Академический Документы
Профессиональный Документы
Культура Документы
b. G75
c. G70
d. G74
Question 2 While writing the part program all the co-ordinates are specified with
Correct respect to part origin
False
False
False
False
False
False
Question 8 The ratio of heat required to melt the joint to net heat supplied is called as
Incorrect heat transfer efficiency
False
False
Question 10
Which of the following process is used for making small spot welds in
Correct gillette razor blades
Mark 1.00 out of
1.00
Select one:
a. EBM
b. ECM
c. EDM
d. LBM
Question 11 G90 with R Ve (R negative) is used for taper turning from larger
Incorrect daiameter to smaller diameter
False
False
Question 13 While calculating cooling rate in thin plates a three dimensional heat flow
Correct model is used
False
Question 14 Which of the following canned cycle is used for peck drilling process
Correct
Select one:
Mark 1.00 out of
1.00 a. G74
b. G76
c. G75
d. G70
False
b. EDM
c. PAM
d. WJM
False
False
Question 19
ECM is low voltage high current process
Correct
False
b. M08
c. G08
d. M03
False
False
Question 23 Heat transfer efficiency is very high in submerged arc welding process
Correct
Select one:
Mark 1.00 out of
1.00 True
False
False
False