Академический Документы
Профессиональный Документы
Культура Документы
pocket guide
A4900 Vibrio M
pocket guide
Basic information 4
Switch on/off 5
Basic control 6
Basic menu 7
Measurement screens 8-9
Saving data from measurement screen 10
Light 11
Memory - Route measurement 12-13
Setup 14
Volume 15
Proximity measurements 16-17
2 3
Basic Information Switch ON/OFF
Top panel
Micro USB for data transfer
IR non-contact
temperature sensor
Phones output
LED stroboscope
Buttons
Arrow buttons
Press the Enter button
toswitch on the device
Enter button
Firmware version
Batteries Serial number
Filters
Sensor sensitivity
4 5
Basic control Basic menu
Arrow buttons 1. To open the Menu press
the Enter button (on any
>> switch between the measurement modes measurement screen)
>> select the right or left item from the menu at the bottom
>> move between items (up/down) in menu
Enter button
>> switches the instrument on/off
>> confirmes the selection
>> selects the middle item from the menu at the bottom 2. Then press the left Arrow
>> opens the menu button to open the Menu
Volume Time
>> Light
to switch on the torch or the stroboscope
Press the left Press the right
(see page 11)
Arrow button Arrow button
to select this to select this >> Memory
option (ESC) option (REP) for route measurement
(see page 12 - 13)
Arrow buttons >> Setup
setup of speed, alarms, units, time, etc.
(see page 14)
>> Volume
for headphones volume setup
(see page 15)
>> -Esc-
Enter button back to the measurement screen
6 7
Measurement screens i Use the arrow buttons to move
between the measurement screens
8 9
Saving data from measurement screen Light
(*available for the Vibrio M only, FASIT screen cannot be saved)
Torch
Used memory The instrument can be used as
atorch in this mode
Press the Enter button [SAVE] Press any button to switch off the
Torch mode
Strobo
Select the address (1-250)
with the Arrow buttons If the speed is found, the stroboscope
frequency is set automatically
Speed Auto
Manual
Off
14 15
Proximity option Proximity measurements
(*available for the Vibrio MP only) (*available for the Vibrio MP only)
Speed
i The A4900 Vibrio MP needs to be i Use the arrow keys to move between
connected to a proximity sensor for the measurement screens
proximity measurement!
(The default sensor sensitivity is set to
7.87mV/m, 200 mV/mil)
Speed can be detected automatically
or set manually
16 17
Notes: Notes:
18 19
Master the language of your machinery.
Adash 2016