Академический Документы
Профессиональный Документы
Культура Документы
Note:
Answer all questions.
For the questions in Part A you are required to show all your calculations.
For every question in Part B you are required to choose all responses which apply, without
showing your calculations. For example: Q12 (A), Q13 (A, B), etc.
1
b) In an oil and gas reservoir, the gas-oil contact is located at 8650 ft. The pressure at the oil-
water contact is 4192psi. Calculate the pressure at 8700ft, assuming that the gradient in the oil
zone of the reservoir can be estimated from Figure 1.
For each of the following questions choose all responses which apply. Each question is worth 5%,
with a total of 40% available.
Q1. A reservoir has an area of 100m2, a thickness of 10m and a porosity of 0.2. The pore volume
of this reservoir is:
(A) 2x103m3
(B) 200m3
(C) 200m2
(D) 20000m3
(E) None of the above
Q2. The oil initially in place in a reservoir is 840x 106 stb. It is estimated that 640 x106stb oil can
be produced from this reservoir. Already 240 x106stb oil have been produced from this
reservoir. What are the current reserves in this reservoir?
2
(A) 640 x106stb
(B) 240x 106stb
(C) 840x 106stb
(D) 400 x106stb
(E) None of the above
Q3. A reservoir contains a fluid which is has an API density of 38oAPI. The following
statement(s) is(are) correct:
(A) This is a wet gas reservoir
(B) This is a volatile oil reservoir
(C) The gas-oil ratio (GOR) for this reservoir is expected to be lower than 2500scf/stb
(D) This is a dry gas reservoir
(E) This is a black oil reservoir
Q4. An oil reservoir has an original oil in place evaluated at STOIIP=3400 MMstb (MMstb
represents million stock tank barrel) and a recovery factor of 42%. The reservoir has already
produced 180 MMstb. The reserves in this reservoir are:
(A) 1428 MMstb
(B) 1248 MMstb
(C) 1428 x106stb
(D) 1248 x108stb
(E) None of the above
Q5. An oil reservoir has an area of 240m2, a thickness of 40m, an average porosity of 0.2 and a
connate water saturation of 0.22. The hydrocarbon pore volume of this reservoir is:
(A) 485.76 x10-9 km3
(B) 485.76 m3
(C) 149.76 x10-8km3
(D) 1497.6m3
(E) None of the above
3
Q7. An oil has a specific gravity (SG) of 0.65. Its density in oAPI oil is approximately:
(A) 86.19oAPI
(B) 68.19oAPI
(C) 71.84oAPI
(D) 42.84oAPI
(E) None of the above
Q8. The pressure at the gas-water contact in a gas reservoir is 4100psi. There is a 720ft continuous
gas column in this reservoir. Typical pressure gradients apply in the reservoir. What is the
pressure at the top of the reservoir?
(A) 4042.4
(B) 2021.2psi
(C) 404.2psi
(D) 4042.4psi
(E) None of the above
- THE END -