Академический Документы
Профессиональный Документы
Культура Документы
UNIT-1
OBJECTIVE QUESTIONS
7) According to the United states Geological Survey,water having less than 1000ml/l of total
solids is
a) Fresh water
b) Slightly saline
c)Moderately saline
d) Brine water
16)The leakage of water from the ground surrounding the sewer called
a)Run off
b)Sullage
c)Infiltration
d)Exfiltration
17) The leakage of sewage from the sewer into the ground c alled
a)Run off
b)Sullage
c)Infiltration
d)Exfiltration
b)oxygen
c)hydrogen
d)nitrogen
(a) fungus
(b) bacteria
(c) worms
(d) animals
23) Pick from the following one chemical used to disinfect water
(a) Chlorine
(c) worms
(d) Coal
(a) Chlorine
(b) Nitrogen
c) Phosphorous
(d) silica
ANSWERS
1 2 3 4 5 6 7 8 9 10 11 12 13
d a c a d b a c a a a a b
14 15 16 17 18 19 20 21 22 23 24 25
d a c d a a a a c a b b
UNIT-II
SEWER DESIGN
OBJECTIVE QUESTIONS
2)The type of valve ,which is provided on the suction pipe in a tube well is
a)air relief valve
b)reflux valve
c)pressure relief valve
d)sluice valve
4)The design discharge for the combined sewer system shall be taken as
a)equal to rainfall
b)rainfall+DWF
c)rainfall+2DWF
d)rainfall+6DWF
8) The minimum dissolved oxygen which should always be present in water in order to save the
aquatic
life is
a) 1 ppm
b) 4ppm
c) 10ppm
d) 40ppm
14) The correct ratio of the diameter of a circular sewer to the side of a hydraulically equivalent
square
section of a sewer is
a)1
b)1.095
c)0.9
d)0.925
15)Which traps are constructed outside the building to carry waste water discharge?
PREPARED BY: SUGANYA.K AP/CIVIL Page 7
OBJECTIVE QUESTIONS-EE-II/CE6605
a) P trap
b)v trap
c)s trap
d) Gully Trap
16) The work of designing is simplified by the use of nomograms which have been prepared on
the basis of some
a) Stokes law
b)rational formulae
c) empirical formulae
d)none of these
17) Self cleansing velocity is develpoed in the sewer, when the flow is
a)minimum
b)maximum
c)zero
d)high velocity
21)Which is determined by considering the particle size and specific weight of the suspended
solids in sewage?
a)All the above
b)Scouring velocity
c)non-scouring velocity
PREPARED BY: SUGANYA.K AP/CIVIL Page 8
OBJECTIVE QUESTIONS-EE-II/CE6605
a)pipe material,
c) external loads
25) Inverted siphon may consist of one, two or more pipes depending upon the
c)Velocity flow
d)Head
ANSWERS
1 2 3 4 5 6 7 8 9 10 11 12 13
a d c b b b a b c d c b a
14 15 16 17 18 19 20 21 22 23 24 25
b d c a a b c d a d d a
UNIT-III
OBJECTIVE QUESTIOS:
4)If in a sedimentation tank,volume of tank is 20m*100m*3m and flow rate is 600m3/day then
detention
time will be
a)4hr
b)6hr
c)3hr
d)2hr
6)A skimming tank is a Process of removing so arranged that the floating matter
a)oil,
b)fat,
c)grease
d)All of these
7)The overflow rate represents the hydraulic loading per unit surface area of tank in unit time
expressed as
a)m3/m2/day
b)cm
c)mm
d)none of the above
8)The growth of huge amounts of algae and other aquatic plants leading to the deterioration of
the water quality is called
a)screening
b)Sedimentation
c) Eutrophication
d)Primary treatment
16)A comminutor is a device that is designed to shred rags and debris into
a)settlable particles
b)minute particles
c)small pieces
d)None of these
PREPARED BY: SUGANYA.K AP/CIVIL Page 12
OBJECTIVE QUESTIONS-EE-II/CE6605
19) The both achieved by using two tanks, intermittently one after another
a)Flow balancing and self-neutralization
b)Flow and self-neutralization
c)Self-neutralization
d)settling tanks
21)The main difference between greywater and sewage (or blackwater) is the
a) organic loading
b)inorganic loading
c) Wier loading
d) all the above
25) Which unit is sometimes provided in the form of facultative aerated lagoon.
a) Equalization
b)sedimentation
c)settling
d)Grit chambers
ANSWERS
1 2 3 4 5 6 7 8 9 10 11 12 13
a b a a b d a c d a a d a
14 15 16 17 18 19 20 21 22 23 24 25
a b c d b a a a b d b a
UNIT-IV
OBJECTIVEQESTIONS
1. Biogas is produced by
a) Aerobic digestion
b) Anaerobic digestion
c) Lagooning
d) Aerobic bacteria
8. Algae which absorbs CO2 & gives out oxygen is thus very helpful process for
a) Self purification process.
b) Eutrophication
c) Sludge dewatering
d) Biogas
c) Primary treatmrent
d) Secondary treatment
11.Incineration at a process of
a)Burning of sludge
b) Self purification process
c) Maintain pH
d) Air drying
c) Sewage Farming
d) Sewage thickening
18.Odorous sulfur compounds are formed and solids settle to the bottom, forming a
a) Sludge
b) Biomass
c) Sewage
d) Biogas
23.Mention the odor gases are emitted from the process of sludge digestion
a)methane,
b ) carbon dioxide,
PREPARED BY: SUGANYA.K AP/CIVIL Page 17
OBJECTIVE QUESTIONS-EE-II/CE6605
c) hydrogen sulphide
d)All the above
Answers
1 2 3 4 5 6 7 8 9 10 11 12 13
b a d d d b a a a c a a c
14 15 16 17 18 19 20 21 22 23 24 25
a a a d a d a a d d a b