Академический Документы
Профессиональный Документы
Культура Документы
PCR200-E0810-F1
Printed in Japan
The Unbeatable Furukawa PCR200
PCR200 Dimensions
CRAWLER ASSEMBLY
Sure traction on rough sites Ample mobility on rough terrain
The crawler uses parts originally designed. These Powerful 12HP air motors and a hydraulic oscillating
include the track-link crawler belts and track rollers. system permit good mobility and traction even on
The ruggedly constructed crawler demonstrates rough terrain. The motors provide adequate power to
effortless maneuverability on rough ground. It is also climb slopes while towing a compressor.
designed for easy maintenance.
Direct motor-connected final drive
Exceptional stability on soft ground The final drive is directly connected to the air motor
Shoe plate width is 300mm which is wider than that of to minimize power loss and ensure drive efficiency.
any other competitive model. Low ground-contact
pressure as well as a low center of gravity further Highly reliable automatic brake Specifications
ensure dependable traction on soft ground, too, and An automatic brake is incorporated inside the air
maximum stability during the drilling operation. Dimensions & Weight Hydraulic Units
motor and interlocked with the traction control valve.
Weight Approx. 5000kg Boom length 2000mm
Lifetime floating seals for minimum Power pump Overall length 5400mm Boom lift 45up, 25down
maintenance Single flange track roller
Feed travel 3710mm Boom swing 45right, 45left
Lifetime floating seals are Track length 2580mm Guide swing 50right, 50left
employed for the front Length of ground contact 1885mm ( 95right, 15left with pin change )
idlers and track rollers. Tow hitch height 550mm Guide tilt 180without pin change
This makes lubrication
Overall width 2390mm Power pump (Model MP12) 5HP
unnecessary over an
extended period of time. Track width 2200mm Drifter ( Model PD200 )
Width of grousers 300mm Weight without shank rod 180kg
Floating seal Traction Air Motor
Well-protected shoe links Overall height ( Boom lowered ) 1250mm Length without shank rod 1020mm
Track guards prevent the shoe links from dropping off Oscillating cylinder Ground clearance 280mm Cylinder diameter 130mm
and also help extend the life of the links. Crawler traction Piston stroke 80mm
Centralizer Ground pressure 0.45kg/cm2 Air consumption Approx. 16m3/min
Convenient crawler-tension adjustment Traveling speed 3.2km/h Blows / min Approx. 1600
Crawler tension may be hydraulically adjusted with
Guide shell ( towing a compressor on level ground )
the utmost ease by using a grease gun.
Gradeability 22 Main air hose connection 50mm
Take-up assembly
Oscillating angle 15 Specifications are subject to change without notice.
1. Reduction gear
2. 2-rotor gear motor
3. Shank rod
4. Valve plug
5. Valve
6. Valve chest
7. Chuck
8. Chuck driver
9. Blow tube
10. Piston
11. Cylinder