Академический Документы
Профессиональный Документы
Культура Документы
Direction:
1. There is only one correct answer.
A B
2. You will be awarded 4 Marks if you have darkened only the bubble
corresponding to the correct answer and zero mark if no bubble is
3g 2g 3
darkened. In all other cases, minus one ( 1) mark will be awarded. (1) (2) (3) mg (4) g
2 3 2 2
Best of Luck for Your Competitive Exams 6. Four identical thin rods each of mass M and length ,
form a square frame. Moment of inertia of this frame
about an axis through the centre of the square and
1. A rigid body is rotating about an axis. To stop the perpendicular to its plane is :-
rotation, we have to apply :- 1 4 2 13 2
(1) pressure (2) force (1) M2 (2) M2 (3) M2 (4) M
(3) momentum (4) torque 3 3 3 3
2. The angular momentum of body remains conserve if 7. A thin circular ring of mass M and radius R is rotating in a
(1) applied force on body is zero. horizontal plane about an axis vertical to its plane with a
(2) applied torque on body is zero. constant angular velocity . If two objects each of mass m
(3) applied force on body is constant. be attached gently to the opposite ends of a diameter of
(4) applied torque on body is constant. the ring, the ring will then rotate with an angular velocity
3. A circular disc is to be made by using iron and aluminium M (M 2m)
so that it acquired maximum moment of inertia about (1) (2)
Mm M 2m
geometrical axis. It is possible with:
M (M 2m)
(1) Aluminium at interior and iron surrounded to it. (3) (4)
(2) Iron at interior and aluminium surrounded to it. M 2m M
(3) Using iron and aluminium layers in alternate order. 8. The instantaneous angular position of a point on a
(4) Sheet of iron is used at both external surface rotating wheel is given by the equation
and aluminium sheet as internal layer. (t) = 2t3 6t2 . The torque on the wheel becomes zero
at :-
3. Two bodies have their moments of inertia I and 2I
respectively about their axis of rotation. If their kinetic (1) t = 1s (2) t = 0.5 s
energies of rotation are equal, their angular momentum
(3) t = 0.25 s (4) t = 2s
will be in the ratio :
9. The moment of inertia of a thin uniform rod of mass M
(1) 1 : 2 (2) 2 : 1 (3) 1 : 2 (4) 2 : 1 and length L about an axis passing through its midpoint
4. A horizontal platform is rotating with uniform angular and perpendicular to its length is I0. Its moment of inertia
velocity around the vertical axis passing through its centre. about an axis passing through one of its ends and
At some instant of time a viscous fluid of mass m is perpendicular to its length is
dropped at the centre and is allowed to spread out and
(1) I0 + ML2/2 (2) I0 + ML2/4
finally fall on ground. The angular velocity during this
period : (3) I0 + 2ML2 (4) I0 + ML2
(1) decreases continuously 10. A small mass attached to a string rotates on a frictionless
(2) decreases initially and increases again table top as shown. If the tension in the string is increased
(3) remains unaltered by pulling the string causing the radius of the circular
(4) Increases continuously motion to decrease by a factor of 2, the kinetic energy of
the mass will :-
5. A uniform rod AB of length and mass m is free to rotate
about A. The rod is released from rest in the horizontal r
position. Given that the moment of inertia of the rod
m 2
about A is , the initial angular acceleration of the (1) Decrease by a factor of 2
3
(2) Remain constant
rod will be :
(3) Increase by a factor of 2
(4) Increase by a factor of 4
2 2
(A) R (B) R
15 5
3 3
(C) R (D) R
15 15