Академический Документы
Профессиональный Документы
Культура Документы
0 Contents
Sl.No. Particulars
Contents
1 Introduction
2 Profile of Bellary District
3 Map showing the location of MAH &
Potentially hazardous Industries
4 Objective, Extent and Scope of the plan
5 Synopsis of MAH Industries
6 Synopsis of Potentially Hazardous Industries.
7 Possible Hazards and Severity with dispersion
modules
8 Emergencies related to Transportation Safety
9 Off-site emergency network
10 Off-site Emergency Management
11 Functions of various Authorities
12 Resource Directory
13 Material Safety data sheets (In brief)
14 Acknowledgement
1
2.0 Introduction
Past and recent disasters, both man made (Technological) and Natural (Non
technological) have produced innumerable casualties and unimaginable harm to life
and property. It is well documented that in case where the organisation and the civil
authorities were prepared to handle the situation, the losses were significantly less
since these undesirable events occur suddenly and generally without immediate
warning, especially the technological disasters, the result is an emergency.
Incidents like Flexiborough, Sevaso, Mexico and Bhopal have brought in sharp focus,
aspect of hazards arising out of chemical factories and the severity of damage these
hazards can cause to the public around. This has led to widespread alarm and deep
concern .Though the management of factories and the authorities has responded to
the challenge and has introduced no. of measures to minimise the hazards, still one
can not forget the fact that accident can not be completely eliminated
“Zero Risk” simply does not exist. Hence the need for preparedness and planning for
containing any likely emergency quickly and to keep the damages the absolute
minimum is evident .The tragic drama that unfolded at Bhopal on that fateful night
brought out this stark reality very vividly. The absolute lack of planning and
unpreparedness for facing any kind of emergency led to gruesome consequences on
the unfortunate city.
These regulations speak out the guidelines for prevention and effective management
of hazardous materials and the dangerous results of violating the same.
It is imperative that the legislation alone cannot fulfill the objectives but need complete
cooperation and involvement of Industries, District Administration and the Public. It is
equally important that Contingency Plan coordinating the resources is prepared and
kept ready in full preparedness to handle any eventualities.
2
It is in this context the Bellary District Administration has taken initiatives in preparing
a comprehensive off site emergency plan for Bellary district to manage the
eventualities from the two hazardous industries located in the District.
Bellary district is having partly sandy and black cotton with red loamy soil suitable for
agricultural crops .The western parts of Bellary District is red loamy with hilly area
having rich minerals like iron ore of 65% ferrous and manganese ore of 40-48 %
manganese. Tungabhadra River flows from western parts to eastern parts of the
district.
The total population of Bellary district is 20.27 lakhs as per 2001 census. The rural
and urban breakup is 13.2 lakhs and 7.07 lakhs respectively. The district is having sex
ratio of 814 females per 842 males. The total geographical area of Bellary district is
813196 hectares out of which forest area is 97017 hectares.
There are about 322 registered factories located in the district under the purview of
the Factories Act 1948 out of which around 55 industries are considered as Industries
involving hazardous processes .Three Units viz., JSW Steels Ltd, Jindal Praxair
Oxygen Company Limited and Bellary Oxygen Company Ltd are classified as Major
Accident Hazard industries. For other industries having storages close to being
declared as Potentially Hazardous industries namely JSW Energy Ltd, Monsanto India
Limited ,United Galva Private Ltd and Pampasara distillery Ltd. M/s Bellary Thermal
power station which is expected to start generating power by the end of 2006 have
also been considered in evolving this plan.
3
4.0 Objectives, Extent & Scope of the Plan
The main objectives of the Off Site Emergency Plan are:
¾ To Provide resources and methods for effective control of emergencies arising out
the leakage ,explosion and fire due to hazardous materials ;
¾ To prevent emergency turning into disaster ;
¾ Synchronized action from all the coordinating agencies with least possible delay.
¾ To minimize damage to the property ,people and the environment
¾ Effective rescue operation and treatment of the causalities ;
¾ To train the people and the concerned to act efficiently and with confidence in an
emergency ;
¾ To bring back normal situation in the least possible time ;
¾ To provide authoritative information to the news media and government agencies ;
¾ No panic among the general public .No exploitation or exaggeration of the situation
by any agency.
The Off Site Emergency Plan is applicable to the following industries of Bellary.
The Scope of the plan is to mobilize all the resources through its Chief Disaster
Controller (CDC) to over see the effective implementation in achieving its objectives
and extend assistance to the needy.
4
5.0 Synopsis of Major Accident Hazardous Industries
The District Administration has identified seven industries as Hazardous Industries in
the district of Bellary. Out of these three industries have been classified as “Major
Accident Hazardous Units“. The Synopsis of the industries is as hereunder:
Activity:
Jindal Praxair Oxygen Co. Ltd has set up an Air separation Unit as an on site
installation for supplying gaseous oxygen, nitrogen and argon to M/S JSW Steels
Limited. A Back up product supply system comprising of storage tanks for liquid
oxygen & liquid nitrogen are available in order to meet the steel plant demand in the
case of unforeseen shut down of air separation plant. The plant is fully mechanized.
JPOCL is complied with the requirements of ISO 9001: 2000 and ISO 14001: 2004.
Shift Total
General Shift 68
( 9.00 am to 6.00 pm)
I Shift 06
( 6 am to 2 pm )
II Shift 12
( 2 pm to 10 pm )
III Shift 08
( 10 pm to 6 am )
TOTAL 94
5
: PRAXAIR HOUSE
No. 8, Ulsoor road
BANGALORE – 560 042
Phone: 080 – 25593889
6
5.2 M/s. JSW Steels Ltd.
Activity :
JSW Steel Limited (JSWSL) is an integrated steel plant with a capacity of 4.0 mtpa
HR coils. JSW Steel limited is an integrated steel project started way back in August
1994 and started its Integrated Steel Plant operation since 15th August 1999. Hot
strips Mill is the first division to come on stream on 23rd August 1997. On a backward
integration concept the project has started and other divisions RMHS, Corex, BOF-
CCP have gone on stream in August 1999. The Pellet Plant has come on stream on
28th Nov 2000.
JSWSL is complied with the requirements of ISO 9001; 2000 standard, the policy of
the Company ISO 14001; 96 and OHSAS – 18001; 99 standards.
7
Brief Description of hazardous materials stored & processed:
Shift Employees
General Shift 18
( 9.00 am to 6.00pm )
I Shift 06
( 6 am to 2 pm )
II Shift 06
( 2 pm to 10 pm )
III Shift 06
( 10 pm to 6 am )
TOTAL 036
8
Information of Important Officers:
Address :
Corporate address & phone no.
“ Oxygen House “:
BOC India Limited
143 , Taratala Road
Kolkatta 700 088
Phone :- 033-24014708
9
6.0 Synopsis of Potentially Hazardous Industries
Activity:
The JSW Energy Ltd. is located in the northeast corner of the JSW Steel Mill Plant
complex. The main plant building, structure and equipment are located in the southern
portion of the power plant site.
The power plant site consists of 94 hectares area. The thermal power plant mainly
consists of boiler, turbine, generator and other auxiliary systems.
The rated production capacity: Power Generation 2 units 260 MW (130 MW each)
10
6.2 M/s. Monsanto India Limited
Address : Sirivara Village
Kappagal – Post, Moka road
Bellary – Dist (Karnataka)
Activity :
Monsanto India Limited, LPG storage facility is situated on a land of 40 acres located
Sirivara Village, Moka road, Bellary.
The Main activities carried at the plant with LPG is drying of Maize wet cobs in the
month of February ,March and April ( wet season ) and September, October and
November ( Rabi Season ) for which LPG is used as a fuel, LPG is receiving Bulk
through Road tanker and stored in Bullets .
11
6.3 M/s. United Galva Private Limited
Address : Mundargi Industrial Area
126 B, 3rd Stage, Bangalore Road
Bellary – Dist. (Karnataka)
Activity :
M/s.United Galva Pct Ltd situated in Mundargi Industrial Area, Bellary is engaged in
the manufacturing of mild steel galvanized plain coils, mild steel galvanized plain
sheets and mild steel galvanized corrugated sheets. For the purpose of Galvanizing
furnace operation, the company is using LPG as fuel.
12
6.4 M/s. Pampasara Distillery limited , Hospet
Activity :
13
6.5 M/s.Bellary Thermal Power Station (KPCL)
(Proposed)
Activity :
The Bellary Thermal Power Station is located near Kudithini between Hospet & Bellary
town at a distance of 23 kms from Bellary and 40 kms from Hospet. The main plant
buildings, equipment and structures are located in the southern portion of the site.
Thermal power generation( 500MW) is the activity proposed to carryout out in the said
siteby employing about 300 workmen. The expected commissioning date scheduled
is December-2006. The Plant mainly consists of boiler, turbine, generator and other
auxiliary systems, which is under construction.
9 Hazard - Toxic
14
7.0 Possible Hazards and Severity
The Complete study of chemicals stored, used, transported & manufactured in these
units reveals that the hazards associated with these chemicals can be broadly
classified into four categories ;
¾ Fire
¾ Explosion
¾ Asphyxiation
¾ Toxic release
Exposure to cryogenic liquid (Severe frost bite / cold burn can result when cryogenic
liquid spills due to explosion)
For details please refer the enclosed Material Safety Data sheets annexure.
The toxic gas that can get released into the atmosphere from the factory
storage area is Corex / LD gas which contains carbonmonoxide a highly toxic gas.
Inert gas such as nitrogen in sufficient quantity in confined space will cause
starvation or asphyxiation resulting in death.
The Maximum accident credible scenario for toxic gases approximately works out to
be 720 M from the storage point.
15
Isopleth Simulation
Severity Analysis for Carbon Monoxide in Corex gas / Blast Furnace gas
– Industry Wise
16
Severity Analysis for Liquid Oxygen
17
18
9.0 EMERGENCIES RELATED TO TRANSPORTATION SAFETY
Accidents involving the transport of chemicals from JVSL,JTPCL and JPOCL are
rare. These industries are striving continually to prevent such accidents by:
Vehicle and packaging design, driver training, vehicle marking, readily available help
and back up for the police or fire brigade, all play their part in maintaining this record.
It is now mandatory in some of the states in India to carry a placard on road tankers
carrying chemical products. Using a code, called the Hazchem Emergency Action
Code, it provides information, which the emergency services, can quickly check and
understand. It tells them how to deal with a spillage, leak or fire.
The emergency information panel indicates correct technical name of the substance
being transported, hazard class label, UN number of the substance and telephone
number for emergency advice.
Tremcard
Drivers of vehicles carrying dangerous loads must carry details of what to do in an
emergency. This information is often provided in the form of Transport emergency
cards - or Tremcards as they are usually known. These cards are instantly
recognizable. The information they contain is laid out in consistent order. The cards
are always in the driver's cab in English and many a time in vernacular language. A
card identifies the chemical and describes the nature of the hazard. So the driver
always knows exactly what is being carried, and the immediate actions needed in the
event of an accident.
Employees trained in Safety and Emergency Handling of the product respond and act
in case of transportation Emergency involving products ,this involves contacting an
appropriate person with in organisation and assuring that contact is made between the
person requesting help and someone able to assist them.
19
FACTORS TO BE CONSIDERED TO HANDLE EMERGENCIES RESULTING DUE
TO VEHICLE ( TANKERS / TRAILERS ) COLLISION
2) Transportation Emergency
3) Transfer of liquid
For safely handling of transfer of liquid following is some of the general guideline
for the emergency response team members on such task of Emergency response
during major accidents
1) If in case of oxygen tankers, the accident vehicle should be shifted away from
the oil or any flammable areas before transfer of liquid is to be done
2) Use a dry, oil free drip pad incase of oxygen when the transfer of liquid is being
done on a ashphalted road.
3) Never decant the liquid from the vehicle met with an accident into a receiving
VITT ( Vacuum insulated Transport tanker ) when the former is in non-erect
position.
Ensure that the tanker safety valve setting receiving the liquid is equal to or greater
than the tanker met with an accident. Otherwise special care should be taken so that
this will not lead to safety valve venting in the vicinity of the decantation location. Also
there is a risk of rupture disc failure if the pressure setting is low.
20
10.0 Off-Site Emergency Management
On receipt of information from the Incident Controller of the Hazardous units about the
existence of off – site emergency , Chief Disaster Controller ( Deputy Commissioner )
will analyze & scrutinize the information as deemed necessary & thereafter notify the
off site emergency .CDC to operate from the HQ
The Incident controller will be responsible in combating the situation and keeps the
CDC well informed . During this period the responders will assist him in the mitigation
procedure. The incident controller will immediately see that initiating the required
measures shuts down the whole plant and guides the evacuees to the safe assembly
points as already planned at the site . Continuous Emergency Siren will be blown to
invite the attention of all the concerned .
The Deputy Commissioner / District Magistrate of Bellary District (herein after called
“Chief Disaster Controller “ in brief CDC) is the declarer of Off – Site Emergency. In
the absence of the Deputy Commissioner, the Head Quarter Asst to DC will assume
the role & act as chief Disaster Controller.
1. Declaration of emergency ;
2. Taking control of situation to mitigate the emergency ;
3. Dissemination / Acceptance of information to / from various agencies like rescue,
police ,fire,transportation,traffic control , medical aid, maintenance of rehabilitation
centre , rallying posts, parking yards ,supply of food & water for affected people &
the evacuees ,live stock
4. Mobilization of all resources to mitigate the emergency;
5. Establishing of safe rescue , evacuation of people, supplementing fire fighting /
rescue equipment at the site of emergency
6. Activation of various NGO’s / Voluntary organization for necessary materials;
7. Establishments liaison with public, media, kith & kin of the affected persons
8. Notifications of termination of emergency & declaration of all clear signal
9. Assessment of damage to human life, livestock, property, environment & provide
adequate relief for substence.
21
10.4 Emergency Control Room :
The Office of the Deputy Commissioner will be the control room . The control room will
be equipped in line with the control room at site / installation to the extent of serving as
an information cum communication centre.
Taking into the consideration the maximum accident credible scenario, Safety & Fire
Services Department at M/S JVSL and M/S JTPCL will be designated control rooms
for operation in the event of any emergency. Either of the two will be used as per
convenience. The control rooms are equipped with the following infrastructure facilities
.
The incident controller of the factory will shoulder the responsibility of combating
emergency till such period; the Chief Disaster Controller comes and assumes the
task. The Various responders who are involved in the mitigation procedure will work
under the advice of the Incident Controller .
The Parking yard facilities are to be parked for housing various rescue vehicles
,plant vehicles and Crisis Group Management vehicles related to emergency
It is located at a place which is at a Safe distance from respective units
To park the vehicles at different places, areas are identified.
The Number of persons likely to be affected has been assessed taking into
consideration the maximum credible accident scenario & provided . The rescue
shelters cum rallying posts identified .
22
10.7 Mobile Communication System (Convoy team);
The CDC in consultation with police will deploy as many communication vehicles
as required , fitted with public address system . VHF,Mobile talkies etc for
dissemination of correct information.depending upon the severity & type of
emergeny to safe guard the life of public & property
The Convoy team will be under direct control & contact of the CDC during the
continuance of emergency for conveying to the messages to public as directed by
the CDC & vice versa.
The Convoy team will be in constant touch with the Revenue authorities who
manages the rescue shelter cum rallying posts, parking yards etc & accordingly
initiate appropriate action in ensuring smooth vehicular traffic.
The Convoy team will also communicate the position of law & order, traffic
movement , the number of persons affected , live stock affected to CDC
An estimated account of number of persons likely to be affected industry wise is
given for ready reference at annexure 44
The CDC will undertake as on the spot study along with the concerned agencies to
assess the situation & declare termination of emergency
Then he will issue order for All clear Signal . All Clear Signal will be issued by
blowing intermittent siren for a period of 5 minutes .
10.9 Rehabilitation
The main function of police authorities would be to maintain law order , regular
patrolling of affected areas, establish rescue safe routes in advance for timely
response , cordoning off the area , control of traffic , shifting of all vehicles to the
parking yards
To render assistance in controlling and fighting disasters , salvage operations
rendering first aid and medical help ,shifting of the affected to rallying posts /
rescue shelters , deploying adequate protection at the rescue shelter and at the
place of incident .
Another important function would be identification of the deceased , informing their
relative , removal and disposal of dead bodies . Finally preparing of the list of
mising persons and take steps to trace them
23
11.1.1 Superintendent of Police , Bellary
The Officer will be overall incharge of the functions of police department in case of
OFF Site Emergency . He will receive the communication and instructions from
CDC from time to time in case of an Emergency arising outside JSW complex.
In case of any Major Emergency arising due to JSW complex operations,
SP,Bellary shall be briefed by the Incident Controller designated by JSW.
On receiving the information about the emergency from CDC, the office will rush to
the site , assess the situation, obtain first hand information , take control of
complete law and order and organize for additional requirement of men and home
guards if required
Arrange for necessary transportation for vehicles in cooperation with RTO
Arrange for necessary ambulance vans integrate the same in the medical facilities
in cooperation with the district health officer / deputy director animal husbandry for
evacuation of people and livestock respectively
In Confirmation with CDC , arrange for removal of dead bodies and will pass on
the information to the relatives of the deceased and will ensure disposal of bodies
after the formal procedure
Arrange for maintaining law and order at site of emergency , rescue shelters,
parking yards , main and cross roads leading to emergency site etc by instructing
the concerned
Pass on the regular information to the CDC about the actions on various issues .
He will in coordination with the traffic police immediately stops the vehicular traffic
in the Bellary – Hospet road entering from Bellary
The DSP traffic will be overall Incharge of traffic management who is assisted by
Circle inspector , Bellary in case of Off Site Emergency
Receive the communication about the off site emergency from CDC and
disseminate the information to all the sub ordinate forces and put them into action
for managing the various traffic points ,routes etc.
Receive the information from Incident controller of factory in case of an Emergency
arising inside JVSL Complex .
Mobilize necessary police personnel / vehicle to man and control the traffic on the
roads identified as safe routes and also take measures to divert or restrict normal
traffic in the emergency routes .
Ensure adequate number of vehicle available fitted with the public address system
and wireless etc and supervise manning of routes and parking yards
Initiate action to ensure adequate number of vehicles if required in consultation
with RTO , KSRTC.
His actions will be in concurrence with his superiors an CDC
24
11.1.3 Police Inspector, Toranagallu / Hospet /Bellary Rural
He will in coordination with the traffic police immediately stops the vehicular traffic
in the Hospet – Bellary road entering from Hospet.
The Officer will receive information from SP Bellary or site incharge of factory and
immediately rush to the site along with maximum possible personnel . He shall
help fire – fighting personnel in rescue operations
In view of close proximity of the police station to MAH units , the responders will
take immediate control of the emergency site and carry rescue operation in
coordination with site incharge
Alert all the sub ordinate officers coming under his jurisdiction and ensure their
availability at the site of emergency to maintain law and order , traffic , rescue ,
salvaging .
Ensure that the information is passed on to superior officers and necessary
instructions are received and adhered to ;
Ensure that all the anti social elements are identified and rounded off if required
His activities will be in acceptance with his superiors.
On receipt of emergency call, the fire officer will rush to the site of incident with all
crew members and equipment and start fighting the fire and control the gas
leakage .
Assist the police ,home guards and other rescue ,evacuation of persons ,salvage
operations etc
Continue to be in action till such time the District Fire Officer or his deputy arrives
at the place of incident and takes charge .From there onwards, he will continue to
assist the said officials .
25
Assist the on Site Emergency personnel in fighting emergency, rescuing injured /
affected people trapped in dangerous zones & participate in salvage operation .
Assistant medical / police personnel in imparting first aid.
Ensure availability of adequate water supply.
Maintain Constant contact and communicate the message to the CDC with regard
to control measures undertaken,salvage operations,rescue methods etc and any
other informations required by the CDC on continous basis.
Take any other appropriate actions as deemed necessary and in concurrence with
CDC in controlling the Emergency
He will be the over all in charge of Rescue Shelter / rallying pot & parking yard .
He will ensure adequate food and clothing in co-ordination with Dy Director of
Food and civil supplies
Voluntary organizations will function under the guidance of Asst Commissioner and
seeking his opinion
He will also ensure proper medical aid ( first aid as well as shifting of affected
persons in consultation with District Health Officer )
He will ensure adequate security & safety in Co – ordination with S.P of Bellary at
the site of emergency and at the rescue shelters.
In addition to these specific responsibilities , the A.C will assist the CDC in all other
matters as the case may be .
He will look after all the facilities required at rescue shelter / rallying past like food ,
clothing , medical aid ,water , electricity ,sanitation and other basic necessities in
coordination with respective Government agencies as well as voluntary
organization
He will manage & arrange for any other requirements on need basis at that point of
time in coordination with respective Government Authorities
He will alert all his subordinates and utilize their services to manage the rescue
shelters / rallying posts .
His action will be in concurrence from A.C – Hospet / Bellary.
District Health Officer ( DHO) will be the overall incharge of health and medical
services to be rendered at the site of emergency or at various rescue shelters ,
affected places,hospitals patholgy laboratories etc .
26
On receiving the information from CDC, he will contact all Hospital
Superintendents , Drug Controller, and Blood Banks for mobilization of required
Ambulance / Doctors/Nurses/Medicines / Life Saving drugs,Blood etc
Rush to the site,assess the extent of Severity & establish adequate TMCs (
Temporary Medical Centers ) .Ensure hygienic conditions at the rescue Shelter
cum rallying Post , temporary , medical centers .Take appropriate action in shifting
affected persons to hospitals either in Koppal or Hospet and ensure them
appropriate treatment .
Arrange for removal of dead bodies if any after post mortem and dispose the same
in consultation with CDC & SP
Render advises to CDC on precautionary measures to be taken by public at the
affected site / villages , rescue shelter cum rallying posts to prevent the out breaks
of epidemic diseases .
On receiving the information from CDC, the Environment officer will mobilize the
possible resource at his disposal and keep the laboratory functioning for analysis
of pollutants,emissions etc.
Rush to the site ,collect the sample,analyse the pollutants and the likely effect on
human life / environment and inform the CDC about the same & the corrective
actions to be taken to prevent for further damage
Act as an expert and advice the CDC about the kind of message to be
disseminated to the public and press etc on pollution matters .
27
17.0 Regional Transport Officer ( RTO )
The RTO will be the overall incharge for providing sufficient number of rescue
vehicles like trucks , buses , cars or any other type of transportation vehicles to the
emergency site / rescue shelter cum rallying post etc for transportation of human
beings as well as animals
Receive information from CDC and act accordingly
Mobilize all possible resources in arranging transportation vehicles in coordination
with KSRTC,Truck owners Association ,travel agencies etc also ensure availability
of adequate number of skilled drivers and advise the SP / DSP
Work out of requirement of heavy moving equipment like cranes etc and mobilize
the same in coordination with such agencies / parties .
19.0 KPTCL
28
21.0 Resource Directory:
21.1 Ambulances
No. of Distance from
Name of the place Phone No. Bellary in Kms.
SN Vehicles.
M/s. JSW Steel Limited, O8395-
Torngallu.
1 250120 to 130 04 45
2 M/s JSW Energy
08395-25 07 67 01 45
Company Limited
3 Basaveswara Medical 08392- 256 554,
01
Center 255 621
4 Mohan Nursing Home 08392-279 262 01
5 St. Mary’s Hospital 08392-242 007 01
6 Vijayanagar Institute of 242 327/
Medical Sciences(VIMS) 242 854 02 --
Bellary.
7 Gopi Blood Bank, Near 08392 – 258 318 01
Gandhi Nagar, Bellary
8 Smt. Vasanthi Devi 232003/4
Baldota Blood Bank, 231 901 01 65
Hospet.
29
21.3 District Crisis Group and officers involved in the Action Plan– Bellary
SN Description Telephone Number
Office Residence
1 Deputy Commissioner, Bellary 277 100 277 300
230 000
2 HQ Assistant, Bellary 277 204
3 Municipal Commissioner, Bellary 273 479
4 Chief Executive Officer, ZP, Bellary 267 555
5 Asst. Commissioner, Bellary 277413
6 Asst. Commissioner, Hospet 252209
7 Joint Director of Industries, DIC, Bellary 242 643
8 Superintendent of Police Bellary 258 400 266 333
9 Director of Factories & Boilers, Bangalore 080- 3530 584
6531 200
10 Deputy Director of Factories, Bellary 277 474
11 District Fire Officer, Bellary 231 933
Station Fire Officer, Bellary 266 001
12 Commandant f Home Guards 276 421
13 Environmental Officer, Bellary 228 365 278 183
Dy. Environmental Officer, Bellary 228 365 266 950
14 Dy. Chief Electrical Inspector, Bellary 267 648
Dy. Electrical Inspector, Bellary 267 648 256 674
15 VIMS Hospital – Director 242387
16 242327 /
VIMS Hospital – Medical Superintendent
242854
17 District Health Officer, Bellary 276 250
18 Asst. Director of Animal Husbandry, Bellary
19 Tahasildar, Bellary
20 District Controller NEKRTC, Bellary 26 71 67 / 73
21 Regional Transport Officer - RTO, Bellary
22 Supdt. Engineer, PWD, Bellary
30
Executive Engineer, PWD, Bellary 266 123
23 Dy. Director Food and Civil supplies
24 District Information & Broadcasting Officer,
Bellary
25 General Manager (Safety & Fire Service), JSW 283 088 240 420
26 Sr. Manager (Safety, Security, Fire Services), 250 801 240 268
JSW Energy
27 Manager - Safety, JPOCL 250 856
28 Dy. Chief Controller of Explosives, Mangalore 0824
441 588
31
21.5 FIRE STATIONS
32
21.7 Live – Stock around the Plants : 05 km radius
No. of Live-Stock
SN Place Cattle Buffalo Sheep Goat Dogs Hens/Chicken Total
1 Vaddu 230 55 2950 1290 125 1600 6250
2 Toranagallu 400 260 4000 1590 290 1240 7780
3 Kurekuppa 1350 500 4400 2000 210 3990 12450
4 Taluru 790 160 550 600 65 355 2520
5 Basapura 280 70 100 100 30 470 1050
6 Taranagar 850 235 175 870 260 1400 3790
7 Bannetti 320 115 1600 530 50 1565 4180
8 Nagalapura 440 70 40 280 45 1120 1995
9 Gangalapura 150 40 5 5 10 1000 1210
33
21.10 Transport Facilities
NEKRTC, Bellary Division, Bellary.
34
3 Toranagallu Govt. Higher Primary School 200 Yes
Govt. High School, Village 150 Yes
Govt. High School, Station 200 Yes
4 Taranagar Govt. Higher Primary School 200 Yes
Govt. High School 150 --
5 Kurekuppa Govt. Higher Primary School 200 --
6 Taluru Govt. Primary School 75 --
7 Basapura Govt. Primary School 100 --
8 Bannetti Govt. Primary School 75 --
9 Gangalapura Govt. Primary School 75 --
10 Bhuvanahalli Govt. Primary School 100 --
23.0 Acknowledgement
Off site emergency plan is prepared incompliance to the rules envisaged under
the Manufacture, Storage and Import of Hazardous Chemical Rules, 1989. The
document mainly consists of the roles and responsibilities of various responders in
case of any emergency in the district due to industrial disasters. Attempt has been
made to define the role and responsibilities taking into consideration of the possible
emergencies from the two major industries located in the district.
A resource directory has been placed at the end of the document, which provides
details about the resources required in the mitigation activities. I am sure that this
document be of immense help and serve the purpose.
I express my profound thanks to all the District Crisis Group members for their active
participation, valuable inputs and guidance in completing these tasks.
I express my heartfelt thanks to the major hazard industries for their immense co-
operation and overwhelming help at all stages of preparation of this document.
I would like to appreciate the officers of the Department of Factories and Boilers for
their total involvement and support.
35
Lastly, I express my thanks to everyone who supported and guided the district
administration directly and indirectly and made the preparation of this document
possible.
36