l/s 275 347 464 541 684 851 1034 1034
Type Copper Tubes mechanically bonded to Hi-effeciency wavy corrugated Aluminium Fins
No. Of Row / FPI # 4 / 12 3 / 12 3 / 12 3 / 12 4 / 12 3 / 12 3 / 12 3 / 12
inch 12 12 16 12 12 16 16 16
Height
mm 305 305 406 305 305 406 406 406
Coil
inch 20 24 24 36 42 42 48 48
Length
mm 508 610 610 914 1067 1067 1219 1219
ft2 1.67 2.00 2.67 3.00 3.50 4.67 5.33 5.33
Face Area
m2 0.15 0.19 0.25 0.28 0.33 0.43 0.50 0.50
Metering Device Type Orifice Expansion valve
Type Double Inlet Double Width Centrifugal Forward Curve Direct Drive
Fan Code 7-7 7-7 9-7 7-7 7-7 9-7 9-7 9-7
Quantity # 1 1 1 2 2 2 2 2
Type 220-240V/1Ph/50-60Hz,3 Speed Electric Motor with Permanent Split Capacitor
Motor Size Watts 150 150 150 150 150 150 150 150
Quantity # 1 1 1 2 2 2 2 2
inch 3/8 3/8 3/8 3/8 1/2 1/2 1/2 1/2
Liquid
mm 9.5 9.5 9.5 9.5 12.7 12.7 12.7 12.7
Connection Sizes
inch 5/8 5/8 5/8 5/8 7/8 1 1/8 1 1/8 1 1/8
Suction
mm 15.8 15.8 15.8 15.8 22.2 28.5 28.5 28.5
lbs. 63 67 82 87 114 134 141 141
Unit Approximate Weight
Kg. 28.6 30.5 37.3 39.5 51.8 60.9 64.1 64.1
Table 6
Notes:
(1). Capacity ratings are based on AHRI Standard 210/240. Evaporator entering air conditions of 80/67F (27/19.5C)
dry bulb/wet bulb and condenser entering air temperature of 95F (35C) dry bulb.
(2). Evaporator entering air conditions of 80/67F (27/19.5C) dry bulb/wet bulb and condenser entering air temperature
of 115F (46C) dry bulb.
9
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
SPECIFICATION (INDOOR UNIT DCYP MATCHED WITH RXH-DC) - 50Hz
Indoor Unit DCYP 06 08 10 12 15 18 21
Matched Outdoor Unit RXH 020-5DC 025-5DC 030-5DC 040-5DC 045-5DC 050-5DC 060-5DC
MBh 18.0 24.3 30.4 36.5 42.8 49.5 58.6
Nominal Cooling Capacity
kW 5.3 7.1 8.9 10.7 12.5 14.5 17.2
cfm 686 785 1061 1331 1536 1914 2200
Nominal Air Flow Rate
l/s 324 370 501 628 725 903 1038
Type Copper Tubes mechanically bonded to Hi-effeciency wavy corrugated Aluminium Fins
No. Of Row / FPI # 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12 3 / 12
inch 12 12 16 12 12 16 16
Height
mm 305 305 406 305 305 406 406
Coil
inch 20 24 24 36 42 42 48
Length
mm 508 610 610 914 1067 1067 1219
ft2 1.67 2.00 2.67 3.00 3.50 4.67 5.33
Face Area 2
m 0.15 0.19 0.25 0.28 0.33 0.43 0.50
Metering Device Type Orifice
Type Double Inlet Double Width Centrifugal Forward Curve Direct Drive
Fan Code 7-7 7-7 9-7 7-7 7-7 9-7 9-7
Quantity # 1 1 1 2 2 2 2
Type 220-240V/1Ph/50-60Hz,3 Speed Electric Motor with Permanent Split Capacitor
Motor Size Watts 150 150 150 150 150 150 150
Quantity # 1 1 1 2 2 2 2
inch 3/8 3/8 3/8 3/8 1/2 1/2 1/2
Liquid
mm 9.5 9.5 9.5 9.5 12.7 12.7 12.7
Connection Sizes
inch 5/8 5/8 5/8 5/8 7/8 1 1/8 1 1/8
Suction
mm 15.8 15.8 15.8 15.8 22.2 28.5 28.5
lbs. 60 67 82 87 109 134 141
Unit Approximate Weight
Kg. 27.3 30.5 37.3 39.5 49.5 60.9 64.1
Table 7
SPECIFICATION (INDOOR UNIT DCYP MATCHED WITH RXH-DC) - 60Hz
Indoor Unit DCYP 06 08 10 12 15 18 21
Matched Outdoor Unit RXH 020-6DC 025-6DC 030-6DC 040-6DC 045-6DC 050-6DC 060-6DC
MBh 19.7 23.5 31.7 35.2 47.4 48.6 57.0
Nominal Cooling Capacity
kW 5.8 6.9 9.3 10.3 13.9 14.2 16.7
cfm 583 735 984 1147 1450 1804 2190
Nominal Air Flow Rate
l/s 275 347 464 541 684 851 1034
Type Copper Tubes mechanically bonded to Hi-effeciency wavy corrugated Aluminium Fins
No. Of Row / FPI # 4 / 12 3 / 12 3 / 12 3 / 12 4 / 12 3 / 12 3 / 12
inch 12 12 16 12 12 16 16
Height
mm 305 305 406 305 305 406 406
Coil
inch 20 24 24 36 42 42 48
Length
mm 508 610 610 914 1067 1067 1219
ft2 1.67 2.00 2.67 3.00 3.50 4.67 5.33
Face Area
m2 0.15 0.19 0.25 0.28 0.33 0.43 0.50
Metering Device Type Orifice
Type Double Inlet Double Width Centrifugal Forward Curve Direct Drive
Fan Code 7-7 7-7 9-7 7-7 7-7 9-7 9-7
Quantity # 1 1 1 2 2 2 2
Type 220-240V/1Ph/50-60Hz,3 Speed Electric Motor with Permanent Split Capacitor
Motor Size Watts 150 150 150 150 150 150 150
Quantity # 1 1 1 2 2 2 2
inch 3/8 3/8 3/8 3/8 1/2 1/2 1/2
Liquid
mm 9.5 9.5 9.5 9.5 12.7 12.7 12.7
Connection Sizes
inch 5/8 5/8 5/8 5/8 7/8 1 1/8 1 1/8
Suction
mm 15.8 15.8 15.8 15.8 22.2 28.5 28.5
lbs. 63 67 82 87 114 134 141
Unit Approximate Weight
Kg. 28.6 30.5 37.3 39.5 51.8 60.9 64.1
Notes: Table 8
Nominal cooling capacities are based on the following conditions: Evaporator entering air of 80/67F (27/19.5C) dry
bulb/wet bulb and condenser entering air temperature of 95F (35C).
10
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
Capacity Ratings
Capacity Ratings 50Hz
50Hz - Medium - Medium Speed
Speed
Air
Air on
on coil
coil Temperature
Temperature DB/WB-80/67F
DB/WB-80/67F (26.6/19.4C)
(26.6/19.4C) Air
Air on
on coil
coil Temperature
Temperature DB/WB-76/63F
DB/WB-76/63F (24.4/17.2C)
(24.4/17.2C)
Outdoor
Outdoor Indoor
Indoor Indoor
Indoor Unit
Unit ESP
ESP Ambient(Condenser
Ambient(Condenser Entering
Entering Air)Temperature
Air)Temperature Ambient(Condenser
Ambient(Condenser Entering
Entering Air)Temperature
Air)Temperature
Unit
Unit Unit
Unit Air
Air Flow
Flow Rate
Rate
95F
95F (35C)
(35C) 105F
105F (41C)
(41C) 115F
115F (46C)
(46C) 120F
120F (49C)
(49C) 95F
95F (35C)
(35C) 105F
105F (41C)
(41C) 115F
115F (46C)
(46C) 120F
120F (49C)
(49C)
TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI* TC
TC SC
SC PI*
PI*
RXV
RXV DCYP
DCYP CFM
CFM in.wg
in.wg (Pa)
(Pa)
MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW MBh
MBh MBh
MBh kW kW
020
020 06/30
06/30 501
501 0.2
0.2 (50)
(50) 17.3
17.3 11.9
11.9 1.8
1.8 16.5
16.5 11.6
11.6 1.9
1.9 15.6
15.6 11.2
11.2 2.0
2.0 15.2
15.2 11.1
11.1 2.0
2.0 16.0
16.0 11.9
11.9 1.7
1.7 15.3
15.3 11.6
11.6 1.8
1.8 14.5
14.5 11.3
11.3 1.9
1.9 14.0
14.0 11.1
11.1 1.9
1.9
025
025 08/40
08/40 587
587 0.2
0.2 (50)
(50) 23.7
23.7 15.9
15.9 2.5
2.5 22.5
22.5 15.4
15.4 2.6
2.6 21.3
21.3 14.9
14.9 2.8
2.8 20.7
20.7 14.7
14.7 2.9
2.9 22.1
22.1 16.0
16.0 2.4
2.4 21.0
21.0 15.5
15.5 2.5
2.5 19.8
19.8 15.0
15.0 2.7
2.7 19.2
19.2 14.8
14.8 2.8
2.8
030
030 10/30
10/30 730
730 0.2
0.2 (50)
(50) 26.6
26.6 17.9
17.9 2.6
2.6 25.4
25.4 17.5
17.5 2.8
2.8 24.1
24.1 17.0
17.0 3.0
3.0 23.5
23.5 16.8
16.8 3.1
3.1 24.8
24.8 18.1
18.1 2.5
2.5 23.6
23.6 17.6
17.6 2.7
2.7 22.4
22.4 17.1
17.1 2.9
2.9 21.8
21.8 16.9
16.9 3.0
3.0
040
040 10/40
10/40 728
728 0.2
0.2 (50)
(50) 29.6
29.6 19.8
19.8 2.4
2.4 28.3
28.3 19.3
19.3 2.6
2.6 26.9
26.9 18.7
18.7 2.8
2.8 26.2
26.2 18.5
18.5 2.9
2.9 27.6
27.6 20.0
20.0 2.4
2.4 26.3
26.3 19.4
19.4 2.5
2.5 24.9
24.9 18.9
18.9 2.7
2.7 24.2
24.2 18.6
18.6 2.8
2.8
040
040 12/30
12/30 990
990 0.2
0.2 (50)
(50) 30.8
30.8 22.0
22.0 2.5
2.5 29.3
29.3 21.5
21.5 2.7
2.7 27.8
27.8 20.9
20.9 2.9
2.9 27.1
27.1 20.6
20.6 3.0
3.0 28.6
28.6 22.2
22.2 2.4
2.4 27.2
27.2 21.6
21.6 2.6
2.6 25.8
25.8 21.0
21.0 2.8
2.8 25.1
25.1 20.7
20.7 2.9
2.9
045
045 12/40
12/40 982
982 0.2
0.2 (50)
(50) 38.8
38.8 26.1
26.1 3.2
3.2 37.4
37.4 25.5
25.5 3.6
3.6 35.9
35.9 24.9
24.9 4.1
4.1 35.2
35.2 24.6
24.6 4.3
4.3 36.4
36.4 26.4
26.4 3.1
3.1 35.0
35.0 25.8
25.8 3.6
3.6 33.6
33.6 25.2
25.2 4.0
4.0 32.8
32.8 24.9
24.9 4.2
4.2
045
045 15/30
15/30 1202
1202 0.2
0.2 (50)
(50) 39.3
39.3 27.3
27.3 3.2
3.2 37.8
37.8 26.8
26.8 3.6
3.6 36.3
36.3 26.2
26.2 4.1
4.1 35.6
35.6 25.9
25.9 4.3
4.3 36.8
36.8 27.7
27.7 3.1
3.1 35.4
35.4 27.1
27.1 3.6
3.6 33.9
33.9 26.5
26.5 4.0
4.0 33.2
33.2 26.2
26.2 4.2
4.2
050
050 15/40
15/40 1194
1194 0.2
0.2 (50)
(50) 46.8
46.8 31.5
31.5 3.4
3.4 45.2
45.2 30.9
30.9 3.9
3.9 43.6
43.6 30.2
30.2 4.3
4.3 42.8
42.8 29.9
29.9 4.6
4.6 43.8
43.8 31.8
31.8 3.4
3.4 42.3
42.3 31.2
31.2 3.8
3.8 40.7
40.7 30.5
30.5 4.3
4.3 39.9
39.9 30.2
30.2 4.5
4.5
050
050 18/30
18/30 1430
1430 0.2
0.2 (50)
(50) 48.3
48.3 33.4
33.4 3.4
3.4 46.7
46.7 32.8
32.8 3.9
3.9 45.0
45.0 32.2
32.2 4.4
4.4 44.1
44.1 31.9
31.9 4.6
4.6 45.2
45.2 33.8
33.8 3.4
3.4 43.6
43.6 33.1
33.1 3.8
3.8 42.0
42.0 32.5
32.5 4.3
4.3 41.1
41.1 32.1
32.1 4.6
4.6
060
060 18/40
18/40 1422
1422 0.2
0.2 (50)
(50) 56.6
56.6 38.1
38.1 4.2
4.2 54.5
54.5 37.2
37.2 4.8
4.8 52.3
52.3 36.3
36.3 5.4
5.4 51.2
51.2 35.9
35.9 5.7
5.7 52.9
52.9 38.4
38.4 4.2
4.2 50.9
50.9 37.6
37.6 4.8
4.8 48.7
48.7 36.6
36.6 5.4
5.4 47.6
47.6 36.2
36.2 5.7
5.7
060
060 21/30
21/30 1636
1636 0.2
0.2 (50)
(50) 56.6
56.6 38.7
38.7 4.2
4.2 54.5
54.5 37.9
37.9 4.8
4.8 52.2
52.2 37.1
37.1 5.4
5.4 51.1
51.1 36.7
36.7 5.7
5.7 52.8
52.8 39.1
39.1 4.2
4.2 50.8
50.8 38.3
38.3 4.8
4.8 48.6
48.6 37.4
37.4 5.4
5.4 47.5
47.5 37.0
37.0 5.7
5.7
070 21/30 1636 0.2 (50) 57.9 39.2 4.4 55.8 38.4 5.1 53.6 37.6 5.8 52.6 37.2 6.1 54.2 39.7 4.4 52.1 38.8 5.0 50.0 38.0 5.7 48.9 37.5 6.0
070 21/30 1636 0.2 (50) 57.9 39.2 4.4 55.8 38.4 5.1 53.6 37.6 5.8 52.6 37.2 6.1 54.2 39.7 4.4 52.1 38.8 5.0 50.0 38.0 5.7 48.9 37.5 6.0
070 21/40 1626 0.2 (50) 61.1 42.1 4.5 58.9 41.2 5.2 56.6 40.3 5.8 55.4 39.9 6.1 57.1 42.5 4.4 54.9 41.6 5.1 52.7 40.6 5.7 51.5 40.2 6.1
070 21/40 1626 0.2 (50) 61.1 42.1 4.5 58.9 41.2 5.2 56.6 40.3 5.8 55.4 39.9 6.1 57.1 42.5 4.4 54.9 41.6 5.1 52.7 40.6 5.7 51.5 40.2 6.1
Table 10
Capacity Ratings
Capacity Ratings 60Hz - High60Hz
Speed - High Speed
Air on coil Temperature DB/WB-80/67F (26.6/19.4C) Air on coil Temperature DB/WB-76/63F (24.4/17.2C)
Outdoor Indoor Indoor Unit
ESP Ambient(Condenser Entering Air)Temperature Ambient(Condenser Entering Air)Temperature
Unit Unit Air Flow Rate
95F (35C) 105F (41C) 115F (46C) 120F (49C) 95F (35C) 105F (41C) 115F (46C) 120F (49C)
TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI*
RXV DCYP CFM in.wg (Pa)
MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW
021 06/30 581 0.1 (25) 18.9 13.2 1.9 17.9 12.8 2.0 17.0 12.4 2.2 16.5 12.3 2.2 17.6 13.3 1.8 16.6 12.9 2.0 15.6 12.5 2.1 15.1 12.3 2.2
021 06/40 583 0.1 (25) 20.3 14.3 2.0 19.3 14.0 2.1 18.3 13.6 2.3 17.8 13.4 2.3 18.8 14.4 1.9 17.7 14.0 2.0 16.7 13.6 2.2 16.2 13.3 2.2
026 06/40 583 0.1 (25) 22.9 15.4 2.2 21.7 14.9 2.3 20.4 14.4 2.4 19.8 14.1 2.5 21.4 15.5 2.1 20.2 15.0 2.2 18.9 14.5 2.4 18.3 14.2 2.4
026 08/30 735 0.1 (25) 23.3 16.4 2.2 22.1 15.9 2.4 20.8 15.4 2.5 20.2 15.2 2.6 21.8 16.5 2.2 20.6 16.0 2.3 19.3 15.5 2.4 18.6 15.3 2.4
031 08/40 732 0.1 (25) 28.1 19.0 3.0 26.8 18.5 3.1 25.6 18.0 3.2 24.9 17.7 3.3 26.2 19.2 2.9 25.0 18.6 3.0 23.7 18.1 3.1 23.1 17.9 3.2
031 10/30 984 0.1 (25) 29.6 21.3 3.1 28.2 20.8 3.2 26.9 20.3 3.3 26.2 20.0 3.4 27.6 21.5 2.9 26.3 20.9 3.1 25.0 20.4 3.2 24.3 20.1 3.3
041 10/40 986 0.1 (25) 35.7 24.7 3.2 33.9 24.0 3.4 32.2 23.4 3.6 31.3 23.1 3.7 33.2 24.9 3.1 31.5 24.2 3.3 29.8 23.5 3.4 29.0 23.2 3.6
041 12/30 1147 0.1 (25) 35.2 25.0 3.2 33.5 24.4 3.4 31.7 23.7 3.6 30.9 23.4 3.7 32.7 25.2 3.1 31.1 24.5 3.2 29.4 23.9 3.4 28.6 23.5 3.5
046 12/40 1150 0.1 (25) 44.8 30.0 3.9 43.1 29.3 4.4 41.4 28.7 4.9 40.6 28.4 5.1 42.0 30.4 3.8 40.4 29.7 4.3 38.7 29.0 4.8 37.9 28.7 5.0
046 15/40 1450 0.1 (25) 48.4 34.5 4.0 46.5 33.8 4.5 44.7 33.1 4.9 43.8 32.8 5.1 45.3 34.9 3.9 43.5 34.2 4.4 41.7 33.4 4.9 40.8 33.1 5.1
051 15/40 1450 0.1 (25) 54.4 36.9 4.2 52.7 36.2 4.7 50.9 35.5 5.2 50.0 35.1 5.5 50.8 37.2 4.1 49.2 36.5 4.6 47.4 35.8 5.2 46.6 35.4 5.4
051 18/30 1804 0.1 (25) 56.3 39.7 4.2 54.5 39.0 4.7 52.6 38.3 5.3 51.6 37.9 5.6 52.5 40.1 4.1 50.8 39.4 4.6 49.0 38.6 5.2 48.0 38.2 5.5
061 18/40 1807 0.1 (25) 66.9 45.8 5.2 64.7 44.9 5.9 62.4 44.1 6.6 61.2 43.6 7.0 62.7 46.4 5.1 60.5 45.4 5.8 58.2 44.5 6.6 57.0 44.0 6.9
061 21/30 2190 0.1 (25) 66.6 47.2 5.2 64.3 46.3 5.9 62.0 45.5 6.6 60.9 45.1 7.0 62.4 47.7 5.1 60.1 46.8 5.8 57.8 45.9 6.6 56.7 45.4 6.9
071 18/40 1807 0.1 (25) 68.9 46.6 5.5 66.6 45.7 6.2 64.2 44.7 7.0 63.0 44.3 7.3 64.6 47.2 5.4 62.3 46.2 6.1 60.0 45.2 6.9 58.8 44.7 7.2
071 21/30 2190 0.1 (25) 68.5 47.9 5.5 66.2 47.0 6.2 63.8 46.1 6.9 62.6 45.7 7.3 64.3 48.5 5.3 62.0 47.6 6.1 59.7 46.6 6.9 58.5 46.2 7.2
11
Indoor Unit
SKM Air Cooled Condensing Units
Air on coil Temperature DB/WB-80/67F (26.6/19.4C) Air on coil Temperature DB/WB-76/63F (24.4/17.2C)
Outdoor
Unit
Indoor
Unit
Air Flow
Rate
ESP RXV/RXH-D+DCYP - R-22
95F (35C)
Ambient(Condenser Entering Air)Temperature
105F (41C) 115F (46C) 95F (35C)
Ambient(Condenser Entering Air)Temperature
105F (41C) 115F (46C)
TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI*
RXH-5DC DCYP CFM in.wg (Pa)
MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW
Combination
020
Capacity06/30 Ratings
Ratings68650Hz0.1-(25)High18.0
- RXH-D and DCYP Units
Speed13.7 1.9 17.0 13.4 2.0 16.0 13.0 2.1 16.7 13.8 1.8 15.8 13.5 1.9 14.9 13.1 2.0
025 06/40 680 0.1 (25) 24.4 16.9 2.4 23.5 16.5 2.6 22.6 16.2 2.8 22.9 17.1 2.3 22.0 16.7 2.5 21.1 16.3 2.7
Capacity
025 08/30
Ratings
785
50Hz17.1- High
0.1 (25) 24.3 2.4
Speed
23.4 16.8 2.6 22.4 16.5 2.8 22.8 17.3 2.3 21.9 17.0 2.5 21.0 16.6 2.7
Indoor Air on coil Temperature DB/WB-80/67F (26.6/19.4C) Air on coil Temperature DB/WB-76/63F (24.4/17.2C)
030
Outdoor 08/40
Indoor 777Unit 0.1 (25) 28.9 19.7 2.9 27.8 19.3 3.2 26.8 18.9 3.6 27.0 19.9 2.8 26.0 19.5 3.1 25.0 19.1 3.5
Air Flow ESP Ambient(Condenser Entering Air)Temperature Ambient(Condenser Entering Air)Temperature
030
Unit Unit
10/30 1061
Rate 0.1 (25) 30.4 22.2
95F (35C)
3.0 29.2 105F21.8(41C) 3.3 28.0 21.4
115F (46C)
3.6 28.4 22.5
95F (35C)
2.9 27.3 105F22.0(41C) 3.2 26.2 21.6
115F (46C)
3.5
040 10/40 1046 0.1 (25) 36.5
TC 25.6
SC 3.7
PI* 35.1
TC 25.1
SC 4.1
PI* 33.6
TC 24.5
SC 4.6
PI* 34.0
TC 25.8
SC 3.6
PI* 32.7
TC 25.3
SC 4.1
PI* 31.2
TC 24.7
SC 4.5
PI*
RXH-5DC DCYP CFM in.wg (Pa)
040 12/30 1331 0.1 (25) 36.5
MBh 27.0
MBh 3.7
kW 35.1
MBh 26.5
MBh 4.1
kW 33.6
MBh 25.9
MBh 4.6
kW 34.0
MBh 27.2
MBh 3.6
kW 32.7
MBh 26.7
MBh 4.1
kW 31.2
MBh 26.1
MBh 4.5
kW
045
020 12/40
06/30 1317
686 0.1 (25) 43.4
18.0 31.0
13.7 4.0
1.9 41.8
17.0 30.4
13.4 4.6
2.0 40.0
16.0 29.8
13.0 5.1
2.1 40.6
16.7 31.4
13.8 3.9
1.8 39.0
15.8 30.7
13.5 4.4
1.9 37.3
14.9 30.0
13.1 4.9
2.0
025 06/40 680 0.1 (25) 24.4 16.9 2.4 23.5 16.5 2.6 22.6 16.2 2.8 22.9 17.1 2.3 22.0 16.7 2.5 21.1 16.3 2.7
045 15/30 1536 0.1 (25) 42.8 31.5 4.0 41.2 30.9 4.5 39.5 30.2 5.1 40.1 31.8 3.9 38.5 31.1 4.4 36.8 30.5 4.9
025 08/30 785 0.1 (25) 24.3 17.1 2.4 23.4 16.8 2.6 22.4 16.5 2.8 22.8 17.3 2.3 21.9 17.0 2.5 21.0 16.6 2.7
050
030 15/40
08/40 1519
777 0.1
0.1 (25)
(25) 48.1
28.9 35.1
19.7 4.3
2.9 46.3
27.8 34.4
19.3 4.9
3.2 44.3
26.8 33.6
18.9 5.5
3.6 44.9
27.0 35.4
19.9 4.2
2.8 43.1
26.0 34.7
19.5 4.8
3.1 41.2
25.0 33.9
19.1 5.3
3.5
050
030 18/30
10/30 1914
1061 0.1
0.1 (25)
(25) 49.5
30.4 38.0
22.2 4.3
3.0 47.5
29.2 37.4
21.8 4.9
3.3 45.5
28.0 36.6
21.4 5.5
3.6 46.2
28.4 38.4
22.5 4.2
2.9 44.3
27.3 37.6
22.0 4.8
3.2 42.3
26.2 36.9
21.6 5.4
3.5
040 10/40 1046 0.1 (25) 36.5 25.6 3.7 35.1 25.1 4.1 33.6 24.5 4.6 34.0 25.8 3.6 32.7 25.3 4.1 31.2 24.7 4.5
060 18/40 1882 0.1 (25) 59.3 43.6 5.3 56.9 42.7 5.9 54.2 41.7 6.5 55.4 44.0 5.1 53.1 43.1 5.8 50.6 42.1 6.4
040 12/30 1331 0.1 (25) 36.5 27.0 3.7 35.1 26.5 4.1 33.6 25.9 4.6 34.0 27.2 3.6 32.7 26.7 4.1 31.2 26.1 4.5
060
045 21/30
12/40 2200
1317 0.1 (25)
0.1 (25) 58.6
43.4 44.3
31.0 5.3
4.0 56.2
41.8 43.5
30.4 5.9
4.6 53.6
40.0 42.6
29.8 6.5
5.1 54.8
40.6 44.8
31.4 5.1
3.9 52.5
39.0 43.9
30.7 5.7
4.4 50.1
37.3 42.9
30.0 6.3
4.9
045 15/30 1536 0.1 (25) 42.8 31.5 4.0 41.2 30.9 4.5 39.5 30.2 5.1 40.1 31.8 3.9 38.5 31.1 4.4 36.8 30.5 4.9
050 15/40 1519 0.1 (25) 48.1 35.1 4.3 46.3 34.4 4.9 44.3 33.6 5.5 44.9 35.4 4.2 43.1 34.7 4.8 41.2 33.9 5.3
050 18/30 1914 0.1 (25) 49.5 38.0 4.3 47.5 37.4 4.9 45.5 36.6 5.5 46.2 38.4 4.2 44.3 37.6 4.8 42.3 36.9 5.4
060 18/40 1882 0.1 (25) 59.3 43.6 5.3 56.9 42.7 5.9 54.2 41.7 6.5 55.4 44.0 5.1 53.1 43.1 5.8 50.6 42.1 6.4
Capacity Ratings 50Hz - Medium Speed
060 21/30 2200 0.1 (25) 58.6 44.3 5.3 56.2 43.5 5.9 53.6 42.6 6.5 54.8 44.8 5.1 52.5 43.9 5.7 50.1 42.9 6.3
Table 12
Capacity Ratings 50Hz - Medium Speed
Capacity Ratings
Indoor 50Hz
Unit - Medium Speed Air on coil Temperature DB/WB-80/67F (26.6/19.4C) Air on coil Temperature DB/WB-76/63F (24.4/17.2C)
Outdoor Indoor
Air Flow ESP Ambient(Condenser Entering Air)Temperature Ambient(Condenser Entering Air)Temperature
Unit Unit
RateUnit
Indoor 95F (35C) Air on coil Temperature DB/WB-80/67F
105F (41C) (26.6/19.4C) 115F (46C) 95F (35C) Air on coil Temperature DB/WB-76/63F
105F (41C) (24.4/17.2C) 115F (46C)
Outdoor Indoor
Air Flow ESP Ambient(Condenser Entering Air)Temperature Ambient(Condenser Entering Air)Temperature
Unit Unit
Rate TC SC
95F (35C)
PI* TC SC
105F (41C)
PI* TC SC
115F (46C)
PI* TC SC
95F (35C)
PI* TC SC
105F (41C)
PI* TC SC
115F (46C)
PI*
RXH-5DC DCYP CFM in.wg (Pa)
MBh
TC MBh
SC kW
PI* MBh
TC MBh
SC kW
PI* MBh
TC MBh
SC kW
PI* MBh
TC MBh
SC kW
PI* MBh
TC MBh
SC kW
PI* MBh
TC MBh
SC kW
PI*
RXH-5DC DCYP CFM in.wg (Pa)
020 06/30 501 0.2 (50) MBh 16.9 11.7
MBh 1.8
kW 16.0
MBh 11.4
MBh 1.9
kW 15.1
MBh 11.1
MBh 2.0
kW 15.6
MBh 11.8
MBh 1.8
kW 14.9
MBh 11.5
MBh 1.8
kW 14.0
MBh 11.1
MBh 1.9
kW
020 06/30 501 0.2 (50) 16.9 11.7 1.8 16.0 11.4 1.9 15.1 11.1 2.0 15.6 11.8 1.8 14.9 11.5 1.8 14.0 11.1 1.9
025 08/40 587 0.2 (50) 24.2 16.1 2.3 23.3 15.7 2.6 22.4 15.3 2.8 22.7 16.3 2.3 21.8 15.9 2.5 20.9 15.5 2.7
025 08/40 587 0.2 (50) 24.2 16.1 2.3 23.3 15.7 2.6 22.4 15.3 2.8 22.7 16.3 2.3 21.8 15.9 2.5 20.9 15.5 2.7
030
030 10/40
10/40 728
728 0.2
0.2 (50)
(50) 29.7
29.7 19.8
19.8 2.9
2.9 28.5
28.5 19.4
19.4 3.3
3.3 27.4
27.4 19.0
19.0 3.6
3.6 27.7
27.7 20.1
20.1 2.8
2.8 26.7
26.7 19.6
19.6 3.2
3.2 25.6
25.6 19.1
19.1 3.5
3.5
040
040 12/40
12/40 982
982 0.2
0.2 (50)
(50) 36.6
36.6 25.2
25.2 3.7
3.7 35.2
35.2 24.6
24.6 4.1
4.1 33.7
33.7 24.1
24.1 4.6
4.6 34.1
34.1 25.4
25.4 3.6
3.6 32.7
32.7 24.8
24.8 4.1
4.1 31.3
31.3 24.2
24.2 4.5
4.5
045 15/40 1194 0.2 (50) 43.5 30.2 4.0 41.8 29.5 4.6 40.1 28.9 5.1 40.7 30.5 3.9 39.0 29.8 4.4 37.3 29.1 5.0
045
050
15/40 1194 0.2 (50) 43.5 30.2 4.0 41.8 29.5 4.6 40.1 28.9 5.1 40.7 30.5 3.9 39.0 29.8 4.4 37.3 29.1 5.0
18/30 1430 0.2 (50) 46.9 32.9 4.3 45.1 32.2 4.9 43.2 31.5 5.4 43.9 33.3 4.1 42.1 32.5 4.7 40.3 31.8 5.3
050
060 18/30
18/40 1430
1422 0.2
0.2 (50)
(50) 46.9
55.6 32.9
37.6 4.3
5.1 45.1
53.4 32.2
36.8 4.9
5.8 43.2
51.1 31.5
35.9 5.4
6.4 43.9
52.1 33.3
38.1 4.1
5.0 42.1
49.9 32.5
37.2 4.7
5.6 40.3
47.7 31.8
36.2 5.3
6.2
060
060 18/40
21/30 1422
1636 0.2
0.2 (50)
(50) 55.6
55.5 37.6
38.3 5.1
5.1 53.4
53.3 36.8
37.5 5.8
5.8 51.1
51.0 35.9
36.6 6.4
6.4 52.1
52.0 38.1
38.8 5.0
5.0 49.9
49.8 37.2
37.9 5.6
5.6 47.7
47.6 36.2
37.0 6.2
6.2
Capacity
060 Ratings163650Hz0.2 -(50)High55.5
21/30 Speed38.3 5.1 53.3 37.5 5.8 51.0 36.6 6.4 52.0 38.8 5.0 49.8 37.9 5.6 47.6 37.0 6.2
Capacity Ratings 60Hz - High Speed Table 13
Indoor Unit Air on coil Temperature DB/WB-80/67F (26.6/19.4C) Air on coil Temperature DB/WB-76/63F (24.4/17.2C)
Outdoor Indoor
Air Flow ESP Ambient(Condenser Entering Air)Temperature Ambient(Condenser Entering Air)Temperature
Unit Unit
Rate 95F (35C) 105F (41C) 115F (46C) 95F (35C) 105F (41C) 115F (46C)
TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI*
RXH-5DC DCYP CFM in.wg (Pa)
MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW
020 06/30 686 0.1 (25) 18.0 13.7 1.9 17.0 13.4 2.0 16.0 13.0 2.1 16.7 13.8 1.8 15.8 13.5 1.9 14.9 13.1 2.0
025 06/40 680 0.1 (25) 24.4 16.9 2.4 23.5 16.5 2.6 22.6 16.2 2.8 22.9 17.1 2.3 22.0 16.7 2.5 21.1 16.3 2.7
025 08/30 785 0.1 (25) 24.3 17.1 2.4 23.4 16.8 2.6 22.4 16.5 2.8 22.8 17.3 2.3 21.9 17.0 2.5 21.0 16.6 2.7
030 08/40 777 0.1 (25) 28.9 19.7 2.9 27.8 19.3 3.2 26.8 18.9 3.6 27.0 19.9 2.8 26.0 19.5 3.1 25.0 19.1 3.5
030 10/30 1061 0.1 (25) 30.4 22.2 3.0 29.2 21.8 3.3 28.0 21.4 3.6 28.4 22.5 2.9 27.3 22.0 3.2 26.2 21.6 3.5
040 10/40 1046 0.1 (25) 36.5 25.6 3.7 35.1 25.1 4.1 33.6 24.5 4.6 34.0 25.8 3.6 32.7 25.3 4.1 31.2 24.7 4.5
040 12/30 1331 0.1 (25) 36.5 27.0 3.7 35.1 26.5 4.1 33.6 25.9 4.6 34.0 27.2 3.6 32.7 26.7 4.1 31.2 26.1 4.5
045 12/40 1317 0.1 (25) 43.4 31.0 4.0 41.8 30.4 4.6 40.0 29.8 5.1 40.6 31.4 3.9 39.0 30.7 4.4 37.3 30.0 4.9
045 15/30 1536 0.1 (25) 42.8 31.5 4.0 41.2 30.9 4.5 39.5 30.2 5.1 40.1 31.8 3.9 38.5 31.1 4.4 36.8 30.5 4.9
050 15/40 1519 0.1 (25) 48.1 35.1 4.3 46.3 34.4 4.9 44.3 33.6 5.5 44.9 35.4 4.2 43.1 34.7 4.8 41.2 33.9 5.3
050 18/30 1914 0.1 (25) 49.5 38.0 4.3 47.5 37.4 4.9 45.5 36.6 5.5 46.2 38.4 4.2 44.3 37.6 4.8 42.3 36.9 5.4
060 18/40 1882 0.1 (25) 59.3 43.6 5.3 56.9 42.7 5.9 54.2 41.7 6.5 55.4 44.0 5.1 53.1 43.1 5.8 50.6 42.1 6.4
060 21/30 2200 0.1 (25) 58.6 44.3 5.3 56.2 43.5 5.9 53.6 42.6 6.5 54.8 44.8 5.1 52.5 43.9 5.7 50.1 42.9 6.3
Notes : Table 14
1. Shaded areas represent matched cooling capacities based as per AHRI Standards 210/240, 80/67F (26.6/19.4C) DB/WB temperature
of air entering the indoor coil and 95F outside air dry bulb. Capacities at other ambient temperature as shown.
Capacity Ratings 50Hz - Medium Speed
2. For matched conditions, at entering condition other than shown, consult SKM.
3. Direct interpolation is permissible but extrapolation is prohibited.
4. Combination ratings are based on indoor and outdoor units at the same elevation and connected by 25 ft. (7.6 m) of refrigerant tubing.
Do not exceed
Indoor 120
Unit feet tubing length without Air on coil Temperature
checking withDB/WB-80/67F
SKM. (26.6/19.4C) Air on coil Temperature DB/WB-76/63F (24.4/17.2C)
5.Outdoor Indoor cooling capacity in Mbh (1000 Btuh)
TC - Total Air Flow ESP Ambient(Condenser Entering Air)Temperature Ambient(Condenser Entering Air)Temperature
Unit SC - Sensible
Unit cooling capacity in Mbh (1000 Btuh)
Rate 95F (35C) 105F (41C) 115F (46C) 95F (35C) 105F (41C) 115F (46C)
PI - Power input in kW (compressor on
To convert Mbh to kW, divide TC
by 3.413SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI* TC SC PI*
RXH-5DC DCYP CFM in.wg (Pa)
To convert cfm to l/s, divide by MBh2.12 MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW MBh MBh kW
6. 020 Its recommended
06/30 501 to0.2use 16.9
(50) expansion 11.7
valve when1.8 operating
16.0 at11.4 1.9
115F ambient 15.1 11.1
and above. 2.0 15.6 11.8 1.8 14.9 11.5 1.8 14.0 11.1 1.9
025
* Power 08/40 mentioned
input 587 0.2
in(50) 24.2 should
this page 16.1 not be
2.3 used23.3 for cable 15.7or fuse 2.6 selection.
22.4 MCA 15.3 and MFA
2.8 values
22.7 given16.3in the2.3electrical21.8 data15.9pages (13 2.5 - 14) 20.9should15.5be referred
2.7
for 030
the same. 10/40 728 0.2 (50) 29.7 19.8 2.9 28.5 19.4 3.3 27.4 19.0 3.6 27.7 20.1 2.8 26.7 19.6 3.2 25.6 19.1 3.5
040 12/40 982 0.2 (50) 36.6 25.2 3.7 35.2 24.6 4.1 33.7 24.1 4.6 34.1 25.4 3.6 32.7 24.8 4.1 31.3 24.2 4.5
045 15/40 1194 0.2 (50) 43.5 30.2 4.0 41.8 29.5 4.6 40.1 28.9 5.1 40.7 30.5 3.9 39.0 29.8 4.4 37.3 29.1 5.0
12
050 18/30 1430 0.2 (50) 46.9 32.9 4.3 45.1 32.2 4.9 43.2 31.5 5.4 43.9 33.3 4.1 42.1 32.5 4.7 40.3 31.8 5.3
060 18/40 1422 0.2 (50) 55.6 37.6 5.1 53.4 36.8 5.8 51.1 35.9 6.4 52.1 38.1 5.0 49.9 37.2 5.6 47.7 36.2 6.2
060 21/30 1636 0.2 (50) 55.5 38.3 5.1 53.3 37.5 5.8 51.0 36.6 6.4 52.0 38.8 5.0 49.8 37.9 5.6 47.6 37.0 6.2
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
Electrical Data
RXV/RXH-D+DCYP
- 50Hz
R-22Systems
Outdoor Unit:RXV
Model RXV 020 025 030 040 045 050 060 070
Electrical Data - RXV& DCYP
Power Supply 220-240V/1Ph/50Hz 380-415V/3Ph/50Hz
Electrical
Comp. RLA
Type - 11.4 220-240V/1Ph/50Hz,3
15 16.5 Speed 15.3 7.3with Permanent
Electric Motor 9.6 Split10.5
Capacitor10.9
Comp. LRA
Motor Size Watts 51
150 58
150 58
150 85
150 50
150 61.8
150 74
150 74
150
Condenser
Quantity # motor FLA 0.85
1 0.85
1 0.85
1 0.85
2 1.1
2 1.1
2 1.1
2 1.1
2
MFA
High 32
1.3 40
1.4 40
1.3 40
2.6 25
2.8 32
2.6 32
2.8 32
2.8
Unit Characteristics
Maximum MCA
Speed Medium 17
0.9 21
1.1 23
1.1 23
1.8 13
2.2 16
2.2 17
2.2 18
2.2
Amps
Indoor Unit:DCYP Low Table 15
0.8 0.8 0.8 1.6 1.6 1.6 1.8 1.8
Unit Size DCYP 06 08 10 12 15 18 21 21
Type - 220-240V/1Ph/50Hz,3 Speed Electric Motor with Permanent Split Capacitor
Motor Size Watts 150 150 150 150 150 150 150 150
Electrical Data - 60Hz
Quantity # 1 1 1 2 2 2 2 2
Outdoor Unit: RXV High
- 60Hz
1.3 1.4 1.3 2.6 2.8 2.6 2.8 2.8
Maximum
Outdoor Unit:RXV
Speed Medium 0.9 1.1 1.1 1.8 2.2 2.2 2.2 2.2
Amps
Model Low
RXV 0.8
021 0.8
026 0.8
031 1.6
041 1.6
046 1.6
051 1.8
061 1.8
071
(i) 220V/1Ph/60Hz (i) 220V/3Ph/60Hz
Power Supply
- (ii) 380V/3Ph/60Hz
Electrical Data Comp.RLA
- 60Hz (i) 11.2 13.2 16.2 19.4 15.6 18.2 21.4 22
Electrical
(i)
(ii) 17
- 19
- 23
- 28- 24
9.4 28
11 32
12 33
13.2
MCA
(ii)
(i) -
55 -
56 -
65 90- 16
91 18
124 20
156 21
156
Comp. LRA
Indoor Unit:DCYP (ii) - - - - 54 75 70 70
Table 16
13
Indoor Unit:DCYP
Unit Size
ElectricalType
Data -- 50Hz
DCYP SKM Air
06 Cooled
08 10 Condensing
12 15 18 Units 21 21
14
SKM Air Cooled Condensing Units
SKM Ducted Mini Split Systems
RXV/RXH-D+DCYP
Electrical Data - RXH-D & DCYP - R-22
Side Discharge
Side Discharge Compressor
Outdoor
Outdoor RUnit: 020020
RXH-D-50Hz
RXH-D-50Hz 025025 030030 040040 045045 050050 060060
Power Supply
LRA 51 60.1220-240V/1Ph/50Hz84 130 56 380-415V/3Ph/50Hz
52 73
Model Power
Condenser Supply
RXH-motor5DC FLA 020 220-240V/1Ph/50Hz
025 030 040 045 380-415V/3Ph/50Hz
050 060
RLA 0.516 0.6220 0.7430 0.7432 1.3211 0.6711.5 0.6714
Electrical
CompressorCondenser motor FLALRA 0.551 0.62 0.7484 0.74 1.3256 0.6752 0.6773
No of Condenser motor 1 60.1 1 1 130 1 1 2 2
Indoor Unit: DCYP-50Hz NoCondenser
of Condenser motor 1 1 1 1 1 2 2
motor FLA 0.5 0.62 0.74 0.74 1.32 0.67 0.67Table 25
Unit Size DCYP 06 08 10 12 15 18 21 25
Table
No of Condenser motor 1 1 1 1 1 2 2
Indoor Unit: DCYP-50Hz Type - 220-240V/1Ph/50-60Hz,3 Speed Electric Motor with Permanent Split Capacitor Table 19
Table 25
Indoor
Indoor Unit: DCYP-50Hz
Unit SizeUnit: DCYP-50Hz
Motor Size Watts
DCYP 150
06 15008 15010 15012 15015 15018 15021
Quantity
Unit Size Unit: DCYP-50Hz
Indoor Type DCYP #- 061 081 101 Speed 12Electric
220-240V/1Ph/50-60Hz,3 2 Motor with 152 Permanent Split 182 Capacitor 212
Motor Size
Type High
Watts
- 1.3
150 1.4
150
220-240V/1Ph/50-60Hz,3 1.3
150 2.6
150 2.8
150 2.6
150 2.8150
Unit Size
Maximum DCYP 06 08 10 Speed Electric 12 Motor with15Permanent Split18Capacitor 21
Motor Speed
Quantity
Size Medium
Watts # 0.91
150 1501.11 1501.11 1.82
150 2.22 2.22 2.22
Amps Type - 220-240V/1Ph/50-60Hz,3 Speed Electric Motor with150Permanent Split150Capacitor 150
Quantity Low
High
# 0.8
11.3 10.8
1.4 10.81.3 21.62.6 21.62.8 21.62.6 21.82.8
Motor
Maximum Size Watts 150 150 150 150 150 150 150
Speed Medium
High 1.30.9 1.411.1 1.311.1 2.621.8 2.822.2 2.622.2 2.2 26
2.82Table
Amps Quantity # 1
Maximum Low 0.8 0.8 0.8 1.6 1.6 1.6 1.8
Speed Medium 0.9
High RXH-D-60Hz
1.3 1.1
1.4 1.1
1.3 1.8
2.6 2.2
2.8 2.2
2.6 2.2
2.8Table 26
Amps
Side Discharge
Maximum Outdoor Unit:
Speed Low
Medium 0.8
0.9 0.8
1.1 0.8
1.1 1.6
1.8 1.6
2.2 1.6
2.2 1.8
2.2
Amps Model RXH- Low6DC
Side Discharge Outdoor Unit: 0.8
RXH-D-60Hz
020 0.8 025 0.8 030 1.6 040 1.6 045 1.6 050 1.8 060 26
Table 20
Table
Side Discharge Outdoor Unit: RXH-D-60Hz
Power Supply 220V/1Ph/60Hz Table 26
Model
Side Discharge Outdoor Unit: RXH- 6DCRXH-D-60Hz 020 025 030 040 045 050 060
RLA 16 20 30 32 36 36 43
Electrical Electrical
Side Discharge
Model Compressor Power
Outdoor Unit:
RXH- SupplyRXH-D-60Hz020
6DC 025 030 220V/1Ph/60Hz
040 045 050 060
LRA 42 66.51 95 101 164 164 188
Model RXH- 6DC RLA 020 16 02520 03030 220V/1040Ph/3260Hz 04536 05036 06043
Electrical
Power Suppl y
CompressorCondenser motor FLA 0. 53 0.66.51
67 0.8956 0.101
86 1.164
17 0.164
75 0.18875
LRA 42
Power Suppl yRLA 16 201 301 220V/321Ph/1 60Hz 361 362 432
CompressorNoCondenser
of Condenser
motormotor
FLA 1
0.53 0.67 0.86 0.86 1.17 0.75 0.75
RLA
LRA 16
42 66.2051 9530 10132 16436 16436 43 27
188Table
Electrical
15
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Options
Thermostat
Thermostat is wall mounted decorative type, with large LCD and backlight. Buttons are provided for power on/off, fan speed selection,
cooling or heating mode selection, set point adjustment and sleep mode selection. Indoor temperature and set point are displayed
simultaneously. Apart from that, display provides fan mode (high, medium, low or auto) and operating mode (cool or heat).
Note:
Expansion Valves
Expansion Valves can be used as an option instead of orifice for the following combinations:
16
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
17
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
18
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
RXH-D Model Recommended Suction And Liquid Line Sizes For Various Length of Run to Evaporator Side- Ft. (m)
(Side Discharge 25 (7.6) 50 (15.2) 75 (22.9) 100 (30.5) 120 (36.6)
Condensing Unit) Suction Liquid Suction Liquid Suction Liquid Suction Liquid Suction Liquid
20 5/8 3/8 5/8 3/8 3/4 3/8 3/4 3/8 3/4 3/8
25 5/8 3/8 3/4 3/8 3/4 3/8 3/4 3/8 3/4 1/2
30 5/8 3/8 3/4 3/8 3/4 1/2 7/8 1/2 7/8 1/2
40 3/4 3/8 3/4 3/8 7/8 1/2 7/8 1/2 7/8 1/2
45 3/4 3/8 7/8 1/2 7/8 1/2 1 1/8 1/2 1 1/8 1/2
50 3/4 3/8 7/8 1/2 1 1/8 1/2 1 1/8 1/2 1 1/8 1/2
60 7/8 1/2 1 1/8 1/2 1 1/8 1/2 1 1/8 1/2 1 1/8 1/2
Table 26
Notes :
The recommended or required suction and liquid line sizes do not necessarily correspond with the refrigerant
connections available on the outdoor or indoor unit. Necessary transformation may be required and its field performed.
19
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Legend:
4
1
REFRIGERANT PIPING
20
SKM Air Cooled Condensing Units
SKM Ducted Mini Split
RXV/RXH-D+DCYP - R-22Systems
Legend:
4 2
5
2
1
3
21
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
EQUIP. GRND.
FM
FH
FL
H
N
C
L
FIELD SIDE
CONTACTOR ANTI SHORT
FAN MOTOR CYCLE TIMER LPS HPS
S L1 L2 1
CAPACITOR
220~240V
1
C C1 TO INDOOR UNIT FROM INDOOR UNIT
FIELD CONNECTIONS
R T1 T2 2 2
RUN CAPACITOR
UNIT SIDE
START
RELAY MOTOR BODY
EARTHING
FM
FM
FH
FH
FL
FL
N
N
E
E
START CAPACITOR FAN FAN
MOTOR MOTOR (IF APPLICABLE)
1 2
L1 L2 L3 N Grd L N E
GROUNDING LUG
FM
CRANKCASE
FH
FL
N
H
C
L
FIELD SIDE
HEATER
(AUX. CONTACT)
1
CONTACTOR FROM INDOOR UNIT
ANTI SHORT FIELD CONNECTIONS
CYCLE TIMER LPS HPS 2
L1 L2 L3 1
220-240V
UNIT SIDE
3~ 3~
MOTOR MOTOR
MOTOR BODY
EARTHING
FM
FM
FH
FH
FL
FL
N
MOTOR MOTOR
FAN FAN FIELD WIRING (BY OTHERS)
MOTOR MOTOR
1 2
BLACK
CN201 CN200
R
RED
CN9
C
Y/G
P.C.B
CN206 CAP1
FIELDSIDE
RED
RED
CN38 L
FROM N
CN39
BLACK
BLACK
BLACK
WHITE
WHITE
OUTDOOR UNIT
CN203 CT2 1
CN40
CN208
XP1 XS1
XP2 XS2
JUNCTIONBOX
T3
TRANS
Y/G
K1 K3
UNITSIDE
BLACK
RED
CAP2
BLUE
RED FAN
A1
21
5
3
1
T4 XT2
KM8
FM
FH
RED
FL
N
A2
22
6
4
2
RED
BLACK
BLACK MOTOR
BLACK
RED
XT1 CODE PART NAME
L N 1 CAP1, 2 CAPACITOR
K1, K2 HIGH, LOWPRESSURESWITCH
TRANS POWERTRANSFORMER
POWER
FAN OUT DOORFAN
Y/G
T4 RESISTANCE
LN1 T3 RESISTANCE
XP1~ 2, XS1~ 2 CONNECTORS
TOINDOORUNIT
CT2 CURRENTDETECT
XT1 5WAYTERMINAL
XT2 TERMINAL
KM8 CONTACTOR
22
POWER SUPPLY: 220~240V/1PH/50HZ
RED
CN201 CN200
R
K2 SW1
S
RED BLACK COMP.
CN9
BLACK
WHITE
RED
C Y/G
P.C.B
CN206 CAP1
RED
RED
CN38 THERMOSTAT WITH 3SPEED SWITCH
(BY OTHERS / OPTION)
CN39
CN203
WHITE
BLACK
CT2 CN40
RXV/RXH-D+DCYP
CN208
XP1 XS1
XP2 XS2
WHITE
BLUE
FIELD SIDE
TRANS L
SKM Ducted Mini Split
FROM N
OUT DOOR UNIT
1
RED
Typical Wiring Diagram - RXH-D & DCYP
K1
CAP2
5
3
1
A1
21
RED
BLUE
K3
XT4
JUNCTION BOX
KM8
T4
6
4
2
22
A2 Y/G
T3 R FAN
BLACK
RED
BLACK
BLACK
UNIT SIDE
BLACK
- R-22Systems
MOTOR BODY
EARTHING
SKM Air Cooled Condensing Units
N
FH
FM
FL
E
N
FH
FM
FL
E
BLACK
BLACK
RED
RED
RED CAP 1, 2 CAPACITOR FAN FAN (APPLICABLE FOR
MOTOR MOTOR
XT2 XT1 K1, K3 HIGH, LOW PRESSURESWITCH RXH- 040 5DC + DCYP- 12)
1 2
TRANS POWER TRANSFORMER
L N 1 3 4
FAN OUT DOOR FAN INDOOR UNIT(DCYP- 10 & 12)
T4 ROOM TEMPARATURE
POWER T3 PIPETEMPARATURE
XP1~ 2, XS1~ 2 CONNECTORS
CT2 CURRENT DETECT
L N E 1
KM8 CONTACTOR
TOINDOORUNIT TOINDOORUNIT
XT3, XT4 TERMINAL
K2 TEMPARETUREPROTECTOR SWITCH
CN100-208 P.C. BOARD SOCKETS
23
24
POWER SUPPLY:- 380~415V/3PH/50HZ
L.P. SW
CN208
RT3
T3
CN206
XS2 XP2 XS1 XP1 HI-PRO K1
R
CN203
XS3 XP3 CT1
CN201 CN100 CN200
BLACK
ORANGE
RED
WHITE
BLUE
BLACK
L
FIELD SIDE
RED
FROM N
BLACK OUT DOOR UNIT
1
KM1
ORANGE A1 A2
XT6 RED 1 2
WHITE 3 4
BLUE 5 6
Typical Wiring Diagram - RXH-D & DCYP
JUNCTION BOX
21 22
Y/G
Y/G
FAN3 BLACK
CODE PARTNAME
RED
BLUE
BLACK
COMP COMPRESSOR
BLUE BLUE W(T3) FAN3,FAN4 OUTDOORFAN
WHITE
CAP3,CAP4 FANCAPACITOR
V(T2)
UNIT SIDE
XT2 4WAYTERMINAL
POWER K1 TEMP. PROTECTSWITCH
380~ 415V/3PH/50Hz INDOOR UNIT(DCYP- 15) CN100-208 P.C. BOARDSOCKETS
1 L N
CN208
CN206
Ducted
Cooled
CN203
CN09
CT1
CN201 CN100 CN200
XS8 XP8
XS7 XP7
XS9 XP9
Mini
L-PRO
L
FIELD SIDE
BLACK
FROM N
RT3
R
ORANGE
RED
WHITE
BLUE
YELLOW
RT4
BLACK OUT DOOR 1
UNIT
KM1
Split
ORANGE A1 A2
XT5 RED 1 2
WHITE
RXV/RXH-D+DCYP - R-22
WHITE 3 4
BLUE BLUE 5 6
Typical Wiring Diagram - RXH-D & DCYP
JUNCTION BOX
21 22
WHITE
WHITE
RED
Y/G
Condensing
Y/G FAN
UP
CODE PARTNAME
BLUE
BLACK
COMP COMPRESSOR
RED YELLOW W(T3) FAN3,FAN4 OUTDOORFAN
WHITE
CAP3,CAP4 FANCAPACITOR
V(T2)
UNIT SIDE
N
FH
FM
FL
E
N
FH
FM
FL
E
25
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Dimensional Data
OUTDOOR UNITS - VERTICAL DISCHARGE
MODELS: RXV- 020 & 025
Model: RXV-020 to 025 23
[584]
2
[50]
2
[484]
19.1
23
4
[50]
2
0.7
[19] 23 23
[584] [584]
[20]
.8
3
[813]
[835]
32.9
32
2 SUCTION
ACCESS
[22]
0.9
4 [51]
LEGEND
1. CONDENSER FAN
2. COMPRESSOR
3. CONTROL PANEL
[737]
[637]
25.1
4. CONDENSER COIL
29
0.75
2
[19]
1.8
[45]
29 29
0.79
[737] [736]
[20]
3
[813]
[835]
32.9
32
SUCTION ACCESS
2
[22]
0.9
ACCESS
26
SKM Air Cooled Condensing Units
[13]
0.5
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems 5.6
[141]
22.1
[560]
Dimensional Data
[346]
[324]
[371]
13.6
12.8
14.6
OUTDOOR UNITS - SIDE DISCHARGE
ALLDIMENSIONSAREININCHES[mm]
35.2
[895]
[694]
27.4
[862]
33.9
[13]
0.5
5.6 22.1
[141] [560]
[13]
0.5
5.6 24.1
[346]
[324]
[371]
13.6
12.8
14.6
[141] [608]
ALLDIMENSIONSAREININCHES[mm]
[335]
[313]
[360]
13.2
12.3
14.2
ALLDIMENSIONSAREININCHES[mm]
35.2
[895]
[13]
0.5
[966]
38
[1167]
46
5.6 24.1
[141] [608]
[335]
[313]
[360]
13.2
12.3
14.2
7.1 24.6
[181] [624]
ALLDIMENSIONSAREININCHES[mm]
[370]
[340]
[390]
14.6
13.4
15.4
[378]
[354]
[414]
14.9
13.9
16.3
5.9 23.2
ALL DIMENSIONS AREIN INCHES[MM]
[150] [590]
ALL DIMENSIONSAREININCHES[mm]
27
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Dimensional Data
4 4
1 1
L
L
K
K
TERMINAL TERMINAL
CO NNECTION CO NNECTI O
N
4 - 5 /8 [1 6 ]
M T G .H O L ES
2 3 W IT H R U BB ER 2 3
M
G R O M M E TS
LE G EN D
L
1 IN S U LA T E D R .A.P LE NU M
2 SU PPL Y FA N E 1 G E
3 FA N M O T O R [25]
[25]
4 C OO L IN G C OI L
1
L IQ U I D
L IQ U ID
5 ACC ESS PA N E L 6
6 FI L TE R
6
J
K L M
D x A
M O D EL
F
F
D IM EN S IO N S F O R
DCYP D C YP -X P K I NC H LM M I N CH MM M IN C H MM
UNIT DIMENSIONS FOR
MODEL 06 INCH MM INCH MM INCH MM FILTER
08
3R / 4 R 2 2 .0 2 561 2 7 .68 703 1. 8 2 46
REMOVAL
06 12
08
3R1/54R 22.02 561 27.68 703 1.82 46 SU C T IO N SUC T IO N
12 F IL T E R
15
10
R EM O V A L 5
18
3R / 4 R 2 6 .1 4 664 2 9 .93 760 1. 8 2 46 R EA R R E T U R N -O PT IO NA L
10 21 F R E E R ET U R N - S T A ND A R D
24 ( DU C T E D )
18
3R / 4R 26.14 664 29.93 760 1.82 46
21
24
CO NN E CT IO N SI Z ES
M O DE L A B C D E F G J I H N LIQU ID SUCT ION
D CY P- X P 3R 4R 3R 4R
INCH M M I N CH M M I N CH M M IN C H MM IN C H MM IN C H M M IN C H M M I N CH MM IN C H M M I N CH MM IN C H M M I NC HCONNECTION
MM SIZES
IN C H M M I NC H M M I N CH MM
MODEL A B C D E F G J I H N LIQUID SUCTION
DCYP 06 23 584 33 838 2 1. 5 546 12 30 5 1 2 .8 7 327 15 381 1 4 .8 376 8.22 3R1 0 5 / 8 4R
209 9 .1 3
16 2 32 - - 6 .9 3 3R
176 3/8 4R1 0 3 /8 5 /8 16
INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM INCH MM
08 27 686 37 940 2 5. 5 647 12 30 5 1 2 .8 7 327 15 381 14.8 376 8.22 209 9 .1 3 2 32 - - 8 .9 4 227 3/8 10 3 /8 10 5/8 16 5 /8 16
06 23 584 33 838 21.5 546 12 305 12.87 327 15 381 14.8 376 8.22 209 9.13 232 - - 6.93 176 3/8 10 3/8 10 5/8 16 5/8 16
10 27 686 37 940 2 5. 5 648 1 4 .5 36 8 1 2 .9 1 328 1 8. 0 7 459 17 432 1 0 .3 4 263 9 .1 3 2 32 - - 8 .9 4 227 3/8 10 3 /8 10 5/8 16 5 /8 16
08 27 686 37 940 25.5 647 12 305 12.87 327 15 381 14.8 376 8.22 209 9.13 232 - - 8.94 227 3/8 10 3/8 10 5/8 16 5/8 16
12 39 991 49 1 24 5 3 7. 5 953 12 30 5 1 2 .8 7 327 15 381 1 4. 8 376 8.22 209 9 .1 3 2 32 8 .8 7 225 5. 9 151 3/8 10 3 /8 10 5/8 16 7 /8 22
10 27 686 37 940 25.5 648 14.5 368 12.91 328 18.07 459 17 432 10.34 263 9.13 232 - - 8.94 227 3/8 10 3/8 10 5/8 16 5/8 16
15 45 1 14 3 55 1 39 7 4 3. 5 1 10 5 12 305 1 2 .8 7 327 15 381 1 4. 8 376 8.22 209 9 .1 3 2 32 1 1 .9 301 7. 4 189 1/2 13 1 /2 13 7/8 22 7 /8 22
12 39 1 8 991 49 1245 37.5 953 412 305 112.87 327 15 381 14.8 376 8.22 4 3209 9.13 2 6232 8.87 225 5.9 151 3/8 10 3/8 10 5/8 16 7/8 22 1
45 1 14 3 55 1 39 7 3. 5 1 10 5 4 .5 368 1 2 .9 1 328 1 8 .0 7 459 17 2 1 0 .3 4 3 9 .1 3 2 3 2 1 1 .9 301 7. 4 189 1/2 13 1 /2 13 1 1/8 29 1 /8 29
15 45 2 1 1143 555
1 11397
29 5 43.5
61 11105
54 9 412
9. 5 305
1 25 7 112.87
4 .5 3 6327
8 1 215
.9 1 3381
2 8 1 814.8
.0 7 4 376
59 18.22
7 209
43 2 1 0 9.13
.3 4 232
26 3 9 11.9
.1 3 2 3301
2 1 4 .7.4
87 3 7189
8 8 .91/2
3 2 2 13
7 1 / 1/2
2 1 313 7/8
1 /2 1 322 1 1 7/8
/8 2 922 1 1 /8 29
18 45 2 4 1143 555
7 11397
44 8 43.5
67 11105
70 2 514.5 368
5. 5 1 41 0 112.91
4 .5 3 6328
8 118.07
2 .9 1 3459 17
2 8 1 8 .0 7 4 432
59 10.34
17 263
43 2 1 0 9.13
.3 4 232
26 3 9 11.9
.1 3 2 3301
2 1 4 .7.4
87 3 7189
8 4 3 2 6 13
1 0. 1/2 5 1 / 1/2
2 1 313 11 1/8 2 929 1 1 /8
/2 1/8 1 329 1 11/ 8 29
24 57 1448 67 1702 55.5 1410 14.5 368 12.91 328 18.07 459 17 432 10.34 263 9.13 232 16.9 430 11.93 303 1/2 13 1/2 13 1 1/8 29 1 1/8 29
28
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
OUTDOOR UNIT CLEARANCE & SPACING
Outdoor Unit Clearance & Spacing
No obstacle POWER
SOURCE
CONTROL CIRCUIT
AIR OUT
30 00 mm
CONTROL
AIR IN PANEL
SPACING FOR
SERVICE
LIQUID
SUCTION SPACING FOR AIR
FLOW
AIR IN
AIR IN
[35 6]
14
[7 62 ]
SPACING FOR
30
SERVICE
[35 6]
14
14
[76 2]
[76 2]
30
30
30 45 30
[7 62 ] [11 43 ] [7 62 ]
29
SKM Air Cooled Condensing Units
RXV/RXH-D+DCYP - R-22
Outdoor Unit
OUT Clearance
DOOR & Spacing
UNIT CLEARENCE & SPACING
20
[ 50
8]
1
[ 30 2
5]
12 ]
5
[ 30
48 9]
1
[ 12
20
[ 50
8]
1
[ 30 2
5]
12 ]
5
[30
48 9]
1
[ 12
MULTIPLEUNIT:-
MULTIPLEUNIT:-
23.6
[600]
30
SKM Air Cooled Condensing Units
SKM Ducted Mini -Split
RXV/RXH-D+DCYP R-22Systems
GUIDE SPECIFICATIONS
GENERAL FEATURES CONTROL PANEL
Ducted mini split Air Conditioning system shall composed Condensing unit shall be provided with a control panel
of a compact design indoor fan coil unit and floor or Rooftop enclosure comprising all electrical control devices except
mounted outside air cooled condensing unit, rated with AHRI for the field supplied room thermostat and shall include the
standards 210/240. following components as minimum:
Compressor and condenser fan motor contactor
The condensing unit shall be composed of compressor, Anti recycling time delay relay
condenser, coil, condenser fan and motor. Terminal for external connections.
For top discharge air delivery, the fan shall be equipped with MOTOR
statically and dynamically balanced alloy blades, and inherent Motor shall be single phase, 3 speed permanent split capacitor
corrosion resistant shaft. Complete fan assembly is mounted type, suitable for 220-240V/1Ph/50-60Hz.Highly efficient with
downward on the strong and acrylic coated fan guard. integral thermal protection. Motor shall have high power factor
and shall be with permanent lubricated sleeve bearings.
Condenser Motor shall be single phase or three phase
induction motor, Totally Enclosed Air over (TEAO), with
inherent thermal protection.
METERING DEVICE
Indoor unit shall be equipped with refrigerant flow control
device.
CASING
The unit casing shall be made of zinc coated galvanized steel
sheets conforming to JIS-G3302 and ASTM-A525 that shall
be phospatized and then electro statically dry powder coated
of approx 60 microns to provide an extremely tough, scratch
resistance, and excellent anti corrosive protection
31
SKM Ducted MiniSpare
SplitPartsSystems
Division
Sharjah, United Arab Emirates
Tel: +971 6 5347347
Fax: +971 6 5349292
Email: spareparts@skm.ae
HEAD OFFICE
P.O Box: 6004 Service Centre
Sharjah, United Arab Emirates Sharjah, United Arab Emirates
Tel: +971 6 5347347 Tel: +971 6 5347347
Fax: +971 6 5349292 Fax: +971 6 5349292
Email: sales@skm.ae Email: aftersales@skm.ae
REGIONAL OFFICES
UAE Saudi Arabia
Abu Dhabi P.O Box: 27788 AL Messila HVAC Equipment Factory
Abu Dhabi, United Arab Emirates (Part of SKM A/C factory in
Saudi Arabia)
Tel: +971 2 6445223 Saudi Arabia, Eastern provenance
Fax: +971 2 6445145 AD Dammam
Email: abudhabisales@skm.ae 2nd industrial city
Al Ain Al Ain, United Arab Emirates Abqiq main road Hail Street
Tel: +966 3 8123332 / 4 / 5
Tel: +971 3 7619921 Fax: +966 3 8123337 / +966 3 8123092
Fax: +971 3 7619941
Email: alainsales@skm.ae Egypt
Dubai P.O Box: 98822 9 Mosadak Street,
3rd floor, Dokki, Giza, Egypt
Dubai, United Arab Emirates Tel: +20 2 37619617 / +20 2 37621974
Tel: +971 4 2940900 Fax: +20 2 37621973
Fax: +971 4 2940029 Email: egyptsales@skm.ae
Email: dubaisales@skm.ae
Algeria
Kuwait Aissat Idir ( EX-ENMA) City
P.O Box: 1215-PC 15463 Bldg1, Flat 2, Dar El Beida Algiers,
Dasman, Kuwait Algeria
Tel: +965 2 2492200 Tel: +213 21 508197
Fax: +965 2 2494400 Fax: +213 21 508197
Email: kuwaitsales@skm.ae Email: algeriasales@skm.ae
DISTRIBUTORS
Saudi Arabia Qatar
Mannai Trading Co. WLL
Dammam P.O Box: 76
Fawaz Ref. & Air Conditioning Co. Doha, Qatar
P.O Box: 1189
Al Khobar, Saudi Arabia Tel: +974 4 4558787 / +974 4 4558788
Tel: +966 13 8598 666 Fax: +974 4 4558781
Fax: +966 13 8598 520 Email: dohasales@skm.ae
Email: abarbarawi@fawaz.com HVAC@mannai.com.qa
Jeddah
Fawaz Ref. & Air Conditioning Co. Iraq
P.O Box: 13218 Erbil Bagdad Basra
Jeddah, Saudi Arabia Tel: +964 7507441111
Tel: +966 12 667 5704 +964 7711117776
Fax: +966 12 6608316 +965 99608916
Email: jrabdu@fawaz.com
Email: info@alrawabitt.com
Riyadh
Fawaz Ref. & Air Conditioning Co. Kuwait (for Unitary Products Only)
P.O Box: 85123 House of Mode
Riyadh, Saudi Arabia P.O Box: 1215-PC 15463
Tel: +966 11 4794 499 Dasman, Kuwait
Fax: +966 11 4785 354 Tel: +965 2 2492200
Email: szaidan@fawaz.com Fax: +965 2 2494400
Email: kuwaitsales@skm.ae
Jordan
Ideal A/C Systems Co. L.L.C
Al Gardenz Street, Building 111, Oman
Al Bakri Complex Al Bunya'an Trading LLC
P.O Box 5502 Amman, Jordan 11953 P.O Box 3618, Ruwi 112
Tel: +962 6 5538640 Sultanate of Oman
Fax: +962 6 5538641 Phone: +968 24504436 / 24504483
Email: tariq@idealac.com Fax: +968 24504469
Email: info@albunyaanoman.com
32 068/2015
visit us at www.skm.ae Supersedes Bulletin # 068/2014A