Академический Документы
Профессиональный Документы
Культура Документы
PY11258-UN-24JAN11
A - Hand Throttle
B - Horn Switch
C - Light Switch
F - Mobile Charger
A - Key Switch
B - Steering Wheel
C - Brake Pedals
F - Clutch Pedal
PY11354-UN-07JAN11
PY11355-UN-07JAN11
PY11356-UN-07JAN11
PY11260-UN-24JAN11
PY11261-UN-24JAN11
A - Gearshift Lever
PY11263-UN-24JAN11
PY11264-UN-24JAN11
A - PTO Lever
NOTE: Either Dual PTO or Reverse PTO will be provided. Both features are not available on a
single tractor.
PY17807-UN-26FEB13
PTO Engaged
A Illuminates when the rear PTO lever is engaged.
Indicator
Displays Hour Meter, Vehicle Speed in km/h, Job Timer, Service Icon,
D Hour Meter
and volt meter.
Wheel SlipIf
E Illuminates when wheel slippage occurs.
Equipped
Charging
Initially indicator illuminates when key switch brought to run position
F System
and it goes off when key switch brought to engine start position.
Indicator
Air Restriction Illuminates when air cleaner element is clogged (clean or replace
G
Indicator element). If necessary, have the John Deere dealer diagnose vehicle.
Engine Oil
Oil pressure indicator lights if engine oil pressure is low. Indicator lights
H Pressure
when key is turned to RUN position and go out when engine starts.
Indicator
Clutch Pedal Illuminates when clutch has been engaged during starting or clutch
I
Riding pedal is in pressed condition for long duration during vehicle running.
Right Turn Illuminates when turn signal switch is switched to the right-hand side. It
L
Indicator also illuminates when hazard switch activated.
Left Turn Illuminates when turn signal switch is switched to the left-hand side. It
N
Indicator also illuminates when hazard switch activated.
Indicates amount of fuel remaining in the fuel tank. When the needle
O Fuel Gauge
comes to a red zone operator need to fill the fuel tank.
High Beam
P Illuminates when the headlights are switched on high beam mode.
Indicator
PY11265-UN-24JAN11
Apart from these 4 data information display boards also display the battery voltage data
also.
A - Turn Right
C - LCD Display
D - Transmission Neutral 1
F - Telematics (Amber)
K - Clutch Override1
L - Rockshaft1
M - PTO
NOTE: Only listed indicators enable during the tractor operations, rest all indicators always
disabled which is available on the instrument panel.
PY25115-UN-28SEP15
LCD Display
PY25299-UN-18NOV15
Press roll mode switch (A) to go from one menu to another menu in the information display
board and press and hold trip switch (A) in any of the required menu to set its value to zero
at LCD display.
1. Engine Hour
2. Job Timer
3. Acre Trip
4. Acre Cumulative
5. Speed
6. Service Timer
7. Battery Voltage
Engine Hour
PY27404-UN-24NOV15
Hour meter is the first menu to display. Steady hourglass indicates that the engine is OFF.
Blinking hourglass indicates that Engine is ON and has started accumulating /counting the
hours.
Job Timer
PY27405-UN-24NOV15
Pressing the roll mode switch two times the display shows the job timer menu. Job timer is
the digital time counter which can be used to calculate specific time of the job while renting
To reset the job timer press and hold while on the job timer menu and hold the switch until
counter sets to zero value.
IMPORTANT: To reset the job timer it is necessary to keep key switch ON position.
Acre Trip
PY27406-UN-24NOV15
Pressing the roll mode switch three times the display shows the acre trip menu. Acre trip is
use for in area for calculate the area of particular field. Acreage meter is a unique tool to
measure the field area in acres.
IMPORTANT: Before starting the acre trip counter, ensure that key switch is in ON position
and telematics device acquired the GPS signal. Refer the trouble shooting section for
checking GPS signal of the telematics device.
3. Press and hold the switch until acre trip starts blinking. NOTE: To stop measurement,
again press and hold until acre trip stops blinking.
4. Tractor drive through the field in desired area. NOTE: To stop measurement, again
press and hold until acre trip stops blinking.
Acre cumulative
PY27407-UN-24NOV15
Pressing the roll mode switch four times the display shows the Acre cumulative menu. Acre
trip is use for total number of acers counts till date.
Speed
PY27408-UN-24NOV15
Pressing the roll mode switch five times the display shows the speed menu. Speed menu
shows the current speed of the tractor.
NOTE: - The speed calculated is based on GPS measurement. When GPS signal is not found
then shows NO GPS.
Service Timer
PY27409-UN-24NOV15
Pressing the roll mode switch six times the display shows the Service timer menu. Service
times shows the service due time in hours.
Battery Voltage
PY27410-UN-24NOV15
Pressing the roll mode switch seven times the display shows the Service timer menu.
Indicates the battery voltage at the given instance.
Lights
PY27518-UN-19JAN16
A - Lights Off
B - Position Lights
C Turns on dim headlights, tail lights, and warning lights. Turn switch to this position before
meeting other vehicles.
D Turns on bright headlights, tail lights, and warning lights. For highway driving during
night time
Use Headlights
PY11360-UN-07JAN11
PY27519-UN-19JAN16
A - Headlights
Dual-beam headlights (A) are switched on by either Dim Headlights (B), bright Headlight (C),
switch positions..
Keep headlights adjusted properly. (See Adjust Headlights in Service section). High Beam
Indicator
PY27508-UN-05JAN16
High beam indicator (A) should glow when light switch is turned to Bright Headlight
position or Flood Light position. Bright headlights, tail lights, flood light and warning lights
should be on.