Академический Документы
Профессиональный Документы
Культура Документы
OWNER REFERENCE
RAPID
For Evaluation
FE1 TPX Only.
ROT SPN 0001 0004
CONTRACTOR REFERENCE
Rev. Page
FEED PHASE
60987R
0001 JSS 1020 9001
0 21 / 47
[6.10.4.6]
[6.11.1]
A dd to this clause:
Crankshafts shall have integrally forged coupling hubs except when applied in a pressurised and sealed
crankcase.
[6.11.2.1]
Replaceable precision-bored shell (sleeve) crankpin bearings and main bearings shall be used. Anti-
friction bearings are not acceptable. The application of aluminium or aluminium alloys in bearings is not
allowed.
[6.11.2.2 to 6.11.2.4]
[6.11.3]
A dd to this clause:
Big-end bolts larger then M30 shall be furnished with hydraulically tightened nuts.
[6.11.4]
A dd to this clause:
Designs in which the crosshead pin is clamped in the connecting rod or designs using forked connecting
[6.11.5]
A dd to this clause:
Crankcase explosion relief valves shall have a minimum throat area of 70 mm2 for each dm3 of the gross
crankcase contents.
[6.11.5]
A dd to this clause:
Crosshead housings bolted to the crank case shall be doweled in place after the alignment and piston rod
[6.12.1.1]
A dd to this clause:
Unless otherwise stated in the data/requisition sheet, the following type of distance piece is required:
[6.12.2.1]
Subject to the provision of Article 13 of the CONTRACT, TECHNIP hereby grant PETRONAS the copyright of this document. No part of this document may be reproduced, stored in a retrieval
system or transmitted in any form or by any means (electronic, mechanical, photocopying, recording or otherwise) without the permission of the copyright owner.