Академический Документы
Профессиональный Документы
Культура Документы
ORGANIC ADDITIVES
DERIVED FROM NATURAL SOURCES
Introduction
Earth has been used for building
for thousands of years throughout
the world spanning a diverse range
of climates and cultures. Earth
itself is a multi-component system
usually consisting of stones, sand,
silt, clay, water and, near the
ground surface, organic humus.
Structural stability of earth
buildings is maintained by the
structural integrity of the sand and
stone framework, by the pore
filling capacity of the silt and,
Figure 1 Surface stabilisation of soil with palm oil,
most importantly, by the binding
Nigeria. Photo credit: CRATerre/EAG
qualities of the clay, which are in
turn influenced by the moisture
content of the soil.
Compared with some building materials earth can be considered to have some disadvantages
– it has relatively low compressive strength, tensile strength and abrasion resistance. It may
also lose a lot of its rigidity in the presence of water. Nevertheless it is very cheap, very
widely available, environmentally friendly, strongly linked to local cultures and traditions and,
with skilful construction, can contribute significantly to the aesthetic appeal and user comfort
of buildings.
Good and durable earth buildings can be built provided certain precautions are taken. These
precautions will depend on local conditions and structural requirements, but can broadly be
classified into four categories:
Soil selection
Different soils can have very different characteristics. The quality of a soil for building is
strongly dependant on grain size distribution and excluding humus.
Building design
The design should take account of the properties of the raw material by appropriate load
distribution and structural dimensions, and by incorporating protective elements against
damp, rain, impact and abrasion. Protection can be achieved by adding more durable but
complimentary materials at places such as the wall base, roof overhang and the copings, and
by using plasters and renders.
Practical Action, The Schumacher Centre for Technology and Development, Bourton on Dunsmore, Rugby,
Warwickshire, CV23 9QZ, UK
T +44 (0)1926 634400 | F +44 (0)1926 634401 | E infoserv@practicalaction.org.uk | W www.practicalaction.org
______________________________________________________________________________________________
Practical Action is a registered charity and company limited by guarantee.
Company Reg. No. 871954, England | Reg. Charity No.247257 | VAT No. 880 9924 76 |
Patron HRH The Prince of Wales, KG, KT, GCB
Additives to clay - Organic Practical Action
Compaction
Compaction increases the soil’s density and hence its strength and resistance to mechanical
damage. It also reduces water absorption but, with the associated reduction in porosity,
durability may be reduced.
Vegetable additives
Fibres
Fibres are widely used when
building with earth. Generally
fibres can be most easily mixed
in with the soil if it is in a plastic
or liquid state that is not too dry.
The fibres act to increase the
tensile strength, reduce density,
accelerate drying and reduce
cracking by dispersing stresses.
The most common fibres used include straw, for example from wheat, rice or barley. The
chaffs or husks of these crops can also be used. Other suitable vegetable fibres include hay,
hemp, millet, sisal, filao needles, and elephant grass. Cow dung and, less frequently, horse
and camel dung have also been used as additives because they contain short fibres which
make the soil workable for plastering and rendering. Synthetic fibres such as colophane,
steel or glass wool have found very limited application. Best results are obtained with fibre
reinforcement if the wet mix is prepared several days before use.
One drawback of vegetable fibre is variable durability. Dry fibres will generally last a very long
time but when wet they are liable to rot. Also some are attacked by insects, especially
termites, but others are not and often local knowledge exists to identify the most resistant
types.
2
Additives to clay - Organic Practical Action
Tannins
Tannins often act to disperse clay particles so that they coat sand grains in the soil more
evenly and, also help to break up clay lumps during compaction as well as reducing
permeability of the soil and improving water resistance.
The amount of tannin required varies from a small percentage of the mixing water for the
most active types to completely replacing the mixing water in the case of decoctions –
solutions obtained by boiling the natural products. In some regions of West Africa a decoction
of the bark of the “Néré” tree (parkia biglobosa) is used for surface protection and it can also
be used to stabilise gravelly soils with good results. Other tannins are prepared from the bark
of oak, chestnut and scorpioid acacia.
Gum arabic
This is a product obtained from the acacia tree. It acts primarily as a flocculant, that is it
helps to form flocs of clay particles within the soil which help to increase dry compressive
strength and slow down water absorption, hence reducing shrinkage. However, it is soluble in
water and so offers little protection to long-term moisture exposure. It is best used inside a
building, added at 5 to 10% proportions.
Palmo copal
Copal is a resin obtained from certain tropical trees. It is usually added at 3 to 8%
concentration to sandy soils. One variety, manilla copal, has waterproofing qualities.
Molasses
Dehydrated sugar molasses contain aldehydes which can be converted into polymers at high
temperatures with the aid of phenolic catalysts. The resinous material obtained is similar to
asphalt and other resins in its effects. It improves the strength and reduces permeability.
Normally a proportion of about 5% is used.
Animal additives
Care must be taken with animal products. In particular it is important that the animal has not
suffered from a contagious disease for humans, such as anthrax.
Fibres
Hair and fur from animals are used with plasters and renders to reduce shrinkage and improve
adhesion and impact resistance.
Excrements
These can contain chemicals such as phosphoric acid and potassium minerals which have
beneficial effects. In addition excrements contain fibres. Additions of up to a third are
possible, or even half for a finishing mix. Cow, horse or camel dungs are normally used. Goat
dung can be used to lighten the soil. It is normal practice to leave a soil and dung mix to
ferment for several days before use.
3
Additives to clay - Organic Practical Action
Urine
Horse urine, added to a soil, reduces its shrinkage and makes it more resistant to erosion. It
can replace the mixing water and is sometimes mixed in with straw before adding to soil. The
strong smell disappears on drying.
Blood
Animal blood, preferably in fresh rather than powdered form, can be an effective additive
when combined with lime or polyphenols.
Casein
Proteinic casein, in the form of whey – a product formed by the souring of milk, sometimes
mixed with animal blood, can be used for stabilisation. Milk powder has also been used. One
proprietary mix is known as Poulh’s soup and is a mixture of diluted casein and brick dust
beaten to a paste.
Animal glues
These improve strength and water resistance. They are made by boiling the skins and bones
of animals in water.
Termite mounds
Termite mound material can be mixed with soil for a stabilising effect. Termite mounds are
cemented with a cellulosic binder produced by the insects.
The precise quantities of additives often need to be determined empirically by trial and error
for each particular situation. The results of laboratory tests often cannot be transferred
directly to field practice, although they do provide useful guidance and a starting point for
field tests. In the field, relatively simple and inexpensive tests such as the observation of the
durability of blocks on soaking in water, and the use of a simple press to assess the load a
block can carry in flexure can provide information on stabiliser requirements. As preparation
of soil mixes and their use for building is often carried out under less rigorous conditions than
for testing a judicious compensatory increase in stabiliser dosage is recommended.
4
Additives to clay - Organic Practical Action
Contacts
CRATerre
Maison Levrat (Parc Fallavier)
B. P. 53, F-38092 Villefontaine -CEDEX
France
T +33 474 954391
F +33 474 956421
E craterre@club-internet.fr
W http://www.craterre.archi.fr
CRATerre is the international centre for earth construction at the school of Architecture in
Grenoble. CRATerre is a member of basin.
5
Additives to clay - Organic Practical Action
This technical brief was originally prepared for basin, Building Advisory Service
and Information Network.
Website: http://www.gtz.de/basin
This Technical Brief is possible thanks to the collaboration of DFID-UK and The Tony Bullard Trust.
Practical Action is a development charity with a difference. We know the simplest ideas can have the
most profound, life-changing effect on poor people across the world. For over 40 years, we have been
working closely with some of the world’s poorest people - using simple technology to fight poverty and
transform their lives for the better. We currently work in 15 countries in Africa, South Asia and Latin
America.