Академический Документы
Профессиональный Документы
Культура Документы
CA =Corrosion allowance 0 mm
Note: The thickness required was less than the Code Minimum,
therefore the Code Minimum value of 1.5000 mm. per UG-16 will be
used
Wall Thickness Calculation Check
CONICAL BOTTOM CIR
Static (Water)head height 2131 mm Static (Water)head heig
Note: The thickness required was less than the Code Minimum, therefore the Note: The thickness req
Code Minimum value of 1.5000 mm. per UG-16 will be used therefore the Code Mini
used
CIRCULAR FLAT HEAD
atic (Water)head height 2131 mm
= Factor 0.2
= diameter 200 mm
ote: The thickness required was less than the Code Minimum,
erefore the Code Minimum value of 1.5000 mm. per UG-16 will be
sed
Half pipe Jacket Design Check per Non
r =Inside radius of
jacket defined in Fig. EE- 40.5 mm
Tj = 0.552756
Tj*1.414 = 5.656 mm
gn Check per NonMandatory Appendix EE
STEP 1: The required thickness of the shell due to internal pressure is
calculated from eq. (1) of UG-27 a
t= 0.1656072467
Design is adequate
DESIGN NOTES:
1) The minimum thickness permitted for shells and heads, after forming and regardless of pro
ng and regardless of product form and material, shall be 1/16 in. (1.5 mm) exclusive of any corrosion allowance
any corrosion allowance