Академический Документы
Профессиональный Документы
Культура Документы
8. Which nut is used as locking device? 18. The plain hex nut part number is ___.
a. Plain hex nut a. An 315
b. Light hex nut b. An 350
c. Plain check nut c. An 320
d. Wing nut
19. The light hex nut part number is ___.
a. An 345
b. An 350
c. An 320
9. A nut used where the desired tightness can be
obtained with fingers? 20. Which stud used to replace plain stud when
a. Plain hex nut tapped hole is damaged?
b. Light hex nut a. Plain stud
c. Plain check nut b. Shouldered stud
d. Wing nut c. Waisted stud
d. Stepped stud
10. MTCS
1 | Page
21. ________ converts an analog input to a digital b. Flash type
output. c. Successive approximation type
a. Flash converter d. Binary weighted type
b. Bipolar converter
c. ADC 24. The advantage of an r-2r ladder DAC is that:
d. DAC a. It uses less resistors overall
b. It uses a smaller number of analogue
22. A DAC can produce 256 different output switches
voltages. This DAC has a resolution of: c. It avoids having a large number of different
a. 8 bits value resistors.
b. 128 bits
c. 256 bits. 25. In a binary weighted DAC the voltage gain for
d. 8 bytes each digital input is determined by:
a. A variable slope ramp
23. Which one of the following types of ADC is the b. A variable reference voltage
fastest? c. Resistors having different values.
a. Digital ramp type
2 | Page