Академический Документы
Профессиональный Документы
Культура Документы
Code : ES 191(EC)
List of Experiments:
1. Familiarization with passive and active electronic components such as Resistor, Inductor,
Capacitor, Diode, Transistor (BJT) etc.
2. Familiarization with equipment like DC power supply, multimeter, CRO, Function generator etc.
5. Study of Half wave rectifier with regulation efficiency and ripple factor.
List of Experiments:
2. Study of transfer characteristics and output characteristics of Junction Field Effect Transistor
(JFET).
3. Study of transfer characteristics and output characteristics of Metal Oxide Semiconductor Field
Effect Transistor (MOSFET).
4. Determination of input-offset voltage, input bias current and Slew rate of OPAMPs.
6. Study of different OPAMP circuits like Inverting and Non-inverting amplifier, Adder, Integrator,
Differentiator etc.
7. Study of Logic Gates and realization of Boolean functions using Logic Gates.
List of Experiments:
3. Study of ripple and regulation characteristics of full wave rectifier without and with
capacitor filter
5. Design a two-stage R-C coupled amplifier & study of its gain & Bandwidth.
8. Realization of current mirror & level shifter circuit using Operational Amplifiers.
9. Study of timer circuit using NE555 & configuration for monostable & astable
multivibrator.
11. Study of Switched Mode Power Supply & construction of a linear voltage regulator
using regulator IC chip.
14. Realization of a Phase Locked Loop using Voltage Controlled Oscillator (VCO).
Module 1:
4: Study of drain characteristics and transfer characteristics of a JFET and hence determine
the FET parameters (drain resistance, transconductance & amplification factor).
Module 2:
9. Find out the modification in Threshold voltage with continuous decreasing channel length
for n-Channel enhancement mode MOSFET. (Innovative).
5. To study LPF &HPF, band pass and reject filters using RC circuits.
6. To demonstrate how analog signals are sampled and how different sampling rates affect
the outputs.
7. To study sampling theorem for low pass signals and band pass signals .
1. Study of Ripple and Regulation characteristics of full wave rectifier with and without
capacitor filter.
3. Construction of two stage R-C coupled amplifier & study of its gain and Bandwidth.
6. Study of timer circuit using NE 555 and configuration of Mono-stable and Astable
Multivibrator.
10. Design of Combinational circuit for BCD to decimal conversion to drive 7-segment
display using Multiplexer.
12. Construction of simple Decoder & Multiplexer circuits using logic gates.
13. Construction of adder circuit using Shift register & Full adder.
4. Design a Full Adder using basic gates and verify its output
5. Design a Full Subtractor circuit using basic gates and verify its output.
13. Construction of adder circuit using Shift Register and full Adder. (Innovative)
List of Experiments:
5. Design of combinational circuit for BCD to decimal conversion to drive 7-segment display
using multiplexer.
13. Construction of adder circuit using Shift Register and full Adder.
Code: EC491
List of Experiments:
[At least THREE experiments from Module I and FOUR experiments from Module II]
Module I:
1. Plotting of Standing Wave Pattern along a transmission line when the line is open-
circuited, short-circuited and terminated by a resistive load at the load end.
Module II:
8. Beam width, gain and radiation pattern of a 3-element, 5-element and 7-element. Yagi-Uda
antenna - Comparative study.
List of Experiments:
List of Experiments:
19. Transfer block of N-bytes from source to destination in forward and reverse order.
20. Unpack a BCD number.
21. Pack two BCD numbers.
22. WAP to convert two BCD numbers in memory location to the equivalent HEX number.
23. WAP to find out the factorial of a given number.
24. WAP to interface 8255A with 8085 or 8086 microprocessor kit.
25. Study of 8251 microcontroller kit and Interfacing of keyboard with 8251 microcontroller
Code:EC-593
List of Experiments:
2. Determination of transfer function using block diagram reduction techniques through MATLAB
toolbox.
3. Determination of step and impulse response for 1st order & 2nd order system, evaluation of static
errors and static error coefficients &calculation of control system specifications for second order
system.
4. Determination of root locus using MATLAB control system toolbox for a given 2nd order transfer
function
5. Determination of Bode-plot using MATLAB control system toolbox for a given transfer function.
6. Determination of Nyquist Plot using MATLAB control system toolbox for a given transfer
function.
Code: EC691
List of Experiments:
1. Design, implementation and study of all the properties of 7-length and 15-length pn
sequences using shift register.
List of Experiments:
3. Study of VCO
4. Study of PLL
5. Design of V to I
6. Design of I to V convertor
Code: EC695A
List of Experiments:
Code: EC793A
List of Experiments:
1. Determination of phase and group velocities in a waveguide carrying TE10 Wave from
Dispersion diagram [ Plot].
6. Scattering matrix of a magic tee / E-plane tee / H-plane tee using waveguide test bench at
X-band.
List of Experiments:
3. Familiarity with EDA tools for VLSI design /FPGA based system design
11. Design of a 12 bit CPU with few instructions and implementation and
Validation on FPGA.
COMMUNICATION LABORATORY
Code:EI-794A
List of experiment
2. Study of Double Side Band Suppressed Carrier (DSB-SC) & Demodulation technique.
3. Study of Single Side Band Suppressed Carrier (SSB-SC) & Demodulation technique.
Code: EC 795C
List of experiments
VB 25/09/15 5000
AI 01/10/14 4000
1. Find the names of all employees who do not work in the department where P.sen is working.
2. Find the names of those employees of the department with dept-no 3 who get more salary than the
highest paid employee of the department with dept-no. 5.
3. Find the employee number of those employees who are not working in any project.
SCHEMAS
TABLES:
LEGEND:-
PNAME PROGRAMMER NAME, SPLACE STUDY PLACE, CCOST COURSE COST, DEVIN EVALUATEED IN,
SCOST SOFTWARE COST, DCOST EVALUATEMENT COST, PROF1 PROFICIENCY 1, PROF2 PROFICIENCY 2.
QUERIES:
1. Find out the selling cost average for packages Evaluateed in Oracle.
2. Display the names, ages, and experience of all programmers.
3. Display the names of those who have done the B.TECH ECE course.
4. What is the highest number of copies sold by a package?
5. Display the names and date of birth of all programmers born in April.
6. Display the lowest course fee.
7. Display the 2nd lowest course fee.
8. How many programmers have done the B.TECH ECE course.
9. How much revenue has been earned through the sale of packages Evaluateed in JAVA.
10. Display the details of software Evaluateed by Ram.
11. How many programmers studied at TICT.
12. Display the details of packages whose sales crossed the Rs.10000.
13. Find out the number of copies which should be sold in order to recover the Evaluatement cost of
each package.
14. Display the details of packages for which the Evaluatement cost has been recovered.
15. What is the price of costliest software Evaluateed in JAVA.
16. How many packages were Evaluateed in Oracle.
17. How many programmers studied at MIT.
18. How many programmers paid 20000 to 30000 for the course?
19. What is the average course fee?
20. Display the details of programmers knowing DBMS.
21. How many programmers know either JAVA or DBMS?
22. How many programmers dont know JAVA and DBMS?
23. How old is the oldest male programmer?
24. What is the average age of female programmers?
25. Calculate the experience in years for each programmer and display along with their names in
descending order.
26. Who are the programmers who celebrate their birthdays during the current month?
27. How many female programmers are there?
28. What are the languages known by the male programmers?
29. What is the average salary?
30. What is the 2nd highest salary?
31. How many people draw salary 5000 to 10000?
32. What is the 3rd lowest salary?
33. Display the details of those who dont know C, JAVA or DBMS.
34. Display the costliest package Evaluateed by each programmer.
35. Produce the following output for all the male programmers
Programmer
1. Construct a rectifier for a given average output dc voltage and a given load resistance.
2. Produce output from a Single stage audio frequency voltage amplifier with BJT for a
given Av, Zin and Zout.
4. Test the output of different digital circuit (FF, counter, multiplexers, demultiplexer
etc).