Академический Документы
Профессиональный Документы
Культура Документы
A~O! 30 .~B
(a) Gantt Plan
(c) Powan plan
(b) Halsey plan
(d) Bedaux plan
Hardness I~ I
carbon ~.
Hardnes [~J
.carbon %
68. A carbon steel having Brinell Hardness number
100 should ultimate tensile stt-ength closer it B .
(a) 100 N/rnm2 (b) 200 N/mm2 <YOUl
76. Dye penetrant method is generally used to locate 84. Which of the following derive system is used in
(a) core defects (b) surface defects computer Numerically controlled machine
(c) superficial defects (d) temporary defects tools?
(a) Stepper motor
77. Herbert cloudburst Hardness test is conducted (b) amorphous structure
to know (c) Thyristor controlled DC motor
(a) uniformity of hardness over a surface (d) Servo controlled pneumatIc dries.
(b) softness of non-metallic components
(c) hardness of non-metallic components
85. Dummy activities are used to
(d) hardness at specified depth inside the surface.
(a) determine critical path
(b) determine project completion time
78. Temperature required for full annealing in (C) maintain the required in a network
hyper-eutectoid steel is (d) facilitate computations of stack.
(a) 500C above upper critical temperature (AC,)
86. Machining of titanium is diJJicult due to
(b) 500C below upper critical temperate (AC,)
(0) high thermal conductivity of titanium
(c) 50C above lower critical temperature (AC1)
(b) Chemical reaction between tool and work
(d) 50C below lower critical temperamre (AC j
)
I) 1. Which of the foLLowing statement is incorrect 99. CLA value for Honing process is
with reference of lathe cutting tools? (a) 6 (b) 0.05 - 3.0
(a) The flank of the tool is the surface below and (c) 0.05 - 1.0 (d) 0.025 - 0.1
adjacent to the cutting edges
100. A machine costs Rs. 2000 installed. The cost of
(h) The nose is the corner, or chamfer joining the
repairs increases Rs. 40 annually. The scrap
side cutting and the end cutting edges
value of the machine is Rs. 200. The economic
(c) The heel is that part ofthe which is shaped to
repair life of the machine is nearly
produce the cutting edges and face
(a) 51/2 years (b) 71/2 years
(d) The base is that surface of the shank which 1
(c) 9 /2 years (d) 111/2 years
against the support and takes 'ngent
101. Which of the following would you prefer for
n. In metal cutting, use of loW eeds and high cutting
checking the hardness of thin .~ections ?
speeds is desired when the objective is
(a) Hebert cloud burst test
(a) high metal removal rate
(b) Shore's Scleroscope
(h) dry machining
(c) Knoop hardness test
(c) use of soft cutting tool
(d) Vickers hardness test
(d) surface finish,