Академический Документы
Профессиональный Документы
Культура Документы
Auger Anchor
Installation Use in: 3/8" to 1" thick wallboard
Fast and easy installation
1. Place #2 Phillips screwdriver into recess
High holding power Use with: #2 or #3 Phillips screwdriver and #8
of Auger Anchor.
Screw is removable sheet metal or dry wall screw
2. Press into gypsum wallboard while
turning the anchor clockwise. Nylon Auger Anchor is Made of: Nylon or Zinc
3. Place fixture in position over installed electrically nonconductive
Shear
Auger Anchor and insert screw with #2 Wallboar Tension
Load
Phillips screwdriver (#8 type A or AB screw Thickne Load (lbs.)
(lbs.)
is recommended). 3/8" 50 60
4. Tighten fixture in place ... threads of 1/2" 65 70
screw self-thread securely into the anchor 5/8" 80 100
(a minimum of 1" thread engagement is Zamac Part Number 20A-4X01 3/4" 85 100
recommended). Do not over-tighten. Note: The values listed above are ultimate load capacities represent
Nylon Part Number 20A-4X02 the point at which the wallboard failed and are therefore valid for the
zinc and the nylon auger anchor. Reduce by minimum safety factor of
4 or greater to determine the allowable working load.